RISK ASSESSMENT AND RESPONSE OF TBM EXCAVATION IN DEEP BURIED FRACTURED ROCK MASS
LIU Ning1，2，ZHANG Chunsheng1，CHU Weijiang1，ZHANG Chuanqing3，WU Xumin1
(1. HydroChina Huadong Engineering Corporation，Hangzhou，Zhejiang 310014，China；2. Pumped Storage Engineering center of Zhejiang Province，Hangzhou，Zhejiang 310014，China；3. State Key Laboratory of Geomechanics and Geotechnical Engineering，Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，Wuhan，Hubei 430071，China)
Abstract：TBM is known for its quick driving，but the normal driving will be affected under the unfavorable geological condition because of the limitation of equipment and the supporting capacity. TBM faces the risk of lock and even shutdown. The general depth of Jinping II diversion tunnel is more than 1 500 m，and the geological condition is very complex. When TBM driving in unfavorable geological period of Baishan group，due to the low strength of broken surrounding rock，and the poor steady ability，the risk of TBM driving need to be evaluated. First the initial mechanical parameters of rock mass were studied by excavation response of field surrounding rock. Then，comparing the displacement of different quality of rock mass and the thrust needed for TBM driving，it was found that the required thrust in the unfavorable geological condition has exceeded the provide maximum thrust，and that the displacement is also hard to limit in the range of TBM expansion. The surrounding rock has been damaged in gripper compression，and cannot provide enough thrust to ensure TBM driving. The pilot tunnel was proposed，and the calculation results show that the pilot tunnel can relieve deformation to avoid lock. Other support optimization designs and coping strategies were presented. The research results can provide good reference for similar engineerings.
刘 宁1，2，张春生1，褚卫江1，张传庆3，吴旭敏1. 深埋破碎岩体TBM掘进风险评估与应对[J]. 岩石力学与工程学报, 2015, 34(s1): 3348-3355.
LIU Ning1，2，ZHANG Chunsheng1，CHU Weijiang1，ZHANG Chuanqing3，WU Xumin1. RISK ASSESSMENT AND RESPONSE OF TBM EXCAVATION IN DEEP BURIED FRACTURED ROCK MASS. , 2015, 34(s1): 3348-3355.
吴世勇，王 鸽，徐劲松，等. 锦屏二级水电站TBM选型及施工关键技术研究[J]. 岩石力学与工程学报，2008，27(10)：2 000-2 009. (WU Shiyong，WANG Ge，XU Jinsong，et al. Research on TBM type-selection and key construction technology for Jinping II hydropower station[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(10)：2 000-2 009.(in Chinese))
<body>Your browse does not support frame!</body>
2015, Vol. 34 
