温度冲击下煤体裂隙结构演化的显微CT实验研究

doi:10.13722/j.cnki.jrme.2018.0364

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (790 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究温度冲击下煤体裂隙结构演化特征，以期从微细观方面揭示煤体对温度的响应机制。采用SLX–80型高低温实验系统对原煤进行4种温差条件下的冷热冲击实验，利用工业显微CT系统对温度冲击前后的煤样进行扫描和裂隙结构的三维立体重建，基于VGStudio MAX图像分析系统建立煤样清晰的裂隙可视模型，并对煤体裂隙结构演化特征进行量化表征，运用非定常热应力理论分析温度冲击下的破煤机制。研究结果表明：温度冲击促使煤体内部裂隙扩展加宽，萌生新裂隙，裂隙体积、壁厚、表面积均与温差呈正相关关系，不同温差产生的热应力决定了煤样的损伤程度；温度冲击过程中产生了大量的声发射信号，声发射信号的产生主要集中在前600 s，且温差越大所产生的声发射能量越高；温度冲击所产生的最大热应力位于煤样表面的切向方向，热应力超过煤样抗拉强度是导致裂隙萌生、扩展和相互贯通的直接原因。研究结果可为煤层气高效开发和提高煤层瓦斯抽采率提供技术支撑。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王登科1
	2
	3
	4
	张平1
	3
	浦海2
	魏建平1
	3
	4
	刘淑敏1
	3
	于充1
	3
	孙刘涛1
	3

关键词 ：岩石力学, 温度冲击, 显微CT, 热应力, 裂隙结构, 破煤机制

Abstract：The mechanism and characteristics of coal cracking under temperature shock was studied with micro-CT. The high-low temperature test system SLX–80 was used to exert the cold and heat shock on the raw coal with four temperature differences designated. The industrial micro-CT system was used to scan the coal samples before and after the temperature shock so that three-dimensional fracture structure of coal samples may be reconstructed with the image analysis system VG Studio MAX. The characteristics of cracking process were described quantitatively. The transient thermal stress theory was used to analyze the coal breaking mechanism under temperature shock. The results show that the temperature shock promotes the expansion and widening of cracks within the coal body and initiates new cracks. The crack volume，wall thickness and surface area are all positively correlated with the temperature difference，indicating that the thermal stress generated by different temperature differences determines the degree of damage of coal samples. A large number of acoustic emission signals were generated in the process of temperature shock and mainly concentrated in the first 600 s. The greater the temperature difference is，the higher the acoustic emission energy. The maximum thermal stress generated is tangential to the coal surface. The thermal stress exceeding the tensile strength of coal samples cause directly the initiation，propagation，and interpenetration of fissures.

Key words： rock mechanics temperature shock micro-CT thermal stress crack structure coal broken mechanism

引用本文:

王登科1，2，3，4，张平1，3，浦海2，魏建平1，3，4，刘淑敏1，3，于充1，3，孙刘涛1，3. 温度冲击下煤体裂隙结构演化的显微CT实验研究[J]. 岩石力学与工程学报, 2018, 37(10): 2243-2252.
WANG Dengke1，2，3，4，ZHANG Ping1，3，PU Hai2，WEI Jianping1，3，4，LIU Shumin1，3， YU Chong1，3，SUN Liutao1，3. Experimental research on cracking process of coal under temperature variation with industrial micro-CT#br#. , 2018, 37(10): 2243-2252.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2018.0364 或 http://www.rockmech.org/CN/Y2018/V37/I10/2243

[2]	SUN W J，FENG Y Y，JIANG C F，et al. Fractal characterization and methane adsorption features of coal particles taken from shallow and deep coalmine layers[J]. Fuel，2015，155(9)：7-13.
[4]	王登科，彭明，付启超，等. 瓦斯抽采过程中的煤层透气性动态演化规律与数值模拟[J]. 岩石力学与工程学报，2016，35(4)：704-712.(WANG Dengke，PENG Ming，FU Qichao，et al. Dynamic evolution laws of coal permeability and numerical simulation during gas drainage in coal seams[J]. Chinese Journal of Rock Mechanics and Engineering，2016，35(4)：704-712.(in Chinese))
[7]	孙赞东. 非常规油气勘探与开发[M]. 北京：石油工业出版社，2011：25-32.(SUN Zandong. Unconventional oil and gas exploration and development[M]. Beijing：Petroleum Industry Press，2011：25-32. (in Chinese))
[12]	张春会，李伟龙，王锡朝，等. 液氮溶浸煤致裂的机理研究[J]. 河北科技大学学报，2015，36(4)：425-430.(ZHANG Chunhui，LI Weilong，WANG Xichao，et al. Research of fracturing mechanism of coal subjected to liquid nitrogen cooling[J]. Journal of Hebei University of Science and Technology，2015，36(4)：425-430.(in Chinese))
[14]	李和万，王来贵，牛富民，等. 冷热交替作用致煤样裂隙结构损伤试验[J]. 安全与环境学报，2016，16(1)：40-43.(LI Hewan，WANG Laigui，NIU Fumin，et al. Experimental study on thestructure crack damage of the coal samples via the abrupt temperature-changing cycles[J]. Journal of Safety and Environment，2016，16(1)：40-43.(in Chinese))
[22]	于伟东，梁卫国，于艳梅，等. 三轴等压条件下400 ℃内褐煤变形及结构衍化实验研究[J]. 岩石力学与工程学报，2017，36(7)： 1 718-1 725.(YU Weidong，LIANG Weiguo，YU Yanmei，et al. Experiment investigation of lignite deformation and structure evolution under triaxial constant stress at temperature below 400 ℃[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(7)： 1 718-1 725.(in Chinese))
[24]	王笑然，王恩元，刘晓斐，等. 裂隙砂岩裂纹扩展声发射响应及速率效应研究[J]. 岩石力学与工程学报，2018，37(6)：1 446-1 458. (WANG Xiaoran，WANG Enyuan，LIU Xiaofei，et al. Macro-crack propagation process and corresponding AE behaviors of fractured sandstone under different loading rates[J]. Chinese Journal of Rock Mechanics and Engineering，2018，37(6)：1 446-1 458.(in Chinese))
[32]	刘淑敏. 温度冲击下煤的力学特性与本构模型研究[硕士学位论文][D]. 焦作：河南理工大学，2017：13-30.(LIU Shumin. Research on mechanical properties and constitutive model of coal under temperature impact[M. S. Thesis][D]. Jiaozuo：Henan Polytechnic University，2017：13-30.(in Chinese))
[10]	COETZEE S，NEOMAGUS H W J P，BUNT J R，et al. The transient swelling behavior of large(－20 + 16 mm) South African coal particles during low-temperature devolatilisation[J]. Fuel，2014，136(10)：79-88.
[20]	于艳梅，胡耀青，梁卫国，等. 应用CT技术研究瘦煤在不同温度下孔隙变化特征[J]. 地球物理学报，2012，55(2)：637-644.(YU Yanmei，HU Yaoqing，LIANG Weiguo，et al. Study on pore characteristics of lean coal at different temperature by CT technology[J]. Chinese Journal of Geophys，2012，55(2)：637-644.(in Chinese))
[30]	OKUBO S，FUKUI K，QI Q. Uniaxial compression and tension tests of anthracite and loading rate dependence of peak strength[J]. International Journal of Coal Geology，2006，68(3/4)：196-204.
[8]	BRYANT J E，HAGGSTROM J. An environmental solution to help reduce freshwater demands and minimize chemical use[J]. SPE 153867，2012：1-10.
[1]	FENG Z，ZHOU D，ZHAO Y，et al. Study on microstructural changes of coal after methane adsorption[J]. Journal of Natural Gas Science and Engineering，2016，30(5)：28-37.
[3]	MITRA A，HARPALANI S，LIU S M. Laboratory measurement and modeling of coal permeability with continued methane production： Part 1—Laboratory results[J]. Fuel，2012，94(1)：110-116.
[5]	WANG D K，WEI J P，FU Q C，et al. Seepage law and permeability calculation of coal gas based on Klinkenberg effect[J]. Journal of Central South University，2015，22(5)：1 973-1 978.
[6]	魏建平，秦恒洁，王登科，等. 含瓦斯煤渗透率动态演化模型[J]. 煤炭学报，2015，40(7)：1 555-1 561.(WEI Jianping，QIN Hengjie，WANG Dengke，et al. Dynamic permeability model for coal containing gas[J]. Journal of China Coal Society，2015，40(7)：1 555-1 561.(in Chinese))
[9]	HOLTSCLAW J，LOVELESS D，SAINI R，et al. Environmentally focused crosslinked-gel system results in high retained proppant-pack conductivity[J]. SPE 153867，2011：2 803-2 815.
[11]	任韶然，范志坤，张亮，等. 液氮对煤岩的冷冲击作用机制及试验研究[J]. 岩石力学与工程学报，2013，32(增2)：3 790-3 794. (REN Shaoran，FAN Zhikun，ZHANG Liang，et al. Mechanisms and experimental study of thermal-shock effect on coal-rock using liquid nitrogen[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(Supp.2)：3 790-3 794.(in Chinese))
[13]	ZHAI C，QIN L，LIU S，et al. Pore structure in coal：pore evolution after cryogenic freezing with cyclic liquid nitrogen injection and its implication on coalbed methane extraction[J]. Energy and Fuels，2016，30(7)：6 009-6 020.
[15]	李和万，王来贵，牛富民，等. 液氮对不同温度煤裂隙冻融扩展作用研究[J]. 中国安全科学学报，2015，25(10)：121-126.(LI Hewan，WANG Laigui，NIU Fumin，et al. Study on effect offreeze-haw cycle with liquid nitrogen on crack extension of coalat different initial temperatures[J]. China Safety Science Journal，2015，25(10)：121-126.(in Chinese))
[16]	WANG D，YAO B，GAO Y，et al. Effect of cyclic temperature impact on coal seam permeability[J]. Thermal Science，2017，21(Supp.1)：351-357.
[17]	魏建平，孙刘涛，王登科，等. 温度冲击作用下煤的渗透率变化规律与增透机制[J]. 煤炭学报，2017，42(8)：1 919-1 925.(WEI Jianping，SUN Liutao，WANG Dengke，et al. Change law of permeability of coal under temperature impact and the mechanism of increasing permeability[J]. Journal of China Coal Society，2017，42(8)：1 919-1 925.(in Chinese))
[19]	孟巧荣，赵阳升，胡耀青，等. 褐煤热破裂的显微CT实验研究[J]. 煤炭学报，2011，36(5)：855-860.(MENG Qiaorong，ZHAO Yangsheng，HU Yaoqing，et al. Micro-CT experimental of the thermal cracking of brown coal[J]. Journal of China Coal Society，2011，36(5)：855-860.(in Chinese))
[21]	于艳梅，胡耀青，梁卫国，等. 瘦煤热破裂规律显微CT试验[J]. 煤炭学报，2010，35(10)：1 696-1 700.(YU Yanmei，HU Yaoqing，LIANG Weiguo，et al. Micro-CT experimental research of lean coal thermal cracking laws[J]. Journal of China Coal Society，2010，35(10)：1 696-1 700.(in Chinese))
[23]	冯子军，赵阳升. 煤的热解破裂过程——孔裂隙演化的显微CT细观特征[J]. 煤炭学报，2015，40(1)：103-108.(FENG Zijun，ZHAO Yangsheng. Pyrolytic cracking in coal：meso-characteristics of pore and fissure evolution observed by micro-CT[J]. Journal of China Coal Society，2015，40(1)：103-108.(in Chinese))
[26]	严宗达，王洪礼. 热应力[M]. 北京：高等教育出版社，1993：261-284.(YAN Zongda，WANG Hongli. Thermal stress[M]. Beijing：Higher Education Press，1993：261-284.(in Chinese))
[27]	竹内洋一郎. 热应力[M]. 北京：科学出版社，1997：172-180.(TAKEUCHI Y. Thermal stress[M]. Beijing：Science Press，1997：172-180.(in Chinese))
[29]	齐庆新. 煤的直接单轴拉伸特性的试验研究[J]. 煤矿开采，2001，(4)：15-18.(QI Qingxin. Study experimental on direct uniaxial tensile properties of coal[J]. Coal Mining Technology，2001，(4)：15-18.(in Chinese))
[31]	袁振明，马羽宽，何泽云. 声发射技术及其应用[M]. 北京：机械工业出版社，1985：115-120.(YUAN Zhenming，MA Yukuan，HE Zeyun. Acoustic emission technology and its application[M]. Beijing：Mechanical Industry Press，1985：115-120.(in Chinese))
[33]	孙刘涛. 温度冲击下煤的微观结构变化与渗透性特性研究[硕士学位论文][D]. 焦作：河南理工大学，2017：23-32.(SUN Liutao. Research on increasing-permeability and microstructure evolution law of coal under temperature shock[M. S. Thesis][D]. Jiaozuo：Henan Polytechnic University，2017：23-32.(in Chinese))
[18]	孟巧荣，赵阳升，于艳梅，等. 不同温度下褐煤裂隙演化的显微CT试验研究[J]. 岩石力学与工程学报，2010，29(12)：2 475-2 483. (MENG Qiaorong，ZHAO Yangsheng，YU Yanmei，et al. Micro-CT experimental study of crack evolution of lignite under different temperatures[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(12)：2 475-2 483.(in Chinese))
[25]	张国凯，李海波，夏祥，等. 单轴加载条件下花岗岩声发射及波传播特性研究[J]. 岩石力学与工程学报，2017，36(5)：1 133-1 144. (ZHANG Guokai，LI Haibo，XIA Xiang，et al. Experiment study on acoustic emission and wave propagation in granite under uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(5)：1 133-1 144.(in Chinese))
[28]	吴基文，樊成. 煤块抗拉强度的套筒致裂法实验室测定[J]. 煤田地质与勘探，2003，31(1)：19-21.(WU Jiwen，FAN Cheng. Laboratory test on tensile strength of coal piece by sleeve fracturing technique[J]. Coal Geology and Exploration，2003，31(1)：19-21.(in Chinese))