突出过程中煤–瓦斯两相流运移的物理模拟研究

doi:10.13722/j.cnki.jrme.2019.0136

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (543 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为了探讨煤与瓦斯突出过程中的煤–瓦斯两相流冲击破坏动力学行为，利用自主研发的多场耦合煤矿动力灾害大型物理模拟试验系统开展了突出过程中煤–瓦斯两相流运移规律物理模拟试验研究。结果表明：突出煤粉在高速气流作用下自工作面抛出，呈射流状，随着距离的增加，固相流扩散为栓塞流，沉降量随之增大，从而主要聚集在巷道末端；试验相对突出强度为10%，突出煤粉中绝大部分为粒径小于0.150 mm的煤粉，煤体破碎程度较高；突出启动后，高压气流携带大量煤粉从煤层中喷射而出，形成较强的冲击力，近突出口区域冲击力反复升降，表明突出过程具有阵发性；煤–瓦斯两相流运移过程中瓦斯完全膨胀形成冲击力陡增区，冲击力沿巷道呈波动式分布，距突出口4 944 mm处峰值冲击力最大，随后沿巷道呈震荡衰减变化趋势。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	许江
	程亮
	周斌
	彭守建
	杨孝波
	杨文建

关键词 ：岩石力学, 煤与瓦斯突出, 煤&ndash, 瓦斯两相流, 冲击力, 分选特性

Abstract：To investigate the impact feature and dynamic behavior of coal-gas two-phase flow in the process of coal and gas outburst，physical simulation test of coal-gas two-phase flow was carried out by multi-field coupling testing system for dynamic disasters in coal mine. The results show that the outburst pulverized coal is thrown from the working face in a jet shape due to the high-speed airflow. As the distance increases，the solid-phase diffuses and converts into the plug flow，and the deposition amount increases accordingly and concentrates at the end of the roadway. The relative intensity of the outburst is 10%，and pulverized coal with a diameter of less than 0.150 mm accounts for the main part of the outburst coal which indicates that the fragmentation degree of pulverized coal is high. While the outburst is triggered，a large amount of pulverized coal is ejected by the high-pressure airflow from the coal seam to create a large impact force. The impact force near the outburst orifice changes repeatedly，which indicates that the outburst process presents paroxysmal characteristics. In the motion process of two-phase flow，the gas expands completely to form a steeply increasing impact zone. The impact force reaches the largest at 4 944 mm from the outburst orifice and then attenuates along the roadway.

Key words： rock mechanics coal and gas outburst coal-gas two-phase flow impact force separation characteristic

引用本文:

许江，程亮，周斌，彭守建，杨孝波，杨文建. 突出过程中煤–瓦斯两相流运移的物理模拟研究[J]. 岩石力学与工程学报, 2019, 38(10): 1945-1953.
XU Jiang，CHENG Liang，ZHOU Bin，PENG Shoujian，YANG Xiaobo，YANG Wenjian. Physical simulation of coal-gas two-phase flow migration in coal and gas outburst process. , 2019, 38(10): 1945-1953.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2019.0136 或 http://www.rockmech.org/CN/Y2019/V38/I10/1945

[30]	耿加波. 煤与瓦斯突出灾变时空演化及其煤-瓦斯两相流运移特性物理模拟试验研究[博士学位论文][D]. 重庆：重庆大学，2018.(GENG Jiabo. Physical simulation on evolution of coal and gas outbursts and coal-gas two-phase flow transport characteristics[Ph. D. Thesis][D]. Chongqing：Chongqing University，2018.(in Chinese))
[1]	俞启香. 矿井瓦斯防治[M]. 徐州：中国矿业大学出版社，1992：66-67.(YU Qixiang. Mine gas prevention and control[M]. Xuzhou：Journal of China University of Mining and Technology，1992：66-67.(in Chinese))
[3]	程五一，刘晓宇，王魁军. 煤与瓦斯突出冲击波阵面传播规律的研究[J]. 煤炭学报，2004，29(1)：57-60.(CHENG Wuyi，LIU Xiaoyu，WANG Kuijun，et al. Study on regulation about shock-wave-front propagating for coal and gas outbursts[J]. Journal of China Coal Society，2004，29(1)：57-60.(in Chinese))
[5]	张建方，王凯，韦彩平. 煤与瓦斯突出冲击波的形成与传播规律研究[J]. 采矿与安全工程学报，2010，27(1)：71-75.(ZHANG Jianfang，WWANG Kai，WEI Caiping. Formation propagation of shock waves during coal and gas outbursts[J]. Journal of Mining and Safety Engineering，2010，27(1)：71-75.(in Chinese))
[7]	程卫民，王刚，张睿，等. 煤与瓦斯突出形成冲击波的灾变损害[J]. 科技导报，2008，26(24)：61-65.(CHENG Weiming，WANG Gang，ZHANG Rui，et al. Formation of coal and gas outburst blast wave[J]. Technology Review，2008，26(24)：61-65.(in Chinese))
[10]	魏建平，朱会启，温志辉. 煤与瓦斯突出冲击波传播规律实验研究[J]. 煤，2010，19(8)：11-13.(WEI Jianping，ZHU Qihui，WEN Zhihui. Coal and gas outburst shock wave propagation experiments[J]. Coal，2010，19(8)：11-13.(in Chinese))
[11]	王凯，周爱桃，张建方，等. 直角拐弯巷道中瓦斯突出冲击气流传播特征研究[J]. 中国矿业大学学报，2011，40(6)：858-862.(WANG Kai，ZHOU Aitao，ZHANG Jianfang，et al. Study of the shock wave propagation and gas flow during a coal and gas outburst at the roadway with a right-angled bend[J]. Journal of China University of Mining and Technology，2011，40(6)：858-862.(in Chinese))
[13]	王凯，周爱桃，魏高举，等. 巷道截面变化对突出冲击波传播的影响[J]. 煤炭学报，2012，37(6)：989-993.(WANG Kai，ZHOU Aitao，WEI Gaojun，et al. Influence of roadway cross-section variation on outburst shock wave propagation[J]. Journal of China Coal Society，2012，37(6)：989-993.(in Chinese))
[15]	孙东玲，曹偈，熊云威，等.突出过程中煤-瓦斯两相流运移规律的实验研究[J]. 矿业安全与环保，2017，44(2)：26-30.(SUN Dongling，CAO Jie，XIONG Yunwei，et al. Experimental study on the migration law of coal-gas two-phase flow in the process of outburst[J]. Mining Safety and Environmental Protection，2017，44(2)：26-30.(in Chinese))
[17]	曹偈，孙海涛，戴林超，等. 煤与瓦斯突出动力效应的模拟研究[J]. 中国矿业大学学报，2018，47(1)：113-121.(CAO Jie，SUN Haitao，DAI Linchao，et al. Simulation research on dynamic effect of coal and gas outburst[J]. Journal of China University of Mining and Technology，2018，47(1)：113-121.(in Chinese))
[20]	许江，张超林，彭守建，等. 多层叠置煤层气系统合采方式及其优化[J]. 煤炭学报，2018，43(6)：1 677-1 686.(XU Jiang，ZHANG Chaolin，PENG Shoujian，et al. Combined mining method and optimization of multi-layer coalbed methane system[J]. Journal of China Coal Society，2018，43(6)：1 677-1 686.(in Chinese))
[21]	刘东，许江，尹光志，等. 多场耦合煤矿动力灾害大型模拟试验系统研制与应用[J]. 岩石力学与工程学报，2013，32(5)：966-975.(LIU Dong，XU Jiang，YIN Guangzhi，et al. Development and application of multifield coupling testing system for dynamic disaster in coal mine[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(5)：966-975.(in Chinese))
[23]	金侃. 煤与瓦斯突出过程中高压粉煤-瓦斯两相流形成机制及致灾特征研究[博士学位论文][D]. 徐州：中国矿业大学，2017.(JIN Kan. Study on formation mechanism and disaster characteristics of high pressure pulverized coal-gas two-phase flow in coal and gas outburst[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，2017.(in Chinese))
[25]	蔡成功，熊亚选. 突出危险煤破碎功理论与实验研究[J]. 煤炭学报，2005，30(1)：63-66.(CAI Chenggong，XIONG Yaxuan. Theoretical and experimental study on crushing energy of outburst- proneness coal[J]. Journal of China Coal Society，2005，30(1)：63-66.(in Chinese))
[27]	熊阳涛，黄滚，罗甲渊，等. 煤与瓦斯突出能量耗散理论分析与试验研究[J]. 岩石力学与工程学报，2015，34(增2)：3 694-3 702. (XIONG Yangtao，HUANG Gun，LUO Jiayuan，et al. Theoretical analysis and experimental study of energy dissipation of coal and gas outburst[J]. Chinese Journal of Rock Mechanics and Engineering，2015，34(Supp.2)：3 694-3 702.(in Chinese))
[29]	王省身，谢之康. 矿井沼气爆炸安全距离的探讨[J]. 中国矿业大学学报，1989，18(4)：1-8.(WANG Xingshen，XIE Zhikang. Discussion on safety distance of mine biogas explosion[J]. Journal of China University of Mining and Technology，1989，18(4)：1-8.(in Chinese))
[2]	程远平. 煤矿瓦斯防治理论与工程应用[M]. 徐州：中国矿业大学出版社，2010：507-508.(CHENG Yuanping. Coal mine gas prevention theory and engineering application[M]. Xuzhou：Journal of China University of Mining and Technology，2010：507-508.(in Chinese))
[4]	杨书召，张瑞林. 煤与瓦斯突出冲击波及瓦斯气流所致伤害研究[J]. 中国安全科学学报，2012，22(11)：62-66.(YANG Shuzhao，ZHANG Ruilin. Research on injuries due to shock wave and gas flow from coal and gas outburst[J]. China Safety Science Journal，2012，22(11)：62-66.(in Chinese))
[6]	苗法田，胡千庭，孙东玲. 煤与瓦斯突出冲击波的形成机理[J]. 煤炭学报，2013，38(3)：367-372.(MIAO Fatian，HU Qianting，SUN Dongling. The formation mechanism of shock waves in the coal and gas outburst process[J]. Journal of China Coal Society，2013，38(3)：367-372.(in Chinese))
[8]	刘星魁，赵志梅. 直角拐角与障碍物对巷道瓦斯突出冲击波传播的影响[J]. 煤矿安全，2016，47(6)：178-181.(LIU Xingkui，ZHAO Zhimei. Influence of right angle corners and obstructions on gas shock propagation in roadway[J]. Safety in Coal Mines，2016，47(6)：178-181.(in Chinese))
[12]	王凯，周爱桃，魏高举，等. 直巷道中突出冲击气流的形成及传播特征研究[J]. 采矿与安全工程学报，2012，29(4)：559-563.(WANG Kai，ZHOU Aitao，WEI Gaojun，et al. Study of formation and propagation characteristics of shock wave and gas flow of outburst at straight roadway[J]. Journal of Mining and Safety Engineering，2012，29(4)：559-563.(in Chinese))
[14]	WANG K，ZHOU A T，ZHANG J F，et al. Real-time numerical simulations and experimental research for the propagation characteristics of shock waves and gas flow during coal and gas outburst[J]. Safety Science，2012，50(4)：835-841.
[16]	孙东玲，曹偈，苗法田，等. 突出煤-瓦斯在巷道内的运移规律[J]. 煤炭学报，2018，43(10)：2 773-2 779.(SUN Dongling，CAO Jie，MIAO Fatian，et al. Migration law of outburst coal and gas in roadway[J]. Journal of China Coal Society，2018，43(10)：2 773- 2 779.(in Chinese))
[18]	SUN H T，CAO J，LI M H. Experimental research on the impactive dynamic effect of gas-pulverized coal of coal and gas outburst[J]. Energies，2018，11(4)：1-15.
[22]	张淑同，王波，曹偈，等. 型煤吸附解吸二氧化碳与甲烷的性能对比试验研究[J]. 矿业安全与环保，2016，43(5)：5-8.(ZHANG Shutong，WANG Bo，CAO Jie，et al. Experimental study on performance of adsorption and desorption of carbon dioxide and methane by briquette[J]. Mining Safety and Environmental Protection，2016，43(5)：5-8.(in Chinese))
[24]	张超林. 深部采动应力影响下煤与瓦斯突出物理模拟试验研究[硕士学位论文][D]. 重庆：重庆大学，2015.(ZHANG Chaolin. Experimental study on physical simulation of coal and gas outburst under the influence of deep mining stress[M. S. Thesis][D]. Chongqing：Chongqing University，2015.(in Chinese))
[26]	罗甲渊. 煤与瓦斯突出的能量源及能量耗散机理研究[博士学位论文][D]. 重庆：重庆大学，2016.(LUO Jiayuan. Study on energy source and energy dissipation mechanism of coal and gas outburst[Ph. D. Thesis][D]. Chongqing：Chongqing University，2016.(in Chinese))
[9]	ZHOU A T，WANG K，WU Z Q. Propagation law of shock waves and gas flow in cross roadway caused by coal and gas outburst[J]. International Journal of Mining Science and Technology，2014，24(1)：23-29.
[19]	ZHOU A T，WANG K，FENG T F，et al. Effects of fast-desorbed gas on the propagation characteristics of outburst shock waves and gas flows in underground roadways[J]. Process Safety and Environmental Protection，2018，119(1)：295-303.
[28]	胡千庭，周世宁，周心权. 煤与瓦斯突出过程的力学作用机理[J]. 煤炭学报，2008，33(12)：1 368-1 372.(HU Qianting，ZHOU Shining，ZHOU Xinquan. Mechanical mechanism of coal and gas outburst[J]. Journal of China Coal Society，2008，33(12)：1 368- 1 372.(in Chinese))