|
|
|
| Mechanical response and energy partition evolution of coal-rock combinations with different strength ratios |
| YANG Lei1，2，GAO Fuqiang1，2，WANG Xiaoqing1，2 |
| (1. CCTEG Coal Mining Research Institute，Beijing 100013，China；2. State Key Laboratory of Coal Mining and Clean Utilization，China Coal Research Institute，Beijing 100013，China) |
|
|
|
|
Abstract The mechanical response and energy partition of coal-rock combinations with different strength ratios were studied through laboratorial uniaxial compression tests and numerical simulation calculations. The results show that the strength and deformation parameters of the coal-rock combination mainly depend on the weak carrier. When the rock strength is weaker than the coal strength，the combination strength is similar to the rock strength，and the main destruction occurred at the rock section，when the coal strength and rock strength are similar，the combination strength is slightly higher than that of coal and rock，and fully destroying the coal and rock，as the strength and rigidity of the rock increase，the strength and rigidity of the combination also increase，and after the rock strength reaches twice of the coal strength，the uniaxial compressive strength of combination increased to 15%，the elastic modulus increased to 70% and both tended to be gentle compared with coal. At this time，coal is the main body of destruction，and with a much more consistent form of destruction. The loading stage of coal-rock combination can be divided into three stages：rapid accumulation of strain energy，slow growth of strain energy and rapid release of strain energy. Dissipative energy and friction energy begin to increase slowly in the second stage，after entering the third stage，dissipative energy，frictional energy and kinetic energy begin to increase sharply. The strain energy evolution of coal and rock is similar to that of the combination，coal is the important carrier of strain energy in combination. As the rock strength increases，the strain energy density of the coal-rock combination increases rapidly and then decreases slowly. When the strength ratio of the coal and rock is 1∶2，the coal-rock combination reaches the highest strain energy density. The bursting energy index of coal continues to increase，and the strain energy density of coal in the combination increases rapidly and then plateaus. When the rock strength in the combination is higher than that of coal，the energy storage capacity of coal strain energy can be increased up to 30%. The strain energy density of the rock in the combination increases first and then decreases，and then reaches its maximum when the coal-rock strength ratio is 1∶1.
|
|
|
|
|
|
| [1] 窦林名，陆菜平，牟宗龙，等. 组合煤岩冲击倾向性特性试验研 究[J]. 采矿与安全工程学报，2006，23(1)：43–46.(DOU Linming，LU Caiping，MOU Zonglong，et al. Rock burst tendency of coal rock combinations sample[J]. Journal of Mining and Safety Engineering，2006，23(1)：43–46.(in Chinese))
[2] 窦林名，田京城，陆菜平，等. 组合煤岩冲击破坏电磁辐射规律研究[J]. 岩石力学与工程学报，2005，24(19)：3 541–3 544.(DOU Linming，TIAN Jingcheng，LU Caiping，et al. Research on electromagnetic radiation rules of composed coal-rock burst failure[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(19)：3 541–3 544.(in Chinese))
[3] 陆菜平，窦林名，吴兴荣. 组合煤岩冲击倾向性演化及声电效应的试验研究[J]. 岩石力学与工程学报，2007，26(12)：2 549–2 555.(LU Caiping，DOU Linming，WU Xingrong. Experimental research on rules of rockburst tendency evolution and acoustic-electromagnetic effects of compound coal-rock samples[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(12)：2 549–2 555.(in Chinese))
[4] 宋录生，赵善坤，刘 军，等. “顶板–煤层”结构体冲击倾向性演化规律及力学特性试验研究[J]. 煤炭学报，2014，39(增1)：23– 30.(SONG Lusheng，ZHAO Shankun，LIU Jun，et al. Experimental research on rules of rock burst tendency evolution and mechanical properties of “roof-coal” structure body[J]. Journal of China Coal Society，2014，39(Supp.1)：23–30.(in Chinese))
[5] 左建平，谢和平，吴爱民，等. 深部煤岩单体及组合体的破坏机制与力学特性研究[J]. 岩石力学与工程学报，2011，30(1)：84–92.(ZUO Jianping，XIE Heping，WU Aimin，et al. Investigation on failure mechanisms and mechanical behaviors of deep coal-rock single body and combined body[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(1)：84–92.(in Chinese))
[6] 左建平，陈 岩，崔 凡. 不同煤岩组合体力学特性差异及冲击倾向性分析[J]. 中国矿业大学学报，2018，47(1)：81–87.(ZUO Jianping，CHEN Yan，CUI Fan. Investigation on mechanical properties and rock burst tendency of different coal-rock combined bodies[J]. Journal of China University of Mining and Technology，2018，47(1)：81–87.(in Chinese))
[7] 左建平，陈 岩，宋洪强，等. 煤岩组合体峰前轴向裂纹演化与非线性模型[J]. 岩土工程学报，2017，39(9)：1 609–1 615.(ZUO Jianping，CHEN Yan，SONG hongqiang，et al. Evolution of pre-peak axial crack strain and nonlinear model for coal-rock combined body[J]. Chinese Journal of Geotechnical Engineering，2017，39(9)：1 609–1 615.(in Chinese))
[8] 左建平，宋洪强，陈 岩，等. 煤岩组合体峰后渐进破坏特征与非线性模型[J]. 煤炭学报，2018，43(12)：3 265–3 272.(ZUO Jianping，SONG Hongqiang，CHEN Yan，et al. Post-peak progressive failure characteristics and nonlinear model of coal-rock combined body[J]. Journal of China Coal Society，2018，43(12)：3 265–3 272.(in Chinese))
[9] 牟宗龙，王 浩，彭 蓬，等. 岩–煤–岩组合体破坏特征及冲击倾向性试验研究[J]. 采矿与安全工程学报，2013，30(6)：841–847. (MOU Zonglong，WANG Hao，PENG Peng，et al. Experimental research on failure characteristics and bursting liability of rock-coal-rock sample[J]. Journal of Mining and Safety Engineering，2013，30(6)：841–847.(in Chinese))
[10] 陈绍杰，尹大伟，张保良，等. 顶板–煤柱结构体力学特性及其渐进破坏机制研究[J]. 岩石力学与工程学报，2017，36(7)：33–43.(CHEN Shaojie，YIN Dawei，ZHANG Baoliang，et al. Mechanical characteristics and progressive failure mechanism of roof-coal pillar structure[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(7)：33–43.(in Chinese))
[11] 张泽天，刘建锋，王 璐，等. 组合方式对煤岩组合体力学特性和破坏特征影响的试验研究[J]. 煤炭学报，2012，37(10)：1 677–1 681. (ZHANG Zetian，LIU Jianfeng，WANG Lu，et al. Effects of combination mode on mechanical properties and failure characteristics of the coal-rock combinations[J]. Journal of China Coal Society，2012，37(10)：1 677–1 681.(in Chinese))
[12] 刘 杰，王恩元，宋大钊，等. 岩石强度对于组合试样力学行为及声发射特性的影响[J]. 煤炭学报，2014，39(4)：685–691.(LIU Jie，WANG Enyuan，SONG Dazhao，et al. Effects of rock strength on mechanical behavior and acoustic emission characteristics of sample composed of coal and rock[J]. Journal of China Coal Society，2014，39(4)：685–691.(in Chinese))
[13] 郭东明，左建平，张 毅，等. 不同倾角组合煤岩体的强度与破坏机制研究[J]. 岩土力学，2011，32(5)：1 333–1 339.(GUO Dongming，ZUO Jianping，ZHANG Yi，et al. Research on strength and failure mechanism of deep coal-rock combination bodies of different inclined angles[J]. Rock and Soil Mechanics，2011，32(5)：1 333–1 339.(in Chinese))
[14] 郭伟耀，周 恒，徐宁辉，等. 煤岩组合体力学特性模拟研究[J]. 煤矿安全，2016，47(2)：33–35.(GUO Weiyao，ZHOU Heng，XU Ninghui，et al. Simulation study of mechanical properties of coal rock combination[J]. Safety in Coal Mines，2016，47(2)：33–35.(in Chinese))
[15] 杨 磊，高富强，王晓卿，等. 煤岩组合体的能量演化规律与破坏机制[J]. 煤炭学报，2019，44(12)：3 894–3 902.(YANG Lei，GAO Fuqiang，WANG Xiaoqing，et al. Energy evolution law and failure mechanism of coal-rock combined specimen[J]. Journal of China Coal Society，2019，44(12)：3 894–3 902.(in Chinese))
[16] CHEN Y，ZUO J，LIU D，et al. Deformation failure characteristics of coal-rock combined body under uniaxial compression：experimental and numerical investigations[J]. Bulletin of Engineering Geology and the Environment，2019，78(5)：3 449–3 464.
[17] YANG S，WANG J，NING J G，et al. Experimental study on mechanical properties, failure behavior and energy evolution of different coal-rock combined specimens[J]. Applied Sciences，2019，20(9)：4 427–4 444.
[18] POTYONDY D O，CUNDALL P A. A bonded-particle model for rock[J]. International Journal of Rock Mechanics and Mining Sciences，2004，41(8)：1 329–1 364.
[19] 张社荣，孙 博，王 超，等. 双轴压缩试验下岩石裂纹扩展的离散元分析[J]. 岩石力学与工程学报，2013，32(增2)：3 083–3 091. (ZHANG Sherong，SUN Bo，WANG Chao，et al. Discrete element analysis of crack propagation in rocks under biaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(Supp.2)：3 083–3 091.(in Chinese))
[20] ZHANG X P，WONG N Y. Cracking processes in rock-like material containing a single flaw under uniaxial compression：A numerical study based on parallel bonded-particle model approach[J]. Rock Mechanics and Rock Engineering，2012，45(5)：711–737.
[21] 张国凯，李海波，夏 祥，等. 岩石单轴压缩下能量与损伤演化规律研究[J]. 岩土力学，2015，36(增1)：94–100.(ZHANG Guokai，LI Haibo，XIA Xiang，et al. Research on energy and damage evolution of rock under uniaxial compression[J]. Rock and Soil Mechanics，2015，36(Supp.1)：94–100.(in Chinese))
|
|
|
|
2020, Vol. 39 
