脆岩超大断面隧道双层初支支护时机研究

doi:10.13722/j.cnki.jrme.2023.0377

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (2460 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract By improving the existing failure approach theory，a safety evaluation index(BRSI) for assessing the mechanical state of brittle rock masses is established，enabling a quantitative expression of the elastic state，strain hardening state，brittle failure and residual state of brittle rock masses. Based on the quantitative relationship between the mechanical state of brittle surrounding rock and the BRSI index，a novel approach is proposed to determine the optimal timing for double-layer primary support during the sequential excavation of super-large section tunnels in brittle rock masses. The proposed method is analyzed and validated through three-dimensional numerical simulations conducted in the Xiabeishan Tunnel project. The results demonstrate that：(1) Under a low confining pressure，tuff undergoes brittle failure immediately upon reaching its ultimate strength. With the increase of the confining pressure，however，tuff shows the characteristics of gradual softening. (2) During tunnel construction，the development of BRSI value of the surrounding rock undergoes three stages as initial development，rapid development and gradual stabilization. (3) The excavation of the rock pillar of the middle pilot tunnel alters the stress state and failure mode of the tunnel wall?s surrounding rock，resulting in the optimal support timing for the middle pilot tunnel lagging behind the side pilot tunnels by 2–10 m. (4) The mechanical state of brittle surrounding rock can be accurately and intuitively characterized by BRSI index，and the proposed method for determining support timing is reasonable and reliable.

Key words： tunnelling engineering failure approach index brittle rock mass super-large section tunnel sequential excavation double-layer primary support support time

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	HE Jiaxin1
	HE Shaohui1
	LIU Xiabing2
	MA Jianfei1

Cite this article:

HE Jiaxin1,HE Shaohui1,LIU Xiabing2, et al. Study on supporting time of double-layer primary support for super-large section tunnels in brittle rock#br#[J]. , 2023, 42(12): 3010-3019.

URL:

https://rockmech.whrsm.ac.cn/EN/10.13722/j.cnki.jrme.2023.0377 OR https://rockmech.whrsm.ac.cn/EN/Y2023/V42/I12/3010

[1]	张德华，雷可，谭忠盛，等. 软岩大变形隧道双层初期支护承载性能对比试验研究[J]. 土木工程学报，2017，50(增2)：86-92.(ZHANG Dehua，LEI Ke，TAN Zhongsheng，et al. Field test on bearing and deformation properties of double primary layers applied to large deformation tunnel in weak rock[J]. China Civil Engineering Journal，2017，50(Supp.2)：86-92.(in Chinese))
[2]	张俊儒，欧小强，郑强，等. 超大断面隧道在双层初期支护下的拆撑安全性研究[J]. 现代隧道技术，2018，55(6)：108-116. (ZHANG Junru，OU Xiaoqiang，ZHENG Qiang，et al. On safety in dismantling temporary strut of super-large tunnels with double-layer primary support[J]. Modern Tunnelling Technology，2018，55(6)：108-116.(in Chinese))
[3]	司剑钧. 极高地应力软岩隧道双层支护技术[J]. 隧道建设，2014，34(7)：685-690.(SI Jianjun. Technologies for double-shell support of tunnels in soft rock with extra-high ground stress[J]. Tunnel Construction，2014，34(7)：685-690.(in Chinese))
[4]	钟友江，刘世杰，吴建和. 双层初期支护在云屯堡隧道高地应力软岩洞段中的应用[J]. 隧道建设，2020，40(1)：90-98.(ZHONG Youjiang，LIU Shijie，WU Jianhe. Application of double primary support to high geostress soft rock section of Yuntunbao Tunnel[J]. Tunnel Construction，2020，40(1)：90-98.(in Chinese))
[5]	李国良，朱永全. 乌鞘岭隧道高地应力软弱围岩大变形控制技术[J]. 铁道工程学报，2008，(3)：54-59.(LI Guoliang，ZHU Yongquan. Control technology for large deformation of highland stressed weak rock in Wushaoling tunnel[J]. Journal of Railway Engineering Society，2008，(3)：54-59.(in Chinese))
[6]	邱瑞成. 千枚岩堆积体大变形隧道双层初期支护关键技术研究[硕士学位论文][D]. 成都：西南交通大学，2016.(QIU Ruicheng. Study on mechanical properties of double layer for large deformation tunnel with stacked phyllite[M. S. Thesis][D]. Chengdu：Southwest Jiaotong University，2016.(in Chinese))
[7]	黄新梅. 隧道双层支护及双层衬砌试验研究—以兰渝铁路两水隧道为例[硕士学位论文][D]. 西安：长安大学，2014.(HUANG Xinmei. Study of double support and double lining of tunnel—a case study on two water tunnel of Lanzhou—Chongqing railway[M. S. Thesis][D]. Xi?an：Chang?an University，2014.(in Chinese))
[8]	洪军，张俊儒. 全风化花岗岩地层特大断面隧道施工过程支护受力分析[J]. 隧道建设，2016，36(7)：787-792.(HONG Jun，ZHANG Junru. Analysis of support stress of extra-large cross-section tunnel during construction in fully weathered granite strata[J]. Tunnel Construction，2016，36(7)：787-792.(in Chinese))
[9]	韩常领，张天，徐晨，等. 大断面软岩隧道变形特征及多层初支控制研究[J]. 公路，2021，66(1)：335-339.(HAN Changling，ZHANG Tian，XU Chen，et al. Research on the deformation characteristics of soft rock tunnel with large section and the deformation control with multi-layer support[J]. Highway，2021，66(1)：335-339.(in Chinese))
[10]	李国良，宋冶，李雷，等. 大断面黄土隧道台阶法双层支护技术[J]. 中国工程科学，2014，16(8)：54-63.(LI Guoliang，SONG Ye，LI Lei，et al. Double-layer support technology of large-section loess tunnel by benching method[J]. Strategic Study of CAE，2014，16(8)：54-63.(in Chinese))
[11]	雷可. 裂隙岩体深埋隧道大变形控制研究[硕士学位论文][D]. 北京：北京交通大学，2018.(LEI Ke. Research on large deformation control of deep-buried tunnel in fractured rock mass[M. S. Thesis][D]. Beijing：Beijing Jiaotong University，2018.(in Chinese))
[12]	巫明健. 兰渝铁路两水隧道软岩开挖及支护技术研究[硕士学位论文][D]. 成都：西南交通大学，2011.(WU Mingjian. Study about tunnel excavation and supporting technology in soft rock on two water tunnel of Lanyu road[M. S. Thesis][D]. Chengdu：Southwest Jiaotong University，2011.(in Chinese))
[13]	陈俊武. 挤压性围岩隧道双层支护和可让式支护比较研究[硕士学位论文][D]. 北京：北京交通大学，2021.(CHEN Junwu. A comparative study on double-layer support and yielding support for tunneling in squeezing rocks[M. S. Thesis][D]. Beijing：Beijing Jiaotong University，2021.(in Chinese))
[14]	ZHANG C Q，ZHOU H，FENG X T. An index for estimating the stability of brittle surrounding rock mass：FAI and its engineering application[J]. Rock Mechanics and Rock Engineering，2011，44(4)：401-414.
[15]	张传庆. 基于破坏接近度的岩石工程安全性评价方法的研究[博士学位论文][D]. 武汉：中国科学院研究生院，2006.(ZHANG Chuanqing. Study on method of safety evaluation for rock engineering based on failure approach index[Ph. D. Thesis][D]. Wuhan：University of Chinese Academy of Sciences，2006.(in Chinese))
[16]	马春景，姜谙男，江宗斌，等. 基于单元状态指标的盾构隧道水-力耦合模拟分析[J]. 岩土力学，2017，38(6)：1 762-1 770.(MA Chunjing，JIANG Annan，JIANG Zongbin，et al. Hydro-mechanical coupled simulation and analysis of shield tunnel construction based on the zone state index[J]. Rock and Soil Mechanics，2017，38(6)：1 762-1 770.(in Chinese))
[17]	姜谙男，权张，许梦飞，等. 基于Hoek-Brown准则的隧道围岩改进单元安全度分析[J]. 中国公路学报，2020，33(7)：135-144. (JIANG Annan，QUAN Zhang，XU Mengfei，et al. Analysis of Improved zone safety index of tunnel surrounding rock based on Hoek-Brown criterion[J]. China Journal of Highway and Transport，2020，33(7)：135-144.(in Chinese))
[18]	张振华，钱明明，位伟. 基于改进破坏接近度的千将坪岸坡失稳机制分析[J]. 岩石力学与工程学报，2018，37(6)：1 371-1 384. (ZHANG Zhenhua，QIAN Mingming，WEI Wei. Analysis of failure mechanism of Qianjiangping slope based on improved failure approach index[J]. Chinese Journal of Rock Mechanics and Engineering，2018，37(6)：1 371-1 384.(in Chinese))
[19]	张传庆，周辉，冯夏庭. 基于破坏接近度的岩土工程稳定性评价[J]. 岩土力学，2007，28(5)：888-894.(ZHANG Chuanqing，ZHOU Hui，FENG Xiating. Stability assessment of rockmass engineering based on failure approach index[J]. Rock and Soil Mechanics，2007，28(5)：888-894.(in Chinese))
[20]	裴峰. 纱岭金矿深部地层岩体力学性能与深竖井围岩稳定性分析及控制[博士学位论文][D]. 北京：北京科技大学，2020.(PEI Feng. Mechanical properties of rock in deep stratum and analysis and control of shaft surrounding rock stability in Shaling Gold Mine[Ph. D. Thesis][D]. Beijing：University of Science and Technology Beijing，2020.(in Chinese))
[21]	梁鹏. 基于应变软化的深埋隧道稳定性分析及安全控制技术研究[博士学位论文][D]. 北京：北京科技大学，2022.(LIANG Peng. Study on stability analysis and safety control technology of deep buried tunnel based on strain softening model[Ph. D. Thesis][D]. Beijing：University of Science and Technology Beijing，2022.(in Chinese))
[22]	周辉，张传庆，冯夏庭，等. 隧道及地下工程围岩的屈服接近度分析[J]. 岩石力学与工程学报，2005，24(17)：3 083-3 087.(ZHOU Hui，ZHANG Chuanqing，FENG Xiating，et al. Analysis of rock mass stability in tunnel and underground engineering based on yield approach index[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(17)：3 083-3 087.(in Chinese))
[23]	柳群义，朱自强，钟正强，等. 基于Hoek-Brown准则的隧道围岩屈服接近度分析[J]. 岩土力学，2009，30(8)：2 447-2 451.(LIU Qunyi，ZHU Ziqiang，ZHONG Zhengqiang，et al. Yielding approach index for surrounding rock mass of tunnel based on Hoek-Brown criterion[J]. Rock and Soil Mechanics，2009，30(8)：2 447-2 451.(in Chinese))
[24]	中华人民共和国国家标准编写组. GB/T 50266—2013 工程岩体试验方法标准[S]. 北京：中国计划出版社，2013.(The National Standards Compilation Group of People?s Republic of China. GB/T 50266—2013 Standard for test methods of engineering rock mass[S]. Beijing：China Planning Press，2013.(in Chinese))
[25]	TU H L，QIAO C S，HAN Z M. Elastic-brittle-plastic analysis of the radial subgrade modulus for a circular cavity based on the generalized nonlinear unified strength criterion[J]. Tunnelling and Underground Space Technology，2018，71：623-636.
[26]	沈新普，岑章志，徐秉业. 弹脆塑性软化本构理论的特点及其数值计算[J]. 清华大学学报：自然科学版，1995，35(2)：22-27.(SHEN Xinpu，CEN Zhangzhi，XU Bingye. The characteristics of elasto-brittle-plastic softening constitutive theory and its numerical calculation[J]. Journal of Tsinghua University(Sci & Tech)，1995，35(2)：22-27.(in Chinese))
[27]	刘文政，徐秉业. 脆塑性厚壁壳体的稳定条件[J]. 固体力学学报，1989，(1)：71-76.(LIU Wenzheng，XU Bingye. The stability condition of brittle-plastic thick-walled shells[J]. Acta Mechanica Solida Sinica，1989，(1)：71-76.(in Chinese))
[28]	郑宏，葛修润，李焯芬. 脆塑性岩体的分析原理及其应用[J]. 岩石力学与工程学报，1997，16(1)：8-21.(ZHENG Hong，GE Xiurun，LI Zhuofen. Analysis principle for rock mass with brittle-plasticity and its applications[J]. Chinese Journal of Rock Mechanics and Engineering，1997，16(1)：8-21.(in Chinese))
[29]	刘夏冰，贺少辉，汪大海，等. 浅埋超大跨四线高铁隧道施工期初期支护体系的力学特性[J]. 中国铁道科学，2021，42(6)：90-102. (LIU Xiabing，HE Shaohui，WANG Dahai，et al. Mechanical characteristics of primary support system at construction phase in shallow-buried super-large-span four-line high-speed railway tunnel[J]. China Railway Science，2021，42(6)：90-102.(in Chinese))
[30]	刘夏冰. 下北山浅埋超大跨四线高铁隧道围岩压力和施工期支护衬砌结构受力特征研究[博士学位论文][D]. 北京：北京交通大学，2022.(LIU Xiabing. Study on surrounding rockmass pressure and mechanical characteristics of support lining system at construction phase of Xiabeishan(XBS) shallow-burden exceptionally-large-span four track high-speed railway tunnel[Ph. D. Thesis][D]. Beijing：Beijing Jiaotong University，2022.(in Chinese))
[31]	王宇，李晓，李守定，等. 一种确定节理岩体残余强度参数方法的探讨[J]. 岩石力学与工程学报，2013，32(8)：1 701- 1 713.(WANG Yu，LI Xiao，LI Shouding，et al. A method for determining residual strength parameters of jointed rock masses[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(8)：1 701-1 713.(in Chinese))
[32]	曲海锋. 扁平特大断面公路隧道荷载模式及应用研究[博士学位论文][D]. 上海：同济大学，2007.(QU Haifeng. Study on load mode of road tunnel with extra-large cross-section and low flat-ratio and its application[Ph. D. Thesis][D]. Shanghai：Tongji University，2007.(in Chinese))
[33]	邓涛，刘大刚，蔡闽金，等. 基于中条山隧道的台阶法几何参数优化分析[J]. 隧道建设(中英文)，2017，37(12)：1 550-1 556.(DENG Tao，LIU Dagang，CAI Minjin，et al. Optimization analysis of geometric parameters of bench method used in Zhongtiaoshan tunnel[J]. Tunnel Construction，2017，37(12)：1 550-1 556.(in Chinese))