基于徐州矿区煅烧煤矸石细集料活性的砂浆孔结构研究

doi:10.13722/j.cnki.jrme.2015.0620

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (747 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要采用X射线衍射法(XRD)、压汞法(MIP)以及环境扫描电镜(SEM)分析方法，研究煤矸石细集料在不同煅烧温度下的活性，并对不同活性的煤矸石细集料水泥硬化砂浆的孔结构进行探讨，并进一步分析孔结构与砂浆强度之间的关系。试验结果研究表明：不同活性的煤矸石细集料，在水化初期可以与水泥水化产物发生不同程度的二次水化反应，煤矸石细集料活性会对水泥硬化砂浆的孔径分布和孔隙率产生一定影响。采用较高活性的煅烧煤矸石细集料，可以降低水泥硬化砂浆的孔隙率和优化孔径分布，且大于200 nm的有害孔明显减少，100，20 nm以下的无害孔和少害孔相应增加，水泥硬化砂浆的水化产物相应增多。煅烧煤矸石细集料的活性由低到高，可以使砂浆的孔隙得到细化，更能有效地改善砂浆的孔结构，降低其孔隙率，能够提高砂浆的强度。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：采矿工程, 煅烧煤矸石细集料, 砂浆, 孔结构, 水化反应

Abstract：The X-ray diffraction(XRD)，the mercury intrusion porosimetry(MIP) and the environmental scanning electron microscope(SEM) were used to study the activity of fine aggregate of coal gangue under different calcination temperatures and the pore structure of hardened cement mortar of fine aggregate. The relationship between the pore structure and the strength of cement mortar was analyzed. The fine aggregates of coal gangue of different activity had the different levels of secondary hydration reaction with the hydration products of cement in the early period of hydration. The activity of fine aggregate of coal gangue affected the pore size distribution and porosity of hardened cement mortar. A highly active fine aggregate of coal gangue reduced the porosity of hardened cement mortar and optimized the pore size distribution. The harmful holes greater than 200 nm decreased significantly and the less harm or harmless holes of 100，20 nm increased. The hydration products of hardened cement mortar increased accordingly. The activity of calcined fine aggregate of coal gangue from low to high refined the porosity of the mortar，improved effectively the pore structure of cement mortar，reduced its porosity，and improved the strength of the mortar.

Key words： mining engineering calcined fine aggregate of coal gangue mortar pore structure hydration reaction

引用本文:

董作超1，夏军武1，2，段晓牧1，张志雄1. 基于徐州矿区煅烧煤矸石细集料活性的砂浆孔结构研究[J]. 岩石力学与工程学报, 2016, 35(04): 819-825.
DONG Zuochao1，XIA Junwu1，2，DUAN Xiaomu1，ZHANG Zhixiong1. Pore structure of fine aggregate mortar based on the activity of calcined coal gangue from Xuzhou mining area. , 2016, 35(04): 819-825.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2015.0620 或 http://www.rockmech.org/CN/Y2016/V35/I04/819

[12]	段晓牧，夏军武，杨风州，等. 煤矸石集料性质对混凝土力学性能影响的试验研究[J]. 工业建筑，2014，44(3)：114-118.(DUAN Xiaomu，XIA Junwu，YANG Fengzhou，et al. Experimental research on the influence of coal gangue aggregate behavior on the mechanical properties of concrete[J]. Industrial Construction，2014，44(3)：114-118.(in Chinese)) " target="_blank">
[24]	马成理. 自燃煤矸石的材料性能试验研究[J]. 太原理工大学学报，2003，34(2)：154-157.(MA Chengli. The test of natural coal spoil material characteristics[J]. Journal of Taiyuan University of Technology，2003，34(2)：154-157.(in Chinese)) " target="_blank">
[25]	段晓牧. 煤矸石集料混凝土的微观结构与物理力学性能研究[博士学位论文][D]. 徐州：中国矿业大学，2014.(DUAN Xiaomu. Study on the micro-structure and physica-mechanical performance of concrete with coal gangue as aggregate[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，2014.(in Chinese)) " target="_blank">
[28]	杨林虎，朱涵，张亚梅. 橡胶集料对水泥砂浆孔结构的影响[J].天津大学学报，2011，44(12)：1 083-1 087.(YANG Linhu，ZHU Han，ZHANG Yamei. Effect of crumb rubber on pore structure of cement mortar[J]. Journal of Tianjin University，2011，44(12)：1 083- 1 087.(in Chinese)) " target="_blank">
[29]	田正宏，白凯国，朱静. 透水模板布改善混凝土表层质量试验研究[J]. 东南大学学报：自然科学版，2008，38(1)：146-150.(TIAN Zhenghong，BAI Kaiguo，ZHU Jing. Study on surface quality of concrete improved by infiltrating formwork texture[J]. Journal of Southeast University：Natural Science，2008，38(1)：146-150.(in Chinese)) " target="_blank">
[30]	韦江雄，余其俊，曾小星，等. 混凝土中孔结构的分形维数研究[J].华南理工大学学报：自然科学版，2007，35(2)：121-124.(WEI Jiangxiong，YU Qijun，ZENG Xiaoxing，et al. Fractal dimension of pore structure of concrete[J]. Journal of South China University of Technology：Natural Science，2007，35(2)：121-124.(in Chinese)) " target="_blank">
[31]	DONG Z C，XIA J W，FAN C，et al. Activity of calcined coal gangue fine aggregate and its effect on the mechanical behavior of cement mortar[J]. Construction and Building Materials，2015，100：63-69. " target="_blank">
[32]	吴中伟，廉慧珍. 高性能混凝土[M]. 北京：中国铁道出版社，1999：22-27.(WU Zhongwei，LIAN Huizhen. High performance concrete[M]. Beijing：China Railway Publishing House，1999：22-27.(in Chinese)) " target="_blank">
[19]	詹炳根，孙伟，沙建芳，等. 煤矸石对混凝土碱硅酸反应损伤的抑制作用[J]. 建筑材料学报，2008，11(3)：253-258.(ZHAN Binggen，SUN Wei，SHA Jianfang，et al. Mitigation of coal gangue on damage of concrete caused by alkali-silica reaction[J]. Journal of Building Materials，2008，11(3)：253-258.(in Chinese)) " target="_blank">
[22]	李化建，孙恒虎，肖雪军. 煤矸石质硅铝基胶凝材料的试验研究[J]. 煤炭学报，2005，30(6)：778-782.(LI Huajian，SUN Henghu，XIAO Xuejun. Study on gangue-containing aluminosilicate based cementitious materials[J]. Journal of China Coal Society，2005，30(6)：778-782. (in Chinese))
[20]	段晓牧，夏军武，杨风州，等. 煤矸石细集料-水泥基材料力学性能影响的试验研究[J]. 工业建筑，2014，44(2)：98-102.(DUAN Xiaomu，XIA Junwu，YANG Fengzhou，et al. Experimental research on the influence of coal gangue fine aggregate-cement-based materials on the mechanical properties[J]. Industrial Construction，2014，44(2)：98-102.(in Chinese)) " target="_blank">
[23]	周梅，赵华民，路其林，等. 自燃煤矸石集料预处理对混凝土工作性及强度影响[J]. 工业建筑，2014，44(12)：113-117.(ZHOU Mei，ZHAO Huamin，LU Qilin，et al. The effects of pretreatment of spontaneous combustion gangue aggregate on the workability and strength of concrete[J]. Industrial Construction，2014，44(12)：113-117. (in Chinese)) " target="_blank">
[27]	ERDEM T K，MERAL C，TOKYAY M，et al. Use of perlite as a pozzolanic addition in producing blended cements[J]. Cement Concrete Composites，2007，29(1)：13-21.
[5]	但建明，王培铭. 煤矸石细度和掺量对水泥性能的影响[J]. 建筑材料学报，2007，10(1)：77-82.(DAN Jianming，WANG Peiming. Influence of fineness and content of coal gangue on properties of cement pastes[J]. Journal of Building Materials，2007，10(1)：77-82.(in Chinese)) " target="_blank">
[7]	孙志华，刘开平，汪敏强，等. 自燃煤矸石活性研究[J]. 建筑材料学报，2013，16(3)：497-502.(SUN Zhihua，LIU Kaiping，WANG Minqiang，et al. Study on activation properties of spontaneous combustion coal gangue[J]. Journal of Building Materials，2013，16(3)：497-502. (in Chinese)) " target="_blank">
[18]	张吉秀，孙恒虎，万建华，等. 煅烧煤矸石胶凝活性评价方法分析[J]. 哈尔滨工业大学学报，2010，42(9)：1 438-1 443.(ZHANG Jixiu，SUN Henghu，WAN Jianhua，et al. Analysis of pozzolanic activity evaluation methods for calcined coal gangue[J]. Journal of Harbin Institute of Technology，2010，42(9)：1 438-1 443.(in Chinese)) " target="_blank">
[17]	吴秀峰，周梅，崔正龙. 自燃煤矸石粗集料对混凝土强度影响的试验研究[J]. 工业建筑，2009，39(3)：81-85.(WU Xiufeng，ZHOU Mei，CUI Zhenglong. The experiment research on concrete strength influence of self combustion coal gangue coarse aggregate[J]. Industrial Construction，2009，39(3)：81-85.(in Chinese)) " target="_blank">
[21]	陈炜林. 煤矸石作为水泥混凝土骨料可行性的基础研究[硕士学位论文][D]. 北京：北京工业大学，2010.(CHEN Weilin. Feasibility study of coal gangue as aggregate of cement concrete[M. S. Thesis][D]. Beijing：Beijing University of Technology，2010.(in Chinese)) " target="_blank">
[26]	喻乐华，周双喜，欧辉，等. 用作混凝土掺合料的火山岩的组成与火山灰活性[J]. 硅酸盐学报，2013，41(10)：1 387-1 394.(YU Lehua，ZHOU Shuangxi，OU Hui，et al. Constitution and pozzolanic activity of volcanic rocks used as mineral admixture in concrete[J]. Journal of the Chinese Ceramic Society，2013，41(10)：1 387-1 394. (in Chinese)) " target="_blank">
[2]	李化建. 煤矸石的综合利用[M]. 北京：化学工业出版社，2010：1-4.(LI Huajian. Comprehensive utilization of coal gangue[M]. Beijing：Chemical Industry Press，2010：1-4.(in Chinese)) " target="_blank">
[3]	段晓牧，夏军武，杨建平. 煤矸石细集料对水泥浆体微观结构的影响及其作用机理[J]. 建筑材料学报，2014，17(4)：700-705.(DUAN Xiaomu，XIA Junwu，YANG Jianping. Influence of coal gangue fine aggregate on microstructure of cement mortar and its action mechanism[J]. Journal of Building Materials，2014，17(4)：700-705. (in Chinese)) " target="_blank">
[15]	GUO W，ZHU J P，LI D X，et al. Early hydration of composite cement with thermal activated coal gangue[J]. Journal of Wuhan University of Technology：Materials Science，2010，25(1)：162-166.
[16]	陈本沛，林雨生. 煤矸石混凝土的强度和变形性能研究[J]. 工业建筑，1996，26(7)：46-51.(CHEN Benpei，LIN Yusheng. Study on the strength and deformation characteristics of gangue concrete[J]. Industrial Construction，1996，26(7)：46-51.(in Chinese)) " target="_blank">
[8]	CHINDAPRASIRT P，HOMWUTTIWONG S，SIRIVIVATNANON V. Influence of fly ash fineness on strength，drying shrinkage and sulfate resistance of blended cement mortar[J]. Cement and Concrete Research，2004，34(7)：1 087-1 092. " target="_blank">
[10]	宋旭艳，宫晨琛，李东旭. 煤矸石活化过程中结构特性和力学性能的研究[J]. 硅酸盐学报，2004，32(3)：358-363.(SONG Xuyan，GONG Chenchen，LI Dongxu. Study on structural characteristics and mechanical property of coal gangue in activation process[J]. Journal of the Chinese Ceramic Society，2004，32(3)：358-363.(in Chinese)) " target="_blank">
[11]	LI D X，SONG X Y，GONG C C. Research on cementitious behavior and mechanism of pozzolanic cement with coal gangue[J]. Cement and Concrete Research，2006，36(9)：1 752-1 759. " target="_blank">
[13]	张长森. 煤矸石资源化综合利用新技术[M]. 北京：化学工业出版社，2008：117-121.(ZHANG Changsen. Coal gangue comprehensive utilization of new technology[M]. Beijing：Chemical Industry Press，2008：117-121.(in Chinese)) " target="_blank">
[4]	郭彦霞，张圆圆，程芳琴. 煤矸石综合利用的产业化及其展望[J]. 化工学报，2014，65(7)：2 443-2 453.(GUO Yanxia，ZHANG Yuanyuan，CHENG Fangqin. Industrial development and prospect about comprehensive utilization of coal gangue[J]. CIESC Journal，2014，65(7)：2 443-2 453.(in Chinese)) " target="_blank">
[6]	刘松玉，邱钰，童立元，等. 煤矸石的强度特征试验研究[J]. 岩石力学与工程学报，2006，25(1)：199-205.(LIU Songyu，QIU Yu，TONG Liyuan，et al. Experimental study on strength properties of coal wastes[J]. Chinese Journal of Rock Mechanics and Engineering，2006，25(1)：199-205.(in Chinese))
[9]	MCCONVILLE C J，LEE W E，SHARP J N. Microstructure evolution in the fired kaolinite[J]. British Ceramic Transactions，1998，97(4)：162-168. " target="_blank">
[1]	王明立. 煤矸石压缩试验的颗粒流模拟[J]. 岩石力学与工程学报，2013，32(7)：1 350-1 357.(WANG Mingli. Simulation of compression test on gangue by PFC3D[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(7)：1 350-1 357.(in Chinese)) " target="_blank">
[14]	FENG S X，WANG P M，LIU X P. Effect of gangue on hydration process of Portland cement[J]. Journal of the Chinese Ceramic Society，2010，38(9)：1 682-1 687. " target="_blank">