特厚煤层高强度综放开采水力压裂顶板控制技术研究

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1245 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要针对塔山煤矿临空顺槽矿压显现剧烈的问题，进行水力压裂弱化煤层上覆坚硬K3老顶的现场试验，通过水力压裂期间监测钻孔以及巷道两侧锚杆出水情况与水压的变化分析水力压裂的影响范围，通过水力压裂前后周期来压步距、动载系数、顶板下沉量、两帮移近量、煤壁片帮统计、工作阻力与瓦斯涌出情况，深入分析水力压裂弱化坚硬老顶的特点。试验结果表明：(1) 切槽裂隙在水力压裂的作用下其扩展范围不超过55 m；(2) 裂缝所处的煤岩体环境使得裂缝扩展的压力时间曲线呈现3种轨迹形态；(3) 水力压裂前后，周期来压步距分别为18.69，16.76 m，平均周期来压动载系数分别为1.69，1.53；顶板下沉量与两帮移近量都明显缩小，巷道顶板整体完整；煤壁片帮深度平均值由原来的31.18 m变为7.06 m；瓦斯涌出相对稳定，上隅角瓦斯浓度由原来的0.20%降低为0.15%。工作面顶板完整性和强度得到了弱化，随工作面推进顶板能够及时垮落，5106临空顺槽顶板的压力明显减弱，说明水力压裂的效果良好，研究结果对类似条件下的工作面具有积极的指导意义。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：采矿工程, 水力压裂, 工作阻力, 瓦斯涌出, 顶板弱化, 矿压显现

Abstract：The hydraulic fracturing field tests to weaken the hard K3 upper roof above coal layer were conducted when severe problems occurred in the open-air and crossheading strata at Tashan Coal Mine. The water pressures in the boreholes and water oozing from bolt locations at two sides of roadways were monitored during the process of hydraulic fracturing to analyze the range of influence of hydraulic fracturing. The characteristics of weakening the hard roof by hydraulic fracturing were analyzed according to the step size of periodic pressure，the dynamic loading factor，the deflections of roof，the displacements of roadways，the statistical analysis of rib wall and gas discharge before and after hydraulic fracturing. It was found that the range of grooving fractures produced by hydraulic fracturing was no more than 55 m. Three types of the pressure-time curve of crack propagation in the coal and rock mass were obtained. The step sizes of periodic pressure are 18.69 and 16.76 m respectively and the average periodic dynamic pressure factors are 1.69 and 1.53 respectively before and after hydraulic fracturing. Both the deflection of roof and the displacement of roadways were greatly reduced and the roof of the roadways remained unbroken. The average depths of coal wall rib spalling were reduced from the original 31.18 m to 7.06 m. Besides，the gas release is relatively stable. The gas density at the upper corner was reduced from the original 0.20% to 0.15%. Meanwhile，the completeness and strength of the roof at the working front were weakened and roof was dropped as working front proceeds.

Key words： mining engineering hydraulic fracturing working resistance gas release roof weakening strata behaviors

收稿日期: 2013-08-22

引用本文:

于斌1，2，段宏飞2. 特厚煤层高强度综放开采水力压裂顶板控制技术研究[J]. 岩石力学与工程学报, 2014, 33(4): 778-785.
YU Bin1，2，DUAN Hongfei2. STUDY OF ROOF CONTROL BY HYDRAULIC FRACTURING IN FULL-MECHANIZED CAVING MINING WITH HIGH STRENGTH IN EXTRA-THICK COAL LAYER. , 2014, 33(4): 778-785.

链接本文:

http://www.rockmech.org/CN/Y2014/V33/I4/778

[2]	于斌. 大同矿区综采40a开采技术研究[J]. 煤炭学报，2010，35(11)：1 772-1 777.(YU Bin. Study on fully mechanized coal mining technology in passed 40 years in Datong mining area[J]. Journal of China Coal Society，2010，35(11)：1 772-1 777.(in Chinese)) " target="_blank">
[4]	王金安，李大钟，尚新春. 采空区坚硬顶板流变破断力学分析[J]. 北京科技大学学报，2011，33(2)：142-148.(WANG Jin?an，LI Dazhong，SHANG Xinchun. Mechanics analysis of creep fracture of strong roof strata above mined-out area[J]. Journal of University of Science and Technology Beijing，2011，33(2)：142-148.(in Chinese))
[6]	谭云亮，何孔翔，马植胜，等. 坚硬顶板冒落的离层遥测预报系统研究[J]. 岩石力学与工程学报，2006，25(8)：1 705-1 709.(TAN Yunliang，HE Kongxiang，MA Zhisheng，et al. Researches on remote monitoring and forecasting system for hard roof fall[J]. Chinese Journal of Rock Mechanics and Engineering，2006，25(8)：1 705-1 709. (in Chinese))
[8]	邓广哲，王世斌，黄炳香. 煤岩水压裂缝扩展行为特性研究[J]. 岩石力学与工程学报，2004，23(20)：3 489-3 493.(DENG Guangzhe，WANG Shibin，HUANG Bingxiang. Research on behavior character of crack development induced by hydraulic fracturing in coal- rockmass[J]. Chinese Journal of Rock Mechanics and Engineering，2004，23(20)：3 489-3 493.(in Chinese))
[10]	YEW D H. Mechanics of hydraulic fracturing[M]. Houston：[s. n.]，1997：2-4. " target="_blank">
[1]	冯彦军，康红普. 定向水力压裂控制煤矿坚硬难垮顶板试验[J]. 岩石力学与工程学报，2012，31(6)：1 148-1 155.(FENG Yanjun，KANG Hongpu. Test on hard and stable roof control by means of directional hydraulic fracturing in coal mine[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(6)：1 148-1 155.(in Chinese))
[3]	孙守山，宁宇，葛钧. 波兰煤矿坚硬顶板定向水力压裂技术[J]. 煤炭科学技术，1999，27(2)：51-52.(SUN Shoushan，NING Yu，GE Jun. Hydraulic directional creaking technology applied in hard roof of poland coal mine[J]. Coal Science and Technology，1999，27(2)：51-52.(in Chinese))
[5]	潘岳，王志强，李爱武. 初次断裂期间超前工作面坚硬顶板挠度、弯矩和能量变化的解析解[J]. 岩石力学与工程学报，2012，31(1)：32-41.(PAN Yue，WANG Zhiqiang，LI Aiwu. Analytic solutions of deflection，bending moment and energy change of tight roof advanced working surface during initial fracturing[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(1)：32-41.(in Chinese))
[7]	闫少宏，宁宇，康立军，等. 用水力压裂处理坚硬顶板的机制及试验研究[J]. 煤炭学报，2000，25(1)：32-35.(YAN Shaohong，NING Yu，KANG Lijun，et al. The mechanism of hydro breakage to control hard roof and its test study[J]. Journal of China Coal Society，2000，25(1)：32-35.(in Chinese)) " target="_blank">
[9]	黄炳香，程庆迎，刘长友，等. 煤岩体水力致裂理论及其工艺技术框架[J]. 采矿与安全工程学报，2011，28(2)：167-173.(HUANG Bingxiang，CHENG Qingying，LIU Changyou，et al. Hydraulic fracturing theory of coal-rock mass and its technical framework[J]. Journal of Mining and Safety Engineering，2011，28(2)：167-173.(in Chinese))