|
|
|
| Research on the rammed quality and influencing factors of traditional rammed technology |
| PEI Qiangqiang1，2，3，4，ZHANG Bo1，2，3，4，LIU Xiaoying1，3，4，5，6，ZHAO Guojing1，3，4，5，YU Zuohui1，GUO Qinglin1，3，4，WANG Xudong2，3 |
| (1. Dunhuang Academy，Dunhuang，Gansu 736200，China；2. School of Civil Engineering and Mechanics，Lanzhou University，Lanzhou，Gansu 730000，China；3. National Technological Research Center for Conservation of Ancient Wall Paintings and Earthen Heritage Sites，Dunhuang，Gansu 736200，China；4. Key Laboratory Conservation of Ancient Wall Paintings and Earthen Sites，Gansu Province，Dunhuang，Gansu 736200，China；5. Gansu Mogao Grottoes Cultural Heritage Conservation Design and Consultation Co.，Ltd.，Dunhuang，Gansu 736200，China；6. College of Cultural Heritage，Northwest University，
Xi′an，Shaanxi 710069，China) |
|
|
|
|
Abstract The introduction of quantitative indicators of ramming quality is the premise of scientific cognition of ramming technology and quality control，and is the key to inherit and apply traditional ramming technology. This study adopted traditional ramming technology to ram full-scale field test samples；took samples and measured the parameters of single- and double-layer rammed body including dry density，porosity ratio，unconfined compressive strength，and the depth of rammer into the soil under the condition of different rammer mass，paved soil thickness，and ramming times；and summarized the quality characteristics of single- and double-layer rammed body under three variable different working conditions. The study found the dry density and unconfined compressive strength were the important indexes to control the quality of ramming. The increase of ramming time and rammer mass had a positive effect on the dry density and unconfined compressive strength of the ramming body. Single-layer rammed body after 8 times of ramming was convergent and stable in density and strength；the double-layer rammed body showed an obvious compacting effect of superimposed work，the density of the lower layer being increased by 4.33% compared to the upper layer and the unconfined compressive strength increasing 39.52%. The results revealed the scientificity of traditional ramming technology “chong haiwo” and “hang ying ding” in making up the uniformity of the compactness of rammed layer and enhancing the compactness and strength by layer-by-layer stacking method.
|
|
|
|
|
|
| [1] 中国科学院自然科学史研究所. 中国古代建筑技术史[M]. 北京：科学出版社，2000：45.(Institute of the History of Natural Science，Chinese Academy of Sciences. History of architectural technology in ancient China[M]. Beijing：Science Press，2000：45.(in Chinese))
[2] 李最雄. 丝绸之路古遗址保护[M]. 北京：科学出版社，2004：118–122.(LI Zuixiong. Protection of the ancient ruins of the silk road[M]. Beijing：Science Press，2004：118–122.(in Chinese))
[3] 景 爱，苗天娥. 剖析长城夯土版筑的技术方法[J]. 中国文物科学研究，2008，(2)：51–56.(JING Ai，MIAO Tian′e. Analysis of the technical method of rammed earth plate building of the Great Wall[J]. China Cultural Heritage Scientific Research，2008，(2)：51–56.(in Chinese))
[4] 毛筱霏，刘玉茜，张卫喜. 高昌故城遗址构筑技法及土体特性研 究[J]. 建筑科学，2012，28(1)：45–48.(MAO Xiaofei，LIU Yuqian，ZHANG Weixi. Study on building techniques and soil properties of ancient ruins of Gaochang[J]. Building Science，2012，28(1)：45–48.(in Chinese))
[5] 曹春平. 客家土楼的夯筑技术[J]. 建筑史论文集，2001，14(00)：134–139.(CAO Chunping. Ramming technology of Hakka Earth Building[J]. Treatises on History of Architecture，2001，14(00)：134–139.(in Chinese))
[6] 张玉石. 中国古代版筑技术研究[J]. 中原文物，2004，(2)：59–70. (ZHANG Yushi. Study on the board frame constructing techniques of ancient China[J]. Cultural Relics of Central China，2004，(2)：59–70.(in Chinese))
[7] 李 诫. 营造法式[M]. 上海：上海商务印书馆，1954：54.(LI Jie. Construction technique[M]. Shanghai：Shang-hai Commercial Press，1954：54.(in Chinese))
[8] 潘谷西. 中国建筑史[M]. 第6版. 北京：中国建筑工业出版社，2006：262.(PAN Guxi. Chinese architectural history[M]. 6th ed. Beijing：China Building Industry Press，2006：262.(in Chinese))
[9] 刘大可. 中国古建筑瓦石营法[M]. 北京：中国建筑工业出版社，1993：4–10.(LIU Dake. The methodology of tile and stone of Chinese ancient building[M]. Beijing：China Architecture and Building Press，1993：4–10.(in Chinese))
[10] 张贺君. 古代夯具述论[J]. 河南科技大学学报：社会科学版，2006，(5)：17–20.(ZHANG Hejun. A brief study on ancient punner[J]. Journal of Henan University of Science and Technology：Social Science，2006，(5)：17–20.(in Chinese))
[11] 王兴中. 浅析中国古建筑施工中的土木工具[J]. 山西建筑，2011，37(18)：85–87.(WANG Xingzhong. Tentative analysis on civil instrument in Chinese ancient architecture construction[J]. Shanxi Architecture，2011，37(18)：85–87.(in Chinese))
[12] 孙满利，李最雄，王旭东，等. 干旱区土遗址病害的分类研究[J].工程地质学报，2007，15(6)：772–778.(SUN Manli，LI Zuixiong，WANG Xudong，et al. Taxonomic research on soil ruins in arid areas[J]. Journal of Engineering Geology，2007，15(6)：772–778.(in Chinese))
[13] 胡 玮. 夯土遗址掏蚀病害发育特征与影响因素研究[硕士学位论文][D]. 兰州：兰州大学，2014.(HU Wei. Study on the development characteristics and influencing factors of sapping in rammed earth sites[M. S. Thesis][D]. Lanzhou：Lanzhou University，2014.(in Chinese))
[14] 裴强强，郭青林，王旭东，等. 土质建筑遗址传统营造技法的演化与特征探析[J]. 文物保护与考古科学，2019，31(5)：1–13.(PEI Qiangqiang，GUO Qinglin，WANG Xudong，et al. The evolution and characteristics of traditional building technique of earthen architectural sites[J]. Sciences of Conservation and Archaeology，2019，31(5)：1–13.(in Chinese))
[15] REDDY B V V，KUMAR P P. Cement stabilised rammed earth. Part A：compaction characteristics and physical properties of compacted cement stabilised soils[J]. Materials and Structures，2011，44(3)：681– 693.
[16] REDDY B V V， KUMAR P P. Cement stabilised rammed earth. Part B：compressive strength and stress strain characteristics[J]. Materials and Structures，2011，44(3)：659–707.
[17] CHAUHAN P， HAJJAR A E，PRIME N，et al. Unsaturated behavior of rammed earth：Experimentation towards numerical modelling[J]. Construction and Building Materials，2019，227：116646.
[18] GAMRANI N，CHAHAM K R，IBNOUSSINA M，et al. The particular “rammed earth” of the Saadian sugar refinery of Chichaoua (XVIth century，Morocco)：mineralogical，chemical and mechanical characteristics[J]. Environmental Earth Sciences，2012，66(1)：129–140.
[19] 裴强强，王旭东，郭青林，等. 干旱环境下土遗址夯补支顶加固变形机制室内试验研究[J]. 岩土力学，2018，39(8)：2 755–2 764.(PEI Qiangqiang，WANG Xudong，GUO Qinglin，et al. Laboratory test research on deformation mechanism of compacted support and reinforcement of soil ruins in arid environment[J]. Rock and Soil Mechanics，2018，39(8)：2 755–2 764.(in Chinese))
[20] WANG X D，PEI Q Q，GUO Q L，et al. Stress mechanism for the rammed layer interfaces of earthen heritage sites with different treatments[J]. Journal of Cultural Heritage，2019，(39)：110–119.
[21] 王旭东，石玉成，刘 琨，等. 夯土长城墙体掏蚀失稳机理研究[J]. 西北地震学报，2011，33(增)：381–385.(WANG Xudong，SHI Yucheng，LIU Kun，et al. Study on the instability mechanism of ramming in the wall of the Great Wall[J]. Northwestern Seismological Journal，2011，33(Supp.)：381–385.(in Chinese))
[22] 吴燕开，刘松玉，洪振舜. 土层工程性质与其沉积环境关系分析研究[J]. 工程地质学报，2004，12(3)：263–267.(WU Yankai，LIU Songyu，HONG Zhenshun. Analysis and research on the relationship between soil engineering properties and sedimentary environment[J]. Journal of Engineering Geology，2004，12(3)：263–267.(in Chinese))
[23] XU L F，HENRY W，ANTONIN F，et at. Modelling the poroplastic damageable behaviour of earthen materials[J]. Materials and Structures，2018，51(4)：112.
[24] BUI T T，BUI Q B，LIMAM A，et al. Modeling rammed earth wall using discrete element method[J]. Continuum Mechanics and Thermodynamics，2016，28(1/2)：523–538.
[25] WANG Y A，WANG M，LIU K，et al. Shaking table tests on seismic retrofitting of rammed-earth structures[J]. Bulletin of Earthquake Engineering，2017，15(3)：1 037–1 055.
[26] JO Y H，LEE S M，LEE C H. Material characteristics and building technique for the rammed earth wall of the 13th Korean fortress in Ganghwa[J]. Environmental Earth Sciences，2018，77(17)：617.
[27] 李最雄，张虎元，王旭东. 古代土遗址的加固研究[J]. 敦煌研究，1995，(3)：1–17.(LI Zuixiong，ZHANG Huyuan，WANG Xudong. Research on the reinforcement of ancient earthen sites[J]. Dunhuang Studies，1995，(3)：1–17.(in Chinese))
[28] 裴强强，郭青林，赵林毅，等. 岩土类遗址保护加固工程档案编写研究[J]. 文物保护与考古科学，2015，27(4)：30–38.(PEI Qiangqiang，GUO Qinglin，ZHAO Linyi，et al. Compilation and research on archaeological protection and reinforcement projects of geotechnical sites[J]. Sciences of Conservation and Archaeology，2015，27(4)：30–38.(in Chinese))
[29] 李最雄，王旭东，郝利民. 室内土遗址的加固试验–半坡土遗址的加固试验[J]. 敦煌研究，1998，(4)：144–149.(LI Zuixiong，WANG Xudong，HAO Limin. Reinforcement test of indoor soil sites reinforcement test of Banpo soil sites[J]. Dunhuang Research，1998，(4)：144–149.(in Chinese))
[30] 李 毅，谢利利，王名福，等. 粉体颗粒形貌特征的提取与识别技术[J]. 重庆大学学报：自然科学版，2000，20(5)：67–69.(LI Yi，XIE Lili，WANG Mingfu，et al. Extraction and recognition technology of powder particle morphology[J]. Journal of Chongqing University：Natural Science，2000，20(5)：67–69.(in Chinese))
[31] 涂新斌，王思敬. 图像分析的颗粒形状参数描述[J]. 岩土工程学报，2004，5(5)：659–662.(TU Xinbin，WANG Sijing. Description of particle shape parameters for image analysis[J]. Chinese Journal of Geotechnical Engineering，2004，5(5)：659–662.(in Chinese))
[32] 杨国忠，闫 超. 中国古代地基基础技术研究[J]. 岩土工程学报，2011，33(增2)：450–453.(YANG Guozhong，YAN Chao. Research on foundation technology of ancient China[J]. Chinese Journal of Geotechnical Engineering，2011，33(Supp.2)：450–453.(in Chinese))
[33] MOROPOULOU A，BAKOLAS A，ANAGNOSTOPOULOU S. Composite materials in ancient structures[J]. Cement and Concrete Composites，2004，27(2)：295–300.
[34] LIU Q，TONG L P. Engineering properties of unstabilized rammed earth with different clay contents[J]. Journal of Wuhan University of Technology-Mater. Sci. Ed.，2017，32(4)：914–920.
[35] KIANFAR E，TOUFIGH V. Reliability analysis of rammed earth structures[J]. Construction and Building Materials，2016，127：884–895.
[36] ALONSO E E，GENS A，JOSA A. A constitutive model for partially saturated soils[J]. Geotechnique，1990，40(3)：405–430.
[37] KEVIN H，ALIDA H. Weathering by wetting-drying：Some experimental results[J]. Earth Surface Processes and Landforms，1996，21(4)：365–376.
[38] SADISUN I A，SHIMADA H，ICHINOSE M. Study on the physical disintegration characteristics of Subang claystone subjected to amodified slaking index test[J]. Geotechnical and Geological Engineering，2005，23(3)：199–218.
|
|
|
|
2020, Vol. 39 
