采动影响下大跨度煤巷耦合支护技术研究与应用

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (708 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为解决多次采动影响下大跨度煤巷支护难的问题，以高家梁矿20108工作面回风巷道为例，通过分析工程地质条件和工程岩体特性可知，20108回风巷道属于应力扩容膨胀型复合地质软岩，确定力学破坏机制为IABCIIBDIIIDA复合型变形力学机制，提出采用锚网索带注耦合支护方案。基于FLAC3D数值软件，对锚网索带注耦合支护方案进行数值计算，计算结果显示，与无耦合支护对比，屈服区域显著缩小，顶底板和两帮变形都得到有效控制。现场监测煤巷围岩变形表明，多次采动影响下煤巷两帮变形速率大于顶底板，表明两帮变形速率控制着20108回风巷道的使用功能。研究结果表明，锚网索带注耦合支护在采动影响下大跨度煤巷支护中取得良好的支护效果，数值计算表明，采动影响下大跨度煤巷采用耦合支护技术是可行的；现场监测结果也验证耦合支护技术的有效性和可靠性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：采矿工程, 采动荷载, 大跨度巷道, 耦合支护, 现场监测, 数值分析

Abstract：In order to solve difficult support problems of the large-span coal roadway under the second or multiple mining influence，an example of the working face 20108 ventilation roadway in Gaojialiang Coal Mine is presented. Through analyzing the engineering geological conditions and engineering rocks body characteristics，it is known that the roadway 20108 is the stress dilatancy expansion type composite geological soft rock. The damage mechanisms of roadway are the composite deformation mechanisms IABCIIBDIIIDA；and then the bolt-mesh-cable-grout with steel band coupling support design is put forward. By using the large finite difference program FLAC3D，numerical analysis of coupling support design is conducted. The numerical results show that comparing with non-coupling support，the plastic failure zone is obviously reduced and floor deformation is larger than roof deformation of coal roadway. The deformation of roof；and the floor and two working slopes are effectively in control. The field monitoring deformation of roadway surrounding rock shows that，deformation rates of roadway two working slopes under multiple mining influence are larger than those of the roof and floor，which indicates that deformations of two working slopes control the utilization function of ventilation roadway 20108. The results reveal that support effect of bolt-mesh-cable-grout with steel band coupling support is very good in large-span roadway under mining dynamic loads. Based on the theory of numerical calculation，the application of coupling support to large-span coal roadway under multiple mining influence is feasible；and the field monitoring result also verifies the validity and reliability of coupling support proposed.

Key words： mining engineering mining load large-span coal roadway coupling support field monitoring numerical analysis

收稿日期: 2013-03-22

引用本文:

张向东1，李庆文1，黄开勇2，李桂秀1，张旭1. 采动影响下大跨度煤巷耦合支护技术研究与应用[J]. 岩石力学与工程学报, 2014, 33(1): 60-68.
ZHANG Xiangdong1，LI Qingwen1，HUANG Kaiyong2，LI Guixiu1，ZHANG Xu1. STUDY OF COUPLING SUPPORT FOR LARGE-SPAN COAL ROADWAY UNDER MINING DYNAMIC LOAD AND ITS APPLICATION. , 2014, 33(1): 60-68.

链接本文:

http://www.rockmech.org/CN/Y2014/V33/I1/60

[1]	何满潮，景海河，孙晓明. 软岩工程力学[M]. 北京：科学出版社，2002：5-9.(HE Manchao，JING Haihe，SUN Xiaoming. Soft rock engineering mechanics[M]. Beijing：Science Press，2002：5-9.(in Chinese)) " target="_blank">
[4]	孙晓明，何满潮，杨晓杰. 深部软岩巷道锚网索偶和支护非线性设计方法研究[J]. 岩土力学，2006，27(7)：1 061-1 065.(SUN Xiaoming，HE Manchao，YANG Xiaojie. Research on nonlinear mechanical design method of bolt-net-anchor coupling support for deep Soft rock tunnel[J]. Rock and Soil Mechanics，2006，27(7)：1 061-1 065.(in Chinese)) " target="_blank">
[5]	王卫军，彭刚，黄俊. 高应力极软破碎岩层巷道高强度耦合支护技术研究[J]. 煤炭学报，2011，36(2)：223-228.(WANG Weijun，PENG Gang，HUANG Jun. Research on high-strength coupling support technology of high stress extremely soft rock roadway[J]. Journal of China Coal Society，2011，36(2)：223-228.(in Chinese))
[7]	GUNTER G. G，ROBERT G．Input to the application of the convergence confinement method with time-dependent behavior of the support[J]. Tunneling and Underground Space Technology，2012，27(1)：13-22. " target="_blank">
[10]	康红普，林健，吴拥政. 全断面高预应力强力锚索支护技术及其在动压巷道中的应用[J]. 煤炭学报，2009，34(9)：1 153-1 159. (KANG Hongpu，LIN Jian，WU Yongzheng. High pretensioned stress and intensive cable bolting technology set in full section and application in entry affected by dynamic pressure[J]. Journal of China Coal Society，2009，34(9)：1 153-1 159.(in Chinese)) " target="_blank">
[11]	孙晓明，杨军，曹伍富. 深部回采巷道锚网索耦合支护时空作用规律研究[J]. 岩石力学与工程学报，2007，26(5)：895-900.(SUN Xiaoming，YANG Jun，CAO Wufu. Research on space-time action rule of bolt-net-anchor coupling support for deep gateway[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(5)：895-900. (in Chinese))
[14]	宋晓辉. 锚注加固软岩巷道机制分析及合理注浆时间的确定[硕士学位论文][D]. 泰安：山东科技大学，2006.(SONG Xiaohui. Mechanics analysis of soft rock tunnel with bolt-grouting support and the define of proper grouting time[M. S. Thesis][D]. Tai′an：Shandong University of Science and Technology，2006.(in Chinese)) " target="_blank">
[15]	曾凡宇. 软岩及动压巷道失稳机制与支护方法[J]. 煤炭学报，2007，32(6)：573-576.(ZENG Fanyu. The loss of stability and supporting method for the soft and dynamic tunnels[J]. Journal of China Coal Society，2007，32(6)：573-576.(in Chinese))
[2]	何满潮，齐干，程骋，等. 深部复合顶板煤巷变形破坏机制及耦合支护设计[J]. 岩石力学与工程学报，2007，26(5)：987-993. (HE Manchao，QI Gan，CHENG Cheng，et al. Deformation and damage mechanisms and coupling support design in deep coal roadway with compound roof[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(5)：987-993.(in Chinese))
[8]	唐建新，邓月华，涂兴东，等. 锚网索联合支护沿空留巷顶板离层分析[J]. 煤炭学报，2010，35(11)：1 827-1 831.(TANG Jianxin，DENG Yuehua，TU Xingdong，et al. Analysis of roof separation in gob-side entry retaining combined support with bolting wire mesh[J]. Journal of China Coal Society，2010，35(11)：1 827-1 831.(in Chinese)) " target="_blank">
[13]	康红普，吴拥政，李建波. 锚杆支护组合构件的力学性能与支护效果分析[J]. 煤炭学报，2010，35(7)：1 057-1 065.(KANG Hongpu，WU Yongzheng，LI Jianbo. Analysis of mechanical performances and supporting function of combination components for rock bolting[J]. Journal of China Coal Society，2010，35(7)：1 057-1 065.(in Chinese)) " target="_blank">
[9]	赵海军，马凤山，丁德民，等. 采动影响下巷道变形机制与破坏模式[J]. 煤炭学报，2009，34(5)：599-604.(ZHAO Haijun，MA Fengshan，DING Demin，et al. Roadway deformation mechanism and failure model under the influence of mining[J]. Journal of China Coal Society，2009，34(5)：599-604.(in Chinese))
[17]	何满潮，孙晓明. 中国煤矿软岩巷道工程支护设计与施工指南[M]. 北京：科学出版社，2004：56-101.(HE Manchao，SUN Xiaoming. Support design and construction guide of soft rock roadway engineering in Chinese coal mines[M]. Beijing：Science Press，2004：56-101.(in Chinese)) " target="_blank">
[3]	许广，唐又驰. 深部软岩煤巷围岩变形分析与控制技术研究[J]. 中国安全科学学报，2011，21(2)：109-114.(XU Guang，TANG Youchi. Research on deformation and control of coal tunnel in deep soft rock[J]. Journal of China Coal Society，2011，21(2)：109-114. (in Chinese))
[6]	WANG S L，ZHENG H，LI C G．A finite element implementation of strain-softening rock mass[J]. International Journal of Rock Mechanics and Mining Sciences，2011，48(1)：67-76.
[12]	王卫军，冯涛. 加固两帮控制深井巷道底鼓的机制研究[J]. 岩石力学与工程学报，2005，24(5)：808-811.(WANG Weijun，FENG Tao. Study on mechanism of reinforcing sides to control floor heave of extraction opening[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(5)：808-811.(in Chinese))
[16]	杨玉亮. 采动巷道支护参数优化设计研究[J]. 煤炭技术，2011，30(3)：81-82.(YANG Yuliang. Study on support parameter optimization of mining induced roadway[J]. Coal Technology，2011，30(3)：81-82.(in Chinese)) " target="_blank">