注浆裂隙岩体力学特性影响因素试验研究

doi:10.3724/1000-6915.jrme.2025.0138

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (6641 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Grouting as a main technical means for stability control of fractured surrounding rock, its reinforcement effect is controlled by many factors. To investigate the effect of inclination angle and rock matrix on grouting reinforcement, this paper carried out uniaxial compression tests of grouted coal, mudstone and sandstone specimens with different crack inclination angles (? = 0°, 15°, 30°, 45°, 60°). Combined with the digital image correlation (DIC) and acoustic emission (AE) technology, the evolution characteristics of their mechanical properties were investigated. Test results showed that: (1) the peak strength showed a tendency of decreasing and then increasing with the increase of inclination angle for different rock specimen; the damage mode of the grouted fractured coal and mudstone specimens shifts from split tensile to shear failure along the fracture, whereas the sandstone specimens were dominated by interfacial shear damage. (2) The DIC results showed that the maximum principal strains of different specimens first increase and then decrease as fracture inclination angle increases, which the mudstone specimens had the smallest value, and the coal specimens had the smallest changes in the strain field. (3) The acoustic emission characteristics showed that the percentage of tensile microcracks decreased with the increase of inclination angle. Combined with the analysis of acoustic emission b-value, the mudstone and sandstone specimens had the smallest and highest degree of failure, respectively. Finally, the slurry-rock interface correlation coefficient k was proposed to analyze the mechanical property evolution mechanism of the grouted fractured rock mass. Results indicated the inclination angle and rock matrix jointly controlled the mechanical behavior of the grouted fractured rock mass through the rock strength and slurry-rock interface characteristics. The above study provides theoretical and experimental basis for the design of grouting reinforcement and stability analysis of surrounding rock in deep tunnel.

Key words： rock mechanics fracture grouting strain characterization acoustic emission (AE) fracture inclination damage characterization

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	LIU Xuewei1
	2
	LIU Yunhao1
	2
	LIU Bin1
	2
	WANG Sai1
	LIU Quansheng3
	ZHU Lei1
	ZHU Yuanguang1
	2

Cite this article:

LIU Xuewei1,2,LIU Yunhao1, et al. Experimental investigation of the influencing factors on the mechanical properties of grouted fractured rock mass[J]. , 2025, 44(7): 1782-1799.

URL:

https://rockmech.whrsm.ac.cn/EN/10.3724/1000-6915.jrme.2025.0138 OR https://rockmech.whrsm.ac.cn/EN/Y2025/V44/I7/1782

[1]	钱七虎. 地下工程建设安全面临的挑战与对策[J]. 岩石力学与工程学报，2012，31(10)：1 945-1 956.(QIAN Qihu. Challenges faced by underground projects construction safety and countermeasures[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(10)：1 945-1 956.(in Chinese))
[2]	WONG R H C，TANG C A，CHAU K T，et al. Splitting failure in brittle rocks containing pre-existing flaws under uniaxial compression[J]. Engineering Fracture Mechanics，2002，69(17)：1 853-1 871.
[3]	刘学伟，王赛，刘滨，等. 不同注浆材料填充双裂隙类岩石试样力学特性研究[J]. 岩石力学与工程学报，2024，43(3)：623-638. (LIU Xuewei，WANG Sai，LIU Bin，et al. Effect of filling grouting material on mechanical properties and mechanism of rock-like samples with double crack[J]. Chinese Journal of Rock Mechanics and Engineering，2024，43(3)：623-638.(in Chinese))
[4]	刘泉声，周越识，卢超波，等. 含裂隙泥岩注浆前后力学特性试验研究[J]. 采矿与安全工程学报，2016，33(3)：509-514.(LIU Quansheng，ZHOU Yueshi，LU Chaobo，et al. Experimental study on mechanical properties of mudstone fracture before and after grouting[J]. Journal of Mining and Safety Engineering，2016，33(3)：509-514.(in Chinese))
[5]	SHANG R H，WANG L，LIU H Q，et al. The influence of dip angle of rock bridge on mechanical properties and fracture characteristics of fractured coal body at three-dimensional scale[J]. Rock Mechanics and Rock Engineering，2023，56：8 927-8 946.
[6]	LI H Q，WONG L N Y. Influence of flaw inclination angle and loading condition on crack initiation and propagation[J]. International Journal of Solids and Structures，2012，49：2 482-2 499.
[7]	PARK C H，BOBET A. Crack coalescence in specimens with open and closed flaws：A comparison[J]. International Journal of Rock Mechanics and Mining Sciences，2009，46(5)：819-829.
[8]	陈卫忠，李术才，邱祥波，等. 岩石裂纹扩展的实验与数值分析研究[J]. 岩石力学与工程学报，2003，22(1)：18-23.(CHEN Weizhong，LI Shucai，QIU Xiangbo，et al. Experimental and numerical research on crack propagation in rock under compression[J]. Chinese Journal of Rock Mechanics and Engineering，2003，22(1)：18-23.(in Chinese))
[9]	JAHANIAN H，SADAGHIANI M H. Experimental study on the shear strength of sandy clay infilled regular rough rock joints[J]. Rock Mechanics and Rock Engineering，2015，48：907-922.
[10]	肖福坤，刘刚，秦涛，等. 拉-压-剪应力下细砂岩和粗砂岩破裂过程声发射特性研究[J]. 岩石力学与工程学报，2016，35(增2)：3 458-3 472.(XIAO Fukun，LIU Gang，QIN Tao，et al. Acoustic emission (AE) characteristics of fine sandstone and coarse sandstone fracture process under tension-compression-shear stress[J]. Chinese Journal of Rock Mechanics and Engineering，2016，35(Supp.2)：3 458-3 472.(in Chinese))
[11]	SHE C X，SUN F T. Study of the peak shear strength of a cement-filled hard rock joint[J]. Rock Mechanics and Rock Engineering，2018，51：713-728.
[12]	卢海峰，朱晨东，刘泉声. 不同注浆材料作用下结构面剪切力学特性研究[J]. 岩石力学与工程学报，2021，40(9)：1 803-1 811.(LU Haifeng，ZHU Chendong，LIU Quansheng. Study on shear mechanical properties of structural planes grouted with different materials[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(9)：1 803-1 811.(in Chinese))
[13]	ZHOU D，ZHAO Z H，LI B，et al. Permeability evolution of grout infilled fractures subjected to triaxial compression with low confining pressure[J]. Tunnelling and Underground Space Technology，2020，104：103539.
[14]	路亚妮，李新平，吴兴宏. 三轴压缩条件下冻融单裂隙岩样裂缝贯通机制[J]. 岩土力学，2014，35(6)：1 579-1 584.(LU Yani，LI Xinping，WU Xinghong. Fracture coalescence mechanism of single flaw rock specimen due to freeze-thaw under triaxial compression[J]. Rock and Soil Mechanics，2014，35(6)：1 579-1 584.(in Chinese))
[15]	刘学伟，刘泉声，陈元，等. 裂隙形式对岩体强度特征及破坏模式影响的试验研究[J]. 岩土力学，2015，36(增2)：208-214.(LIU Xuewei，LIU Quansheng，CHEN Yuan，et al. Experimental study of effects of fracture type on strength characteristics and failure modes of fractured rock mass[J]. Rock and Soil Mechanics，2015，36(Supp.2)：208-214.(in Chinese))
[16]	HUANG J F，CHEN G L，ZHAO Y H，et al. An experimental study of the strain field development prior to failure of a marble plate under compression[J]. Tectonophysics，1990，175(1/3)：269-284.
[17]	张科，刘享华，李昆，等. 含孔多裂隙岩石力学特性与破裂分形维数相关性研究[J]. 岩石力学与工程学报，2018，37(12)：2 785-2 794.(ZHANG Ke，LIU Xianghua，LI Kun，et al. Investigation on the correlation between mechanical characteristics and fracturing fractal dimension of rocks containing a hole and multi-flaws[J]. Chinese Journal of Rock Mechanics and Engineering，2018，37(12)：2 785-2 794.(in Chinese))
[18]	JANEIRO R P，EINSTEIN H H. Experimental study of the cracking behavior of specimens containing inclusions (under uniaxial compression)[J]. International Journal of Fracture，2010，164：83-102.
[19]	LE H L，SUN S R，PINNADUWA H S W，et al. Effect of grout on mechanical properties and cracking behavior of rock-like specimens containing a single flaw under uniaxial compression[J]. International Journal of Geomechanics，2018，10(18)：04018129.
[20]	张波，李术才，张敦福，等. 含充填节理岩体相似材料试件单轴压缩试验及断裂损伤研究[J]. 岩土力学，2012，33(6)：1 647-1 652. (ZHANG Bo，LI Shucai，ZHANG Dunfu，et al. Uniaxial compression mechanical property test，fracture and damage analysis of similar material of jointed rock mass with filled cracks[J]. Rock and Soil Mechanics，2012，33(6)：1 647-1 652.(in Chinese))
[21]	HU X J，GONG X N，MA J J，et al. Numerical study on full-field stress evolution and acoustic emission characteristics of rocks containing three parallel pre-existing flaws under uniaxial compression[J]. European Journal of Environmental and Civil Engineering，2023，27(1)：51-57.
[22]	刘剑，周宗红，张晶，等. 闪长岩不同卸荷速率声发射特征及非稳定阶段识别[J]. 岩土力学，2025，46(1)：225-232.(LIU Jian，ZHOU Zonghong，ZHANG Jing，et al. Acoustic emission characteristics of diorite at varying unloading rates and identification of its unsteady phases[J]. Rock and Soil Mechanics，2025，46(1)：225-232.(in Chinese))
[23]	马永安，于崇，李海波，等. 三轴及循环加卸载下花岗岩力学特性与能量演化研究[J]. 岩石力学与工程学报，2020，39(10)：2 047-2 059.(MA Yongan，YU Chong，LI Haibo，et al. Study on the mechanical properties and energy evolution of granite under triaxial and cyclic loading and unloading conditions[J]. Chinese Journal of Rock Mechanics and Engineering，2020，39(10)：2 047-2 059.(in Chinese))
[24]	ZHOU X P，NIU Y，CHENG H，et al. Cracking behaviors and chaotic characteristics of sandstone with unfilled and filled dentate flaw[J]. Theoretical and Applied Fracture Mechanics，2011，112：102876.
[25]	张朝俊，吴顺川，储超群，等. 裂隙砂岩应变场演化与超声时移衰减特征研究[J]. 岩土力学，2024，45(5)：1 284-1 296.(ZHANG Chaojun，WU Shunchuan，CHU Chaoqun，et al. Strain field evolution and ultrasonic time-lapse attenuation characteristics of fractured sandstone[J]. Rock and Soil Mechanics，2024，45(5)：1 284-1 296.(in Chinese))
[26]	LIU X H，ZHANG K，LIU W L，et al. Influence of weak inclusions on the cracking behavior of a jointed rock mass containing an opening：insights from DIC-based approaches[J]. Archives of Civil and Mechanical Engineering，2022，22：184.
[27]	ZHU Q Q，LI D Y，HAN Z Y，et al. Mechanical properties and fracture evolution of sandstone specimens containing different inclusions under uniaxial compression[J]. International Journal of Rock Mechanics and Mining Sciences，2019，115：33-47.
[28]	李英骏，张鸣原，何满潮. 脉冲激光超快时间分辨方法在岩石力学领域的应用与进展[J]. 中国科学：技术科学，2024，54(8)：1 549-1 562.(LI Yingjun，ZHANG Mingyuan，HE Manchao. Applications and state-of-the-art review of pulsed laser ultrafast time-resolution method in the field of rock mechanics[J]. Scientia Sinica：Technologica，2024，54(8)：1 549-1 562.(in Chinese))
[29]	ZUO J P，WANG X S，MAO D Q. SEM in situ study on the effect of offset-notch on basalt cracking behavior under three-point bending load[J]. Engineering Fracture Mechanics，2014，131：504-513.
[30]	WANG Z Y，WH Z J，CHU Z F，et al. Study on mesoscopic failure mechanism of grout-infilled sandstone under uniaxial compression using an improved AE localization technique[J]. International Journal of Rock Mechanics and Mining Sciences，2022，160：105275.
[31]	牟宏伟，何学秋，宋大钊，等. 不同节理夹角煤单轴压缩力学和声发射响应及影响机制[J]. 煤炭学报，2020，45(5)：1 726-1 732.(MU Hongwei，HE Xueqiu，SONG Dazhao，et al. Response characteristics and influence mechanism of uniaxial compression mechanics and AE of coal with different joint angles[J]. Journal of China Coal Society，2020，45(5)：1 726-1 732.(in Chinese))
[32]	PAN P Z，MIAO S T，JIANG Q，et al. The influence of infilling conditions on flaw surface relative displacement induced cracking behavior in hard rock[J]. Rock Mechanics and Rock Engineering，2020，53：449-470.
[33]	MIAO S T，PAN P Z，WU Z H，et al. Fracture analysis of sandstone with a single filled flaw under uniaxial compression[J]. Engineering Fracture Mechanics，2018，204：319-343.
[34]	TIAN Y C，LIU Q S，MA H，et al. New peak shear strength model for cement filled rock joints[J]. Engineering Geology，2018，223：269-280.
[35]	MA H，LIU Q S. Prediction of the peak shear strength of sandstone and mudstone joints infilled with high water-cement ratio grouts[J]. Rock Mechanics and Rock Engineering，2017，50：2 021-2 037.
[36]	LEE J S，BANG C S，MOK Y J，et al. Numerical and experimental analysis of penetration grouting in jointed rock masses[J]. International Journal of Rock Mechanics and Mining Sciences，2000，37(7)：1 027-1 037.
[37]	张进鹏，李扬，赵炜，等.不同岩石强度裂隙岩体约束自应力浆液加固试验研究与应用[J]. 煤炭学报，2023，48(9)：3 347-3 359. (ZHANG Jinpeng，LI Yang，ZHAO Wei，et al. Test and application of self-stress slurry reinforcement for fractured rock masses with different strength[J]. Journal of China Coal Society，2023，48(9)：3 347-3 359.(in Chinese))
[38]	WU D，LI H B，SHAO Z S，et al. Effects of infilling materials on mechanical behaviors and cracking process of pre-cracked rock：Insights from a hybrid continuum-discontinuum method[J]. Engineering Fracture Mechanics，2021，253：107843.
[39]	LI Y Z，YUAN L，ZHANG Q H. Brittle rock mass failure in deep tunnels：The role of infilled structural plane with varying dip angles[J]. International Journal of Rock Mechanics and Mining Sciences，2024，176：105721.
[40]	LIU X W，WANG S，LIU B，et al. Cement-based grouting material development and prediction of material properties using PSO-RBF machine learning[J]. Construction and Building Materials，2024，417：135328.
[41]	程先振，陈连军，栾恒杰，等. 基质-裂隙相互作用对煤渗透率的影响：考虑煤的软化[J]. 岩土工程学报，2022，44(10)：1 890-1 898. (CHENG Xianzhen，CHEN Lianjun，LUAN Hengjie，et al. Influences of softening behaviour of coal on evolution of its permeability by considering matrix-fracture interactions[J]. Chinese Journal of Geotechnical Engineering，2022，44(10)：1 890-1 898.(in Chinese))