不同装药模式爆破载荷作用下煤层裂隙扩展特征试验研究

doi:10.13722/j.cnki.jrme.2015.0865

摘要
图/表
参考文献
相关文章 (0)

全文: PDF (601 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为了研究炸药在不同煤岩介质中爆破所产生的裂隙扩展和力学特征，提高深孔预裂爆破对低透气性煤层进行增透的效果，在实验室搭建爆破模拟试验系统，设计穿层钻孔和顺层钻孔2种不同的装药模式，以Froude 比例法建立煤层深孔预裂爆破的试验模型，利用相似材料配比加工制备尺寸为50 cm×50 cm×50 cm的试样进行爆破模拟试验。通过超动态应变仪监测煤岩层的应变信号，利用高速摄像仪记录试样完整的裂纹萌生、扩展、贯通直至试样破坏的全过程，分析爆破载荷作用下试样的动态力学特性和裂纹扩展特性。研究发现，裂纹主要是由压缩波与卸载波共同作用形成的，裂纹扩展方向与炮孔轴线方向垂直；在煤岩介质中实施穿层钻孔爆破的爆破效果优于顺层钻孔煤层爆破效果，当爆破应力波从煤层入射到岩层后，出现反射拉伸波，反作用于煤体上，加剧煤岩不同爆破介质的破坏程度，促使爆破裂隙的扩展。研究成果可用于指导井下低透气性煤层深孔预裂爆破装药方式的选择，以提高瓦斯抽采效率。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：爆破力学；深孔爆破；煤&ndash, 岩介质；瓦斯灾害；增透

Abstract：In order to stduy the crack extension and mechanical characters of explosive blasting in different layers of coal-rock media and to increase the permeability of coal seam of low permeability in the deep hole pre-splitting blasting，a blasting simulation test system was set up in the laboratory. Two different charging modes of drilling borehole，cross and down the seam，were designed. Deep hole pre-splitting blasting test model was built based on Froude proportion method and the samples with the size of 50 cm×50 cm×50 cm were prepared with the similar materials. Under the above conditions，blasting simulation tests were carried out. The strain signals of coal rock were monitored with the super dynamic strain gauge. The whole process from the crack initiation，expansion and breaking through to the destruction of samples was recorded with the high speed camera. The dynamic mechanical and crack propagation properties under blasting loading were analyzed. The results showed that the cracks were mainly formed by the interaction of the compression and unloading waves and the direction of crack propagation was perpendicular to axis direction of hole. The effect of drilling blasting with borehole cross the seam was better than that down the seam. When the blasting stress wave was from the coal seam to the rock，the reflected tension shock wave was arisen to react on coal seam，which resulted in the aggravated damage of different coal-rock media and prompted blasting crack extension.

Key words： blasting mechanics deep borehole blasting layers of coal-rock media gas disaster increasing permeability

引用本文:

刘健1，2，3，刘泽功1，2，高魁1，2，薛俊华3，娄亚北1，2. 不同装药模式爆破载荷作用下煤层裂隙扩展特征试验研究[J]. 岩石力学与工程学报, 2016, 35(04): 735-742.
LIU Jian1，2，3，LIU Zegong1，2，GAO Kui1，2，XUE Junhua3，LOU Yabei1，2. Experimental study of extension characters of cracks in coal seam under blasting load with different charging modes. , 2016, 35(04): 735-742.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2015.0865 或 http://www.rockmech.org/CN/Y2016/V35/I04/735

[1]	杨仁树，王雁冰，岳中文，等. 定向断裂双孔爆破裂纹扩展的动态行为[J]. 爆炸与冲击，2013，33(6)：631-637.(YANG Renshu，WANG Yanbing，YUE Zhongwen，et al. Dynamic behaviors of crack propagation in directional fracture blast with two holes[J]. Explosion and Shock Waves，2013，33(6)：631-637.(in Chinese)) " target="_blank">
[5]	穆朝民，王海露，黄文尧，等. 高瓦斯低透气性煤体定向聚能爆破增透机制[J]. 岩土力学，2013，34(9)：2 496-2 500.(MU Chaomin，WANG Hailu，HUANG Wenyao，et al. Increasing permeability mechanism using directional cumulative blasting in coal seams with high concentration of gas and low permeability[J]. Rock and Soil Mechanics，2013，34(9)：2 496-2 500.(in Chinese)) " target="_blank">
[12]	褚怀保，杨小林，梁为民，等. 煤体爆破作用机理模拟试验研究[J]. 煤炭学报，2011，36(9)：1 451-1 456.(CHU Huaibao，YANG Xiaolin，LIANG Weimin，et al. Simulation experimental study on the coal blast mechanism[J]. Journal of China Coal Society，2011，36(9)：1 451-1 456.(in Chinese)) " target="_blank">
[13]	郑福良. 含瓦斯煤体爆破裂隙发展规律的探讨[J]. 煤炭科学技术，1997，25(2)：23-26.(ZHENG Fuliang. The law of development of explosion fracture in gas coal[J]. Coal Science and Technology，1997，25(2)：23-26.(in Chinese)) " target="_blank">
[14]	褚怀保，杨小林，梁为民. 煤体爆破损伤规律模拟试验研究[J]. 采矿与安全工程学报，2011，28(3)：488-492.(CHU Huaibao，YANG Xiaolin，LIANG Weimin. Experimental study on the blast damage law in simulation coal[J]. Journal of Mining and Safety Engineering，2011，28(3)：488-492.(in Chinese)) " target="_blank">
[15]	褚怀保，侯爱军，杨小林，等. 含瓦斯煤体爆破裂纹扩展规律试验研究[J]. 采矿与安全工程学报，2012，29(6)：894-898.(CHU Huaibao，HOU Aijun，YANG Xiaolin，et al. Experimental study on regularity of blasting crack spread in a coal contained gas[J]. Journal of Mining and Safety Engineering，2012，29(6)：894-898.(in Chinese))
[16]	褚怀保，杨小林，侯爱军，等. 煤体中爆炸应力波传播与衰减规律模拟实验研究[J]. 爆炸与冲击，2012，32(2)：185-189.(CHU Huaibao，YANG Xiaolin，HOU Aijun，et al. A simulation-based experimental study on explosion stress wave propagation and attenuation in coal[J]. Explosion and Shock Waves，2012，32(2)：185-189.(in Chinese)) " target="_blank">
[2]	郭德勇，裴海波，宋建成，等. 煤层深孔聚能爆破致裂增透机制研究[J]. 煤炭学报，2008，33(12)：1 381-1 385.(GUO Deyong，PEI Haibo，SONG Jiancheng，et al. Study on splitting mechanism of coal bed deep-hole cumulative blasting to improve permeability[J]. Journal of China Coal Society，2008，33(12)：1 381-1 385.(in Chinese)) " target="_blank">
[3]	郭德勇，吕鹏飞，裴海波，等. 煤层深孔聚能爆破裂隙扩展数值模拟[J]. 煤炭学报，2012，37(2)：274-278.(GUO Deyong，LU Pengfei，PEI Haibo，et al. Numerical simulation on crack propagation of coal bed deep-hole cumulative blasting[J]. Journal of China Coal Society，2012，37(2)：274-278.(in Chinese))
[4]	张超，林柏泉，周延，等. 控制爆破致裂提高矿井瓦斯抽放率试验研究[J]. 煤炭学报，2014，39(增1)：100-104.(ZHANG Chao，LIN Baiquan，ZHOU Yan，et al. Application of multi-seam metal jet directed pre-split blasting technology in gas extraction[J]. Journal of China Coal Society，2014，39(Supp.1)：100-104.(in Chinese)) " target="_blank">
[6]	龚敏，刘万波，王德胜，等. 提高煤矿瓦斯抽放效果的控制爆破技术[J]. 北京科技大学学报，2006，28(3)：223-226.(GONG Min，LIU Wanbo，WANG Desheng，et al. Control blasting technique to improve gas predrainage effect in a coal mine[J]. Journal of University of Science and Technology Beijing，2006，28(3)：223-226.(in Chinese)) " target="_blank">
[7]	余永强，杨小林，梁为民，等. 控制爆破致裂提高矿井瓦斯抽放率试验研究[J]. 煤炭学报，2007，32(4)：377-381.(YU Yongqiang，YANG Xiaolin，LIANG Weimin，et al. Testing research of improving mine gas drainage under suction by controlling blasting to cause crack[J]. Journal of China Coal Society，2007，32(4)：377-381.(in Chinese))
[8]	饶俊. 矿山地压相似材料模型应力测量的应变砖法[J]. 南方冶金学院学报，1998，19(2)：91-95.(RAO Jun．Measuring stress in the ground pressure model by the strain gauge[J]. Journal of southern institute of metallurgy，1998，19(2)：91-95.(in Chinese)) " target="_blank">
[9]	穆朝民，齐娟. 爆炸荷载作用下煤体裂纹扩展机理模型实验研究[J]. 振动与冲击，2012，31(13)：58-61.(MU Chaomin，QI Juan. Model investigation on cracks propagation in coal under blast loading[J]. Journal of Vibration and Shock，2012，31(13)：58-61.(in Chinese))
[10]	龚敏，熊本良，王楚翰，等. 穿层爆破各煤层动态应力分布与抽放效果探讨[J]. 岩石力学与工程学报，2012，31(增1)：2 899-2 996. (GONG Min，XIONG Benliang，WANG Chuhan，et al. Discussion on distribution of dynamic stress and gas draining efficiency in coal seams by blasting through layers of coal-rock[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(Supp.1)：2 899-2 996.(in Chinese)) " target="_blank">
[11]	戴俊. 柱状装药爆破的岩石压碎圈与裂隙圈计算[J]. 辽宁工程技术大学学报：自然科学版，2001，20(2)：144-147.(DAI Jun. Calculation of radii of the broken and cracked areas in rock by a long charge explosion[J]. Journal of Liaoning Technical University：Natural Science，2001，20(2)：144-147.(in Chinese)) " target="_blank">