含裂隙岩石注浆加固后静动态力学性能试验研究

doi:10.13722/j.cnki.jrme.2020.0279

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (1001 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The static and dynamic mechanical responses of rock mass after grouting reinforcement are important for evaluating the safety and stability of rock engineering. In order to study the mechanical characteristics of grouting-reinforced rock under static and cyclic impact loads，the failure mechanism and damage evolution model of red sandstone samples of different grouting types were studied using the drop hammer impact test device. The test results show that specimens grouted by cement show poor reinforcement effect due to the low bonding performance and strength of the cement，while that resin grouting material can effectively improve the stress concentration caused by cracks and obtain a good reinforcement effect due to its high strength，toughness and good coordination with the rock. The maximum tension strain at the middle position of the cement grouting sample first increases rapidly and suddenly changes when the load reaches the peak value of the cement cracking load，while the strain changes of the specimens grouted by resin are smooth and there is no obvious mutation. All specimens，whether or not they are grouted，will be destroyed immediately when the impact energy is large enough. For both resin grouting specimens and un-cracked specimens，there is a clear double logarithmic linear relationship between the impact energy and the impact life，and the specimen will be damaged when the impact cumulative residual strain reaches the difference between the static peak strain and the dynamic peak strain. The damage evolution curve presenting an obvious three-stage change was obtained and verified by experiments of different grouting types and different impact energy. The damage evolution can better simulate the damage accumulation during the impact process.

Key words： rock mechanics grouting reinforcement cyclic impact loading failure mechanism damage strain

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WANG Zhi
	QIN Wenjing
	ZHANG Lijuan

Cite this article:

WANG Zhi,QIN Wenjing,ZHANG Lijuan. Experimental study on static and dynamic mechanical properties of cracked rock after grouting reinforcement[J]. , 2020, 39(12): 2451-2459.

URL:

https://rockmech.whrsm.ac.cn/EN/10.13722/j.cnki.jrme.2020.0279 OR https://rockmech.whrsm.ac.cn/EN/Y2020/V39/I12/2451

[1] EL TANI M. Grouting rock fractures with cement grout[J]. Rock Mechanics and Rock Engineering，2012，45(4)：547–561.
[2] FUNEHAG J，GUSTAFSON G. Design of grouting with silica sol in hard rock–New methods for calculation of penetration length，Part I[J]. Tunnelling and Underground Space Technology，2008，23(1)：1–8.
[3] 葛家良. 化学灌浆技术的发展与展望[J]. 岩石力学与工程学报，2006，25(增2)：3 384–3 392.(GE Jialiang. Development and prospect of chemical grouting techniques[J]. Chinese Journal of Rock Mechanics and Engineering，2006，25(Supp.2)：3 384–3 392.(in Chinese))
[4] 郝明辉，党玉辉，邢会歌，等. 水泥–化学复合灌浆在断层补强中的应用效果评价[J]. 岩石力学与工程学报，2013，32(11)：2 268–2 274. (HAO Minghui，DANG Yuhui，XING Huige，et al. Evaluation of application effect of cement-chemical compound grouting in fault reinforcement[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(11)：2 268–2 274.(in Chinese))
[5] LI S C，LI Z F，SHA F，et al. The development of new composite material for the grouting treatment of Ordovician limestone aquifer and performance tests[J]. Materials Research Innovations，2015，19(Supp.1)：252–255.
[6] 李术才，张霄，张庆松，等. 地下工程涌突水注浆止水浆液扩散机制和封堵方法研究[J]. 岩石力学与工程学报，2011，30(12)：2 377–2 396.(LI Shucai，ZHANG Xiao，ZHANG Qingsong，et al. Research on mechanism of grout diffusion of dynamic grouting and plugging method in the water inrush of underground engineering[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(12)：2 377–2 396.(in Chinese))
[7] 刘人太，李术才，张庆松，等. 一种新型动水注浆材料的试验与应用研究[J]. 岩石力学与工程学报，2011，30(7)：1 454–1 459.(LIU Rentai，LI Shucai，ZHANG Qingsong，et al. Experiment and application research on a new type of dynamic water grouting material[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(7)：1 454–1 459.(in Chinese))
[8] 王文学，翟守俊. 水泥注浆与化学注浆加固破碎岩石对比试验[J].工程地质学报，2010，18(增1)：322–326.(WANG Wenxue，ZHAI Shoujun. Comparison experiment of the mechanical behaviors of cement and chemical material grouted fractured rocks[J]. Journal of Engineering Geology，2010，18(Supp.1)：322–326.(in Chinese))
[9] 许宏发，耿汉生，李朝甫，等. 破碎岩体注浆加固体强度估计[J]. 岩土工程学报，2013，35(11)：2 018–2 022.(XU Hongfa，GENG Hansheng，LI Caofu，et al. Estimating strength of grouting reinforced bodies in broken rock mass[J]. Chinese Journal of Geotechnical Engineering，2013，35(11)：2 018–2 022.(in Chinese))
[10] 陆银龙，贺梦奇，李文帅，等. 岩石结构面注浆加固微观力学机制与浆–岩黏结界面结构优化[J]．岩石力学与工程学报，2020，39(9)： 1 808–1 818.(LU Yinlong，HE Mengqi，LI Wenshuai，et al. Micromechanical mechanisms of grouting reinforcement in rock joints and the microstructure optimization of grout-rock bonding interface[J]. Chinese Journal of Rock Mechanics and Engineering，2020，39(9)：1 808–1 818. (in Chinese))
[11] 刘泉声，雷广峰，卢超波，等. 注浆加固对岩体裂隙力学性质影响的试验研究[J]. 岩石力学与工程学报，2017，36(增1)：3 140–3 147. (LIU Quansheng，LEI Guangfeng，LU Chaobo，et al. Experimental study of grouting reinforcement influence on mechanical properties of rock fracture[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(Supp.1)：3 140–3 147.(in Chinese))
[12] 刘长武，陆士良. 水泥注浆加固对工程岩体的作用与影响[J]. 中国矿业大学学报，2000，29(5)：454–458.(LIU Changwu，LU Shiliang. Reinforcement effect of cement grouting on engineering rock mass[J]. Journal of China University of Mining and Technology，2000，29(5)：454–458.(in Chinese))
[13] BOLTON M D，MCKINLEY J D. Geotechnical properties of fresh cement grout-pressure filtration and consolidation tests[J]. Géotechnique，1997，47(2)：347–352.
[14] 刘彦伟，程远平，李国富. 高性能注浆材料研究与围岩改性试验[J]. 采矿与安全工程学报，2012，29(6)：821–826.(LIU Yanwei，CHEN Yuanping，LI Guofu. Research on high performance grouting material and improving surrounding rock mass strength[J]. Journal of Mining and Safety Engineering，2012，29(6)：821–826.(in Chinese))
[15] 王志，李龙. 含裂隙岩石注浆加固后的弯曲疲劳性能试验研究[J]. 岩石力学与工程学报，2018，37(8)：1 823–1 832.(WANG Zhi，LI Long. Experimental study on bending fatigue behavior of grouting reinforced rock with fracture[J]. Chinese Journal of Rock Mechanics and Engineering，2018，37(8)：1 823–1 832.(in Chinese))
[16] 詹金武，李涛. 破碎泥岩注浆结石体动力特性的SHPB试验及其数值模拟研究[J]. 岩土力学，2017，38(7)：2 096–2 102.(ZHAN Jinwu，LI Tao. SHPB tests and numerical simulation of dynamic behavior of grouting-reinforced fractured mudstone[J]. Rock and Soil Mechanics，2017，38(7)：2 096–2 102.(in Chinese))
[17] LI X B，GONG F Q，TAO M，et al. Failure mechanism and coupled static-dynamic loading theory in deep hard rock mining：A review[J]. Journal of Rock Mechanics and Geotechnical Engineering，2017，9(4)：767–782.
[18] ZHOU Z L，CAI X，LI X B，et al. Dynamic response and energy evolution of sandstone under coupled static-dynamic compression：insights from experimental study into deep rock engineering applications[J]. Rock Mechanics and Rock Engineering，2020，53：1 305–1 331.
[19] YIN T B，BAI L，LI X，et al. Effect of thermal treatment on the mode I fracture toughness of granite under dynamic and static coupling load[J]. Engineering Fracture Mechanics，2018，199：143–158
[20] WENG L，LI X B，TAHERI A，et al. Fracture evolution around a cavity in brittle rock under uniaxial compression and coupled static-dynamic loads[J]. Rock Mechanics and Rock Engineering，2018，51(2)：531–545.
[21] 金解放，李夕兵，邱灿，等. 岩石循环冲击损伤演化模型及静载荷对损伤累积的影响[J]. 岩石力学与工程学报，2014，33(8)：1 662–1 671.(JIN Jiefang，LI Xibing，QIU Can，et al. Evolution model for damage accumulation of rock under cyclic impact loadings and effect of static loads on damage evolution[J]. Chinese Journal of Rock Mechanics and Engineering，2014，33(8)：1 662–1 671.(in Chinese))
[22] 闫雷，刘连生，李仕杰，等. 单轴循环冲击下弱风化花岗岩的损伤演化[J]. 爆炸与冲击，2020，40(5)：93–102.(YAN Lei，LIU Liansheng，LI Shijie，et al. Damage evolution of weakly weathered granite under uniaxial cyclic impact[J]. Explosion and Shock Waves，2020，40(5)：93–102.(in Chinese))
[23] SHU R H，YIN T B，LI X B，et al. Effect of thermal treatment on energy dissipation of granite under cyclic impact loading[J]. Transactions of Nonferrous Metals Society of China，2019，29(2)：385–396.
[24] 王志亮，杨辉，田诺成. 单轴循环冲击下花岗岩力学特性与损伤演化机制[J]. 哈尔滨工业大学学报，2020，52(2)：59–66.(WANG Zhiliang，YANG Hui，TIAN Nuocheng. Mechanical property and damage evolution mechanism of granite under uniaxial cyclic impact[J]. Journal of Harbin Institute of Technology，2020，52(2)：59–66.(in Chinese))
[25] 刘杰，冯世国，李天斌，等. 冲击荷载作用下岩石动态响应预测研究[J]. 岩土工程学报，2018，40(11)：2 022–2 030.(LIU Jie，FENG Shiguo，LI Tianbin，et al. Prediction of dynamic response of rock under impact loads[J]. Chinese Journal of Geotechnical Engineering，2018，40(11)：2 022–2 030.(in Chinese))
[26] 高锋，甘德清，张静辉，等. 磁铁石英岩落锤冲击破碎效果与能量关系[J]. 哈尔滨工业大学学报，2020，52(4)：160–169.(GAO Feng，GAN Deqing，ZHANG Jinghui，et al. Relation of crushing effect of magnetite-quartzite to energy under drop weight impact[J]. Journal of Harbin Institute of Technology，2020，52(4)：160–169.(in Chinese))
[27] WANG Z，LI L，GUO S C，et al. Nonlinear fatigue damage of cracked cement paste after grouting enhancement[J]. Applied Sciences-Basel，2018，8(7)：1 105.
[28] 吴永端. 应变花应力分析的图解法[J]. 南京航空航天大学学报，1980，(1)：128–150.(WU Yongduan. A graphical method of stress analysis strain rosette[J]. Journal of Nanjing University of Aeronautics and Astronautics，1980，(1)：128–150.(in Chinese))