含裂隙岩石注浆加固后的弯曲疲劳性能试验研究

doi:10.13722/j.cnki.jrme.2018.0155

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (1487 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Neat epoxy resin(EP) and Dibutyl phthalate(DBP) modified epoxy resin were proposed and applied to grout the cracked rock for reinforcement. The cumulative damages of the neat EP grouted samples and DBP modified EP grouted samples under high-frequency three-point fatigue load were compared. The test results showed that the strength，the deflection，and the fatigue performance of cracked rock were obviously increased after grouting. In addition，the grouting effect and the fatigue resistance of the samples with toughened EP were much stronger than that of neat EP. The strain and the damage of samples after grouting reinforcement also exhibited the three-phase behavior(initial damage phase，stability phase，and acceleration phase). The double logarithmic fatigue life equation was established，which has an excellent correlation with the experimental results. Moreover，the damage of toughened EP grouted specimens was less significant than the neat EP grouted samples at the same cycle ratio. Stress level is one of the most important factors affecting the fatigue life.

Key words： rock mechanics three point bending fatigue damage epoxy toughening

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WANG Zhi
	LI Long

Cite this article:

WANG Zhi,LI Long. Experimental study on bending fatigue behavior of grouting reinforced rock with fracture[J]. , 2018, 37(8): 1823-1832.

URL:

https://rockmech.whrsm.ac.cn/EN/10.13722/j.cnki.jrme.2018.0155 OR https://rockmech.whrsm.ac.cn/EN/Y2018/V37/I8/1823

[1] ERIKSSON M，STILLE H. A method for measuring and evaluating the penetrability of grouts[J]. Geotechnical Special Publication，2003，(120)：1 326–1 337.
[2] 周维垣，杨若琼，剡公瑞. 二滩拱坝坝基弱风化岩体灌浆加固效果研究[J]. 岩石力学与工程学报，1993，12(2)：138–150.(ZHOU Weiyuan，YANG Ruoqiong，YAN Gongrui. Study on the efficacy of grouting reinforcement of slightly weathered rock masses at the ertan arch dam abutments[J]. Chinese Journal of Rock Mechanics and Engineering，1993，12(2)：138–150.(in Chinese))
[3] 葛家良，陆士良. 注浆模拟试验及其应用的研究[J]. 岩土工程学报，1997，19(3)：31–36.(GE Jialiang，LU Shiliang. Study on grouting simulation experiment and its application[J]. Chinese Journal of Geotechnical Engineering，1997，19(3)：31–36.(in Chinese))
[4] 张农，侯朝炯，陈庆敏. 岩石破坏后的注浆固结体的力学性能[J]. 岩土力学，1998，19(3)：50–52.(ZHANG Nong，HOU Chaojiong，CHEN Qinmin，DAI Biaobin. Mechanical properties of broken rock after grouting reinforcement[J]. Rock and Soil Mechanics，1998，19(3)：50–52.(in Chinese))
[5] 刘长武，陆士良. 水泥注浆加固对工程岩体的作用与影响[J]. 中国矿业大学学报，2000，29(5)：454–458.(LIU Changwu，LU Shiliang. Reinforcement effect of cement grouting on engineering rock mass[J]. Journal of China University of Mining and Technology，2000，29(5)：454–458.(in Chinese))
[6] 葛修润. 周期荷载作用下岩石大型三轴试件的变形和强度特征研究[J]. 岩土力学，1987，8(2)：11–19.(GE Xiurun. Study of deformation and strength behavior of the large-sized triaxial rock samples under cyclic loading[J]. Rock and Soil Mechanics，1987，8(2)：11–19.(in Chinese))
[7] 葛修润，卢应发. 循环荷载作用下岩石疲劳破坏和不可逆变形问题的探讨[J]. 岩土工程学报，1992，14(3)：56–60.(GE Xiurun，LU Yingfa. Study on fatigue failure and irreversible deformation problem of rock under cyclic load[J]. Chinese Journal of Geotechnical Engineering，1992，14(3)：56–60.(in Chinese))
[8] 葛修润，蒋宇，卢允德，等. 周期荷载作用下岩石疲劳变形特性试验研究[J]. 岩石力学与工程学报，2003，22(10)：1 581–1 585. (GE Xiurun，JIANG Yu，LU Yunde，et al. Testing study on fatigue deformation law of rock under cyclic loading[J]. Chinese Journal of Rock Mechanics and Engineering，2003，22(10)：1 581–1 585.(in Chinese))
[9] LIU J J，XIE H P，HOU Z M，et al. Damage evolution of rock salt under cyclic loading in uniaxial tests[J]. Acta Geotechnica，2014，9(1)：153–160.
[10] SUN B，ZHU Z D，SHI C，et al. Dynamic mechanical behavior and fatigue damage evolution of sandstone under cyclic loading[J]. International Journal of Rock Mechanics and Mining Sciences，2017，94：82–89.
[11] HE M，HUANG B，ZHU C，et al. Energy dissipation-based method for fatigue life prediction of rock salt[J]. Rock Mechanics and Rock Engineering，2018，51(5)：1 447–1 455.
[12] LIU Y，DAI F，DONG L，et al. Experimental investigation on the fatigue mechanical properties of intermittently jointed rock models under cyclic uniaxial compression with different loading parameters[J]. Rock Mechanics and Rock Engineering，2018， 51(1)：47–68.
[13] VOZNESENSKII A S，KRASILOV M N，KUTKIN Y O，et al. Features of interrelations between acoustic quality factor and strength of rock salt during fatigue cyclic loadings[J]. International Journal of Fatigue，2017，97：70–78.
[14] FAN J，CHEN J，JIANG D，et al. Fatigue properties of rock salt subjected to interval cyclic pressure[J]. International Journal of Fatigue，2016，90：109–115.
[15] 孙凌寒，邵国建，黄俊. 短纤维局部增强混凝土疲劳性能试验研究[J]. 试验力学，2009，10(5)：445–452.(SUN Linghan，SHAO Guojian，HUANG Jun. Experimental study of fatigue properties for partially short carbon fiber reinforced concrete[J]. Journal of Experimental Mechanics，2009，10(5)：445–452.(in Chinese))
[16] SUTHIWARAPIRAK P，MATSUMOTO T，KANDA T. Flexural fatigue failure characteristics of an engineered cementitious composite and polymer cement mortars[J]. Doboku Gakkai Ronbunshu，2002，718：121–134.
[17] 徐世烺，刘问. 超高韧性水泥基复合材料疲劳损伤模型试验[J]. 中国公路学报，2011，24(6)：1–8.(XU Shilang，LIU Wen. Fatigue Damage Model Test of Ultra-high Toughness Cementitious Composites[J]. China Journal of Highway and Transport，2011，24(6)：1–8.(in Chinese))
[18] 刘问，徐世烺，李庆华. 等幅疲劳荷载作用下超高韧性水泥基复合材料弯曲疲劳寿命试验研究[J]. 建筑结构学报，2012，33(1)：119–127.(LIU Wen，XU Shilang，LI Qinghua. Study on flexural fatigue life of ultra-high toughness cementitious composites under constant amplitude cyclic loading[J]. Journal of Building Structures，2012，33(1)：119–127.(in Chinese))
[19] TSENG D J，TSAI B R，CHANG L C. A case study on ground treatment for a rock tunnel with high groundwater ingression in Taiwan[J]. Tunnelling and Underground Space Technology，2001，16(3)：175–183.
[20] FUNEHAG J. Grouting of fractured rock with silica sol，grouting design based on penetration length[M]. [S. l.]：Chalmers University of Technology，2007：6–10.
[21] 张永兴，饶枭宇，唐树名，等. 预应力锚索注浆体与岩石黏结界面抗剪强度试验[J]. 中国公路学报，2008，21(6)：1–6.(ZHANG Yongxing，RAO Xiaoyu，TANG Shuming，et al. Experiment on shear strength of cementation plane between grout and rock in prestressed anchor[J]. China Journal of Highway and Transport，2008，21(6)：1–6.(in Chinese))
[22] NAUDTS A. Irreversible changes in the grouting industry caused by polyurethane grouting：an overview of 30 years of polyurethane grouting[M]// Grouting and Ground Treatment. [S. l.]：[s. n.]，2003：1 266–1 280.
[23] HODUL J，?LEBEK T，DROCHYTKA R. Development of epoxy grout containing fine waste from production of mineral wool board insulation[J]. Trans Tech Publications，2018，878：275–280.
[24] LIM S K，MOHDWARIDHUSSIN M W. Effect of filler on strength development of epoxy grout[J]. Malaysian Journal of Civil Engineering，2008，20(1)：38–46.
[25] BAGDE M N，PETROŠ V. Fatigue properties of intact sandstone samples subjected to dynamic uniaxial cyclical loading[J]. International Journal of Rock Mechanics and Mining Sciences，2005，42(2)：237–250.
[26] EWERT F K，HUNGSBERG U. Rock grouting at dam sites. professional practice in earth sciences[M]. [S. l.]：Springer，2018：14–20.
[27] 张明，毕忠伟，杨强，等. 锦屏一级水电站大理岩蠕变试验与流变模型选择[J]. 岩石力学与工程学报，2010，29(8)：1 530–1 538. (ZHANG Ming，BI Zhongwei，YANG Qiang，et al. Creep test and rheological model selection of marble of Jinping I hydropower station[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(8)：1 530–1 538.(in Chinese))
[28] 王志俭，殷坤龙，简文星，等. 三峡库区万州红层砂岩流变特性试验研究[J]. 岩石力学与工程学报，2008，27(4)：840–847.(WANG Zhijian，YIN Kunlong，JIAN Wenxing，et al. Experimental study on rheological behaviors of Wanzhou red sandstone in three gorges reservoir area[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(4)：840–847.(in Chinese))
[29] TEPFERS R. Tensile fatigue strength of plain concrete[J]. Journal of American Concrete Institute，1979，76(8)：919–934.
[30] 朱劲松，肖汝诚，宋玉普. 混凝土双轴抗压疲劳累积损伤规律试验研究[J]. 土木工程学报，2005，38(6)：104–109.(ZHU Jinsong，XIAO Rucheng，SONG Yupu. Experimental study on the cumulative fatigue damage of plain concrete under biaxial compression[J]. China Civil Engineering Journal，2005，38(6)：104–109.(in Chinese))
[31] 樊秀峰，简文彬. 砂岩疲劳特性的超声波速法试验研究[J]. 岩石力学与工程学报，2008，27(3)：557–563.(FAN Xiufeng，JIAN Wenbin. Experimental research on fatigue characteristics of sandstone using ultrasonic wave velocity method[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(3)：557–563.(in Chinese))
[32] 金解放，钟海兵，吴越，等. 静载荷与循环冲击作用下岩石损伤变量定义方法的选择[J]. 有色金属科学与工程，2013，4(4)：85–90.(JIN Jiefanga，ZHONG Haibinga，WU Yue，et al. Method selection for defining damage variable of rock subjected to static loadings and cyclic impacts[J]. Nonferrous Metals Science and Engineering，2013，4(4)：85–90.(in Chinese))