|
|
|
| SUPPORT RESISTANCE ANALYSIS FOR SPECIAL ROOF STRUCTURES UNDER ROOM MINING GOAF |
| WEI Like1，2，ZHANG Bin1，2，FU Xingyu1，2，WANG Yin1，2，LI Hongjie1，2 |
(1. Mine Safety Technology Branch，China Coal Research Institute，Beijing 100013，China；
2. State Key Laboratory of Coal Mining and Clean Utilization，China Coal Research Institute，Beijing 100013，China) |
|
|
|
|
Abstract A single rotary rock block model with the revised step voussoir beam was proposed and a formula calculating the working resistance was established. For the roof structure of the shallow fully-mechanized face，i.e.，31201 working face of Shigetai coal mine in Shendong mining area，three different conditions according to the overlying coal seam which was the solid coal，or the room and pillar goaf or the concentrated pillar in room and pillar goaf were considered so that the roof structures were proposed as a voussoir beam-single rotary rock block，a slight dislocation voussoir beam-single rotary rock block and a severe dislocation voussoir beam-single rotary rock block respectively. The mechanical model of the single rotary rock block was used to calculate the working resistance of support under different roof conditions in Shigetai coal mine. The results showed that the working resistances calculated with the model in different roof structures were correct and the crushing accident of the support cannot be avoided by increasing the working resistance only.
|
|
|
|
|
|
| [1] 弓培林，靳钟铭. 大采高综采采场顶板控制力学模型研究[J]. 岩石力学与工程学报，2008，27(1)：193–198.(GONG Peilin，JIN Zhongmin. Mechanical model study on roof control for fully- mechanized coal face with large mining height[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(1)：193–198.(in Chinese))
[2] 鞠金峰，许家林，朱卫兵，等. 7.0 m支架综采面矿压显现规律研究[J]. 采矿与安全工程学报，2012，29(3)：344–350.(JU Jinfeng，XU Jialin，ZHU Weibing，et al. Strata Behavior of fully-mechanized face with 7.0 m height support[J]. Journal of Mining and Safety Engineering，2012，29(3)：344–350.(in Chinese))
[3] 闫少宏，尹希文，许红杰，等. 大采高综采顶板短悬臂梁–铰接岩梁结构与支架工作阻力的确定[J]. 煤炭学报，2011，36(11)：1 816– 1 820.(YAN Shaohong，YIN Xiwen，XU Hongjie，et al. Roof structure of short cantilever-articulated rock beam and calculation of support resistance in full-mechanized face with large mining height[J]. Journal of China Coal Society，2011，36(11)：1 816–1 820.(in Chinese))
[4] 郭卫彬，刘长友，吴锋锋，等. 坚硬顶板大采高工作面压架事故及支架阻力分析[J]. 煤炭学报，2014，39(7)：1 212–1 219.(GUO Weibin，LIU Changyou，WU Fengfeng，et al. Analyses of support crushing accidents and support working resistance in large mining height workface with hard roof [J]. Journal of China Coal Society，2014，39(7)：1 212–1 219.(in Chinese))
[5] 许家林，鞠金峰. 特大采高综采面关键层结构形态及其对矿压显现的影响[J]. 岩石力学与工程学报，2011，30(8)：1 547–1 556.(XU Jialin，JU Jinfeng. Structural morphology of key stratum and its influence on strata behaviors in fully-mechanized face with super-large mining height[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(8)：1 547–1 556.(in Chinese))
[6] WANG J C，YANG S L，LI Y，et al. A dynamic method to determine the supports capacity in longwall coal mining[J]. International Journal of Mining Reclamation and Environment，2015，29(4)：277–288.
[7] 王继林，袁 永，屠世浩，等. 大采高综采采场顶板结构特征与支架合理承载[J]. 采矿与安全工程学报，2014，31(4)：512–518.(WANG Jilin，YUAN Yong，TU Shihao，et al. Roof structure characteristics in fully mechanized coalface with large mining height and reasonable loading of support[J]. Journal of Mining and Safety Engineering，2014，31(4)：512–518.(in Chinese))
[8] 王家臣，王 蕾，郭 尧. 基于顶板与煤壁控制的支架阻力的确 定[J]. 煤炭学报，2014，39(8)：1 619–1 624.(WANG Jiachen，WANG Lei，GUO Yao. Determining the support capacity based on roof and coal wall control[J]. Journal of China Coal Society，2014，39(8)：1 619– 1 624.(in Chinese))
[9] 潘 岳，王志强，李爱武. 周期来压前受超前隆起分布荷载作用的坚硬顶板弯矩和挠度的解析解[J]. 岩石力学工程学报，2012，31(10)：2 053–2 063.(PAN Yue，WANG Zhiqiang，LI Aiwu. Analytic solution of tight roof?s bending moment and deflection under swelling distributive supporting pressure[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(10)：2 053–2 063.(in Chinese))
[10] 潘 岳，王志强，李爱武. 初次断裂期间超前工作面坚硬顶板挠度、弯矩和能量变化的分析解[J]. 岩石力学与工程学报，2012，31(1)：178–179.(PAN Yue，WANG Zhiqiang，LI Aiwu. Analytic solutions of deflection，bending moment and energy change of tight roof of advanced working surface during initial fracturing[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(1)：178–179.(in Chinese))
[11] 潘 岳，顾士坦，戚云松. 初次来压前受超前增压荷载作用的坚硬顶板弯矩、挠度和剪力的解析解[J]. 岩石力学与工程学报，2013，32(8)：1 544–1 553.(PAN Yue，GU Shitan，QI Yunsong. Analytic solution of tight roof's bending moment，deflection and shear force under advanced supercharger load and supporting resistance before first weighting[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(8)：1 544–1 553.(in Chinese))
[12] 王 开，康天合，李海涛，等. 坚硬顶板控制放顶方式及合理悬顶长度的研究[J]. 岩石力学与工程学报，2009，28(11)：2 320–2 327. (WANG Kai，KANG Tianhe，LI Haitao，et al. Study of control caving methods and reasonable hanging roof length on hard roof[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(11)：2 320–2 327.(in Chinese))
[13] 于 雷，闫少宏，刘全明. 特厚煤层综放开采支架工作阻力的确 定[J]. 煤炭学报，2012，37(5)：737–742.(YU Lei，YAN Shaohong，LIU Quanming. Determination of support working resistance of top coal caving in extra thick coal seam[J]. Journal of China Coal Society，2012，37(5)：737–742.(in Chinese))
[14] 孔令海，姜福兴，王存文. 特厚煤层综放采场支架合理工作阻力研究[J]. 岩石力学与工程学报，2010，29(11)：2 312–2 318.(KONG Linghai，JIANG Fuxing，WANG Cunwen. Study of reasonable working resistance of support in fully-mechanized sublevel caving face in extra-thick coal seam[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(11)：2 312–2 318.(in Chinese))
[15] 黄庆享，钱鸣高，石平五. 浅埋煤层采场老顶周期来压的结构分析[J]. 煤炭学报，1999，24(6)：581–585.(HUANG Qingxiang，QIAN Minggao，SHI Pingwu. Structural analysis of main roof stability during periodic weighting in longwall face[J]. Journal of China Coal Society，1999，24(6)：581–585.(in Chinese))
[16] 侯忠杰. 对浅埋煤层“短砌体梁”、“台阶岩梁”结构与砌体梁理论的商榷[J]. 煤炭学报，2008，33(11)：1 201–1 204.(HOU Zhongjie. Concept of both short voussoir beam and step beam in shallow seam and voussoir beam theory[J]. Journal of China Coal Society，2008，33(11)：1 201–1 204.(in Chinese))
[17] 钱鸣高，石平五. 矿山压力与岩层控制[M]. 徐州：中国矿业大学出版社，2003：280–294.(QIAN Minggao，SHI Pingwu. Mine pressure and controlling of rock stratum[M]. Xuzhou：China University of Mining and Technology Press，2003：280–294.(in Chinese)) |
| [1] |
LI Botao1, 2, 3, TAN Yuxuan1, LIN Haifei4, 5*, WEI Jianping1, 2, 3, ZHANG Hongtu1, 2, 3, LI Shugang4, 5, WEI Zongyong4, 5, WANG Pei4, LUO Rongwei4, LIU Yanwei1, 2, 3. Mechanical properties and mesoscopic damage evolution of coal under liquid-nitrogen freezing at different initial temperatures[J]. , 2026, 45(6): 1757-1772. |
|
|
|
|
2015, Vol. 34 
