|
|
|
| RESEARCH ON TEMPERATURE CONTROL TECHNOLOGY FOR WINTER CONSTRUCTION OF TUNNEL CONCRETE LINING IN COLD REGIONS |
| TAN Xianjun1，CHEN Weizhong1，2，WANG Hui3，ZHAO Wusheng1 |
| (1. State Key Laboratory of Geomechanics and Geotechnical Engineering，Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，Wuhan，Hubei 430071，China；2. Geotechnical and Structural Engineering Research Center，Shandong University，Jinan，Shandong 250061，China；3. Department of Resources and Civil Engineering，Shandong University of Science and Technology，Tai?an，Shandong 271019，China) |
|
|
|
|
Abstract The cement can not hydrate sufficiently and uniformly at low temperature，so it?s easy to arouse rise the problem with lack of strength and appearing penetration cracks for tunnel concrete lining in cold regions during winter. According to the temperature control equation including low temperature phase transition，beginning with the study of influence of excavation time on temperature distribution of surrounding rock，considering the heat of hydration of concrete，the heat transfer law between surrounding rock and concrete lining was analyzed，and the influence of environment temperature in tunnel，heating temperature and time on the change rule of concrete temperature was studied. The results show that the influence scope of environmental temperature on the temperature of surrounding rock increased with the increase of excavation time；after a period of heated time，the temperature of surface and deep surrounding rock became higher than the middle?s，formed a temperature distribution of hot at two head，cold in the middle；the lowest temperature of concrete lining in 24 hours increased with increasing of heating time，heating temperature and environmental temperature. Based on this，a concise and practical heating time calculation formula was put forward. The in-situ results show that the goals were realized about the lining concrete can continuously and efficiently constructing，its surface has no crack and the actual strength＞C30 by applying the proposed calculation formula.
|
|
Received: 20 June 2012
|
|
|
|
| [1] 张勇进，李 源. 冬季混凝土受冻机理及施工温控技术[J]. 中外公路，2007，27(5)：123–126.(ZHANG Yongjin，LI Yuan. Frost mechanism of concrete and construction temperature control technology in winter[J]. Journal of China and Foreign Highway，2007，27(5)：123–126. (in Chinese))
[2] 夏才初，张国柱，肖素光. 考虑衬砌和隔热层的寒区隧道温度场解析解[J]. 岩石力学与工程学报，2010，29(9)：1 767–1 773.(XIA Caichu，ZHANG Guozhu，XIAO Suguang. Analytical solution to temperature fields of tunnel in cold region considering lining and insulation layer[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(9)：1 767–1 773.(in Chinese))
[3] 郭全生，朱明峰. 冬季大体积混凝土施工的控温及养护[J]. 混凝土，1997，(5)：46–47.(GUO Quansheng，ZHU Mingfeng. Temperature control and maintenance in the process of construction of mass concrete in winter[J]. Concrete，1997，(5)：46–47.(in Chinese))
[4] 唐 林，李正超. 满拉水利枢纽工程冬季混凝土施工措施[J]. 水利水电技术，2000，31(12)：32–33.(TANG Lin，LI Zhengchao. Concrete construction measures for Raman large-scale water projects in winter[J]. Water Resources and Hydropower Engineering，2000，31(12)：32–33.(in Chinese))
[5] 尚 军. 湾湾川隧道混凝土工程冬季施工技术方案[J]. 山西建筑，2010，36(17)：338–339.(SHANG Jun. Winter constructional technology plan for the concrete project of Wanwanchuan tunnel[J]. Shanxi Architecture，2010，36(17)：338–339.(in Chinese))
[6] 金连才. 西藏地区冬季混凝土施工利用太阳能供热的探讨[J]. 水力发电，2005，31(9)：42–43.(JIN Liancai. Discussions on the solar heat supply in the concrete construction in winter in Tibet Region[J]. Water Power，2005，31(9)：42–43.(in Chinese))
[7] 刘延熙，周昭强. 羊湖电站冬季混凝土施工技术措施[J]. 水利水电技术，1995，(1)：36–39.(LIU Yanxi，ZHOU Zhaoqiang. Construction measures for Yanghu power station in winter[J]. Water Resources and Hydropower Engineering，1995，(1)：36–39.(in Chinese))
[8] 迟宗立，任光月. 硫铝酸盐水泥在冬季泵送混凝土施工中的试验研究[J]. 混凝土，1999，(1)：44–46.(CI Zongli，REN Guangyue. Experimental research of sulphoaluminate cement in winter pumping concrete construction[J]. Concrete，1999，(1)：44–46.(in Chinese))
[9] 吕宝玉，单大力. 有关防冻泵送剂的若干思考[J]. 混凝土，2002，(9)：14–16.(LU Baoyu，SHAN Dali. Some considerations on anti-freezing pumping aid[J]. Concrete，2002，(9)：14–16.(in Chinese))
[10] 李秋启，公衍丽，王广通. 几种常见防冻剂各组分掺量对混凝土冬期施工的影响[J]. 混凝土，1997，(3)：49–51.(LI Qiuqi，GONG Yanli，WANG Guangtong. The influence of several common antifreezing admixture on the various components of the winter concrete construction[J]. Concrete，1997，(3)：49–51.(in Chinese))
[11] 韩亚飞. 浅谈沈阳市五爱隧道大体积混凝土冬季施工防裂抗渗技术措施[J]. 北方交通，2008，(7)：144–146.(HAN Yafei. Large volume concrete winter construction anti-cracking anti-permeability technical measures of Shenyang Wuai tunnel[J]. North Traffic，2008，(7)：144–146.(in Chinese))
[12] TAN X J，CHEN W Z，TIAN H M，et al. Water ?ow and heat transport including ice/water phase change in porous media：Numerical simulation and application[J]. Cold Regions Science and Technology，2011，68(1)：74–84.
[13] 谭贤君，陈卫忠，贾善坡，等. 含相变低温岩体水热耦合模型研究[J]. 岩石力学与工程学报，2008，27(7)：1 455–1 461.(TAN Xianjun，CHEN Weizhong，JIA Shanbo，et al. A coupled hydro- thermal model for low temperature rock including phase change[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(7)：1 455–1 461.(in Chinese))
[14] 谭贤君. 高海拔寒区隧道冻胀机制及其保温技术研究[博士学位论文][D]. 武汉：中国科学院武汉岩土力学研究所，2010.(TAN Xianjun. Study on the mechanism of frost heave of tunnel in cold region with high altitude and related insulation technology[Ph. D. Thesis][D]. Wuhan：Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，2010.(in Chinese))
[15] 熊 炜，刘明贵. 多年冻土区桩基温度场模型研究[J]. 岩土力学，2009，30(6)：1 658–1 664.(XIONG Wei，LIU Minggui. Temperature distribution along piles in permafrost regions[J]. Rock and Soil Mechanics，2009，30(6)：1 658–1 664.(in Chinese))
[16] 张学富，喻文兵，刘志强. 寒区隧道渗流场和温度场耦合问题的三维非线性分析[J]. 岩土工程学报，2006，28(9)：1 095–1 100. (ZHANG Xuefu，YU Wenbing，LIU Zhiqiang. Three-dimensional nonlinear analysis for coupled problem of seepage field and temperature field of cold regions tunnels[J]. Chinese Journal of Geotechnical Engineering，2006，28(9)：1 095–1 100.(in Chinese))
[17] 张正荣. 传热学[M]. 北京：高等教育出版社，1982：15–17. (ZHANG Zhengrong. Heat transfer[M]. Beijing：Higher Education Press，1982：15–17.(in Chinese))
[18] 苟 季. 大体积混凝土水化热对结构的影响研究[硕士学位论文][D]. 广西：广西大学，2008：20–23.(GOU Ji. Study on the effect of mass concrete hydration heat on structure[M. S. Thesis][D]. Guangxi：Guangxi University，2008：20–23.(in Chinese)) |
| [1] |
MAO Yuting1, 2, HE Manchao1, 2, LIU Fangzhou3, BAI Xing4, YANG Xiaojie1, 2, TAO Zhigang1, 2*. Development and application of a large-scale physical model system for tunnel creep testing[J]. , 2026, 45(6): 1627-1638. |
|
|
|
|
2013, Vol. 32 
