盐岩变速率循环试验中的疲劳特性与声发射特征研究

doi:10.13722/j.cnki.jrme.2023.0612

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1493 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究压气蓄能型盐穴注采气速率变化对围岩疲劳力学特性和细观机制的影响，在声发射监测下对盐岩开展4组变循环速率疲劳试验(加、卸载速率一致)，试验中采用不同的上限应力和应力路径。分析循环内的残余应变、声发射累积振铃计数(后续简称AE计数)和峰频等与循环速率的相关性，结果表明：(1) 循环残余应变和循环累积AE计数均具有明显的率相关性(即与循环速率呈明显的幂函数型关系，如，形式)，应力等级和应力因子(幂函数的系数项m，m?)正相关，应力等级和蠕变塑性的率相关性(幂函数指数项b)正相关，循环累积AE计数的率相关性则相反(幂函数的指数项b^'减小)。率相关性参数(b，b?)均能不同程度提前于循环残余应变预示加速破坏阶段的来临。(2) 循环累积AE计数加速增长点在循环残余应变发展趋势的一、二阶段过渡点左右，该点在上限应力为19，23，27 MPa试验中大致对应2.382%，3.464%，4.297%的累积残余应变。(3) 每循环内低频信号占比随循环速率增大而减小，高频信号占比随速率减小而增大，中频信号占比仅随应力等级提升而增长。(4) 快、慢循环分别起到了硬化、软化作用，软化作用使后一循环中有更小起裂应力和更强塑性变形能力(硬化作用则反之)，这种机制与慢速循环中更多小尺度裂纹萌生扩展，以及慢速卸载过程中内应力的充分释放有关。研究成果对压气蓄能盐穴注采气频率调节方式和损伤演化分析有一定参考意义。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	杨镇宇1
	2
	陈结1
	2
	范金洋1
	2
	姜德义1
	2
	王同涛3
	杨春和3

关键词 ：岩石力学, 压气蓄能, 盐岩, 疲劳试验, 声发射

Abstract：In order to investigate the impact of variations in gas injection and extraction rates on the fatigue mechanical properties and fine-scale mechanism of the surrounding rock in compressed air energy storage salt caverns(CAES). Four groups of variable cyclic rate fatigue tests on salt rock were conducted using acoustic emission monitoring(loading and unloading rates are consistent)，with varying upper limit stress and stress routes. The correlations of residual strain，cyclic acoustic emission cumulative ring counts(AE counts) and peak frequency with cyclic rate were analyzed. The results showed that：(1) Cyclic residual strain and cumulative AE counts have an obvious rate correlation(obvious power law relationship with the cyclic rate，， )，and a positive correlation has been observed between stress level and stress factor(coefficient terms of power functions m，m'). The rate dependence of creep plasticity is positively correlated with stress level(power function exponential term b)，while the rate dependence of cyclic cumulative AE counts is opposite(power function exponential term b? decreases). The rate correlation parameters(b，b?) are all able to predict the onset of the accelerated damage stage differently in advance of the cyclic residual strain. (2) Accelerated rise of cyclic cumulative AE counts occurs at the transition point between phases I and II of the cyclic residual strain development trend. This corresponds to 2.382%，3.464% and 4.297% cumulative residual strains in tests of 19，23，27 MPa upper limit stress, respectively. (3) The proportion of low-frequency signals reduces with increasing cyclic rate，while high-frequency signals rise with lowering cyclic rate. Mid-frequency signals only increase with increasing stress level. (4) Fast and slow cycling operate as hardening and softening，respectively，with the softening effect resulting in lower fracture initiation stresses and stronger plastic deformability(and vice versa for hardening) in the latter cycle. This mechanism can be linked to increased small-scale crack sprouting and expansion during slow cycling，as well as the full release of internal stress during slow unloading. This work provides valuable insights into the control of gas injection and extraction frequency in CAES salt caverns，as well as the analysis of damage progression.

Key words： rock mechanics compressed air energy storage salt rock fatigue test acoustic emission

引用本文:

杨镇宇1，2，陈结1，2，范金洋1，2，姜德义1，2，王同涛3，杨春和3. 盐岩变速率循环试验中的疲劳特性与声发射特征研究[J]. 岩石力学与工程学报, 2024, 43(4): 951-963.
YANG Zhenyu1，2，CHEN Jie1，2，FAN Jinyang1，2，JIANG Deyi1，2，WANG Tongtao3，YANG Chunhe3. Experimental study on fatigue properties and acoustic emission characteristics of salt rock under variable cyclic rate effect#br#. , 2024, 43(4): 951-963.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2023.0612 或 http://rockmech.whrsm.ac.cn/CN/Y2024/V43/I4/951

[4]	杨春和，王同涛. 深地储能研究进展[J]. 岩石力学与工程学报，2022，41(9)：1 729-1 759.(YANG Chunhe，WANG Tongtao. Advance in deep underground energy storage[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(9)：1 729-1 759.(in Chinese))
[1]	FAN J，LIU W，JIANG D，et al. Time interval effect in triaxial discontinuous cyclic compression tests and simulations for the residual stress in rock salt[J]. Rock Mechanics and Rock Engineering，2020，53(9)：4 061-4 076.
[6]	李宗泽，姜德义，范金洋，等. 盐岩三轴间隔疲劳特性试验研究[J]. 岩土力学，2020，41(4)：1 305-1 312.(LI Zongze，JIANG Deyi，FAN Jinyang，et al. Experimental study of triaxial interval fatigue of salt rock[J]. Rock and Soil Mechanics，2020，41(4)：1 305-1 312.(in Chinese))
[7]	曾寅，刘建锋，周志威，等. 盐岩单轴蠕变声发射特征及损伤演化研究[J]. 岩土力学，2019，40(1)：207-215.(ZENG Yin，LIU Jianfeng，ZHOU Zhiwei，et al. Creep acoustic emission and damage evolution of salt rock under uniaxial compression[J]. Rock and Soil Mechanics，2019，40(1)：207-215.(in Chinese))
[11]	纪文栋，杨春和，姚院峰，等. 应变加载速率对盐岩力学性能的影响[J]. 岩石力学与工程学报，2011，30(12)：2 507-2 513.(JI Wendong，YANG Chunhe，YAO Yuanfeng，et al. Effects of loading strain rate on mechanical performances of salt rock[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(12)：2 507-2 513.(in Chinese))
[14]	HE M，LI N，ZHU C，et al. Experimental investigation and damage modeling of salt rock subjected to fatigue loading[J]. International Journal of Rock Mechanics and Mining Sciences，2019，114：17-23.
[9]	LIANG W G，ZHAO Y S，XU S G，et al. Effect of strain rate on the mechanical properties of salt rock[J]. International Journal of Rock Mechanics and Mining Sciences，2011，48(1)：161-167.
[17]	ALKAN H，CINAR Y，PUSCH G. Rock salt dilatancy boundary from combined acoustic emission and triaxial compression tests[J]. International Journal of Rock Mechanics and Mining Sciences，2007，44(1)：108-119.
[19]	姜德义，杨镇宇，范金洋，等. 盐岩循环加卸载过程中的速率效应试验研究[J]. 岩土力学，2023，44(2)：403-414.(JIANG Deyi，YANG Zhenyu，FAN Jinyang，et al. Experimental study of load rate effect of salt rock during loading and unloading[J]. Rock and Soil Mechanics，2023，44(2)：403-414.(in Chinese))
[21]	朱品竹. 不同加载速率下岩石力声学特性及损伤演化规律研究[硕士学位论文][D]. 赣州：江西理工大学，2020.(ZHUN Pinzhu. Study on acoustic properties and damage evolution of rock under different loading rates[M. S. Thesis][D]. Ganzhou：Jiangxi University of Science and Technology，2020.(in Chinese))
[24]	ZHAO K，MA H，YANG C，et al. The role of prior creep duration on the acoustic emission characteristics of rock salt under cyclic loading[J]. International Journal of Rock Mechanics and Mining Sciences，2022，157：105166.
[5]	姜德义，王雷，陈结，等. 损伤盐岩短期自恢复特性试验研究[J]. 岩土工程学报，2015，37(4)：594-600.(JIANG Deyi，WANG Lei，CHEN Jie，et al. Experimental research on properties of short-term selfrecovery of damaged salt rock[J]. Chinese Journal of Geotechnical Engineering，2015，37(4)：594-600.(in Chinese))
[15]	任松，白月明，姜德义，等. 周期荷载作用下盐岩声发射特征试验研究[J]. 岩土力学，2012，33(6)：1 613-1 619.(REN Song，BAI Yueming，JINAG Deyi，et al. Experimental research on acoustic emission property of salt rock under cyclic loading[J]. Rock and Soil Mechanics，2012，33(6)：1 613-1 619.(in Chinese))
[25]	HSIEH A，DIGHT P，DYSKIN A V. The rock stress memory unrecoverable by the Kaiser effect method[J]. International Journal of Rock Mechanics and Mining Sciences，2015，75：190-195.
[27]	刘建新. 岩石破裂声发射实验研究[硕士学位论文][D]. 北京：中国地震局地球物理研究所，2002.(LIU Jianxin. Experimental study of AE in rocks[M. S. Thesis][D]. Beijing：Institute of Geophysics，China Earthquake Administration，2002.(in Chinese))
[29]	ZHANG S，XUAN F，GUO S，et al. The role of anelastic recovery in the creep-fatigue interaction of 9%-12% Cr steel at high temperature[J]. International Journal of Mechanical Sciences，2017，122：95-103.
[8]	姜德义，陈结，任松，等. 盐岩单轴应变率效应与声发射特征试验研究[J]. 岩石力学与工程学报，2012，31(2)：326-336.(JIANG Deyi，CHEN Jie，REN Song，et al. Experimental study of strain rate effect and acoustic emission characteristics of salt rock under uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(2)：326-336.(in Chinese))
[18]	LI Z，SUO J，FAN J，et al. Damage evolution of rock salt under multilevel amplitude creep-fatigue loading with acoustic emission monitoring[J]. International Journal of Rock Mechanics and Mining Sciences，2023，164：105346.
[28]	FAN J，JIANG D，LIU W，et al. Discontinuous fatigue of salt rock with low-stress intervals[J]. International Journal of Rock Mechanics and Mining Sciences，2019，115：77-86.
[3]	谢凌志，周宏伟，谢和平. 盐岩CO2处置相关研究进展[J]. 岩土力学，2009，30(11)：3 324-3 330.(XIE Lingzhi，ZHOU Hongwei，XIE Heping. Research advance of CO2 storage in rock salt caverns[J]. Rock and Soil Mechanics，2009，30(11)：3 324-3 330.(in Chinese))
[13]	FUENKAJORN K，PHUEAKPHUM D. Effects of cyclic loading on mechanical properties of Maha Sarakham salt[J]. Engineering Geology，2010，112(1/4)：43-52.
[23]	虢成功，李杰. 考虑应变率效应的混凝土随机损伤本构模型研究[J]. 力学学报，2022，54(12)：3 456-3 467.(GUO Chengong，LI Jie. New stochastic damage constitutive model of concrete considering strain rate effect[J]，Chinese Journal of Theoretical and Applied Mechanics，2022，54(12)：3 456-3 467.(in Chinese))
[2]	LI Z，YANG Z，FAN J，et al. Fatigue mechanical properties of salt rocks under high stress plateaus：the interaction between creep and fatigue[J]. Rock Mechanics and Rock Engineering，2022，55(11)：6 627-6 642.
[12]	HAN Y，MA H，YANG C，et al. The mechanical behavior of rock salt under different confining pressure unloading rates during compressed air energy storage(CAES)[J]. Journal of Petroleum Science and Engineering，2021，196：107676.
[22]	MENG Q，CHEN Y，ZHANG M，et al. On the Kaiser effect of rock under cyclic loading and unloading conditions：insights from acoustic emission monitoring[J]. Energies，2019，12(17)：3 255.
[10]	梁卫国，徐素国，莫江，等. 盐岩力学特性应变率效应的试验研究[J]. 岩石力学与工程学报，2010，29(1)：43-50.(LIANG Weiguo，XU Suguo，MO Jiang，et al. Test study of strain rate effects on mechanical performances of salt rock[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(1)：43-50.(in Chinese))
[20]	崔遥，姜德义，杜逢彬，等. 盐岩间隔疲劳的声发射特性试验研究[J]. 中南大学学报：自然科学版，2017，48(7)：1 875-1 882.(CUI Yao，JIANG Deyi，DU Pengbing，et al. Experimental study on character of acoustic emission caused by interval fatigue of salt rock[J]. Journal of Central South University：Science and Technology，2017，48(7)：1 875-1 882.(in Chinese))
[16]	陈宇龙，张玉. 加载速率对不同岩性岩石Kaiser效应影响[J]. 煤炭学报，2018，43(4)：959-966.(CHEN Yulong，ZHANG Yu. Influence of loading rate on the Kaiser effect for different lithological rocks[J]. Journal of China Coal Society，2018，43(4)：959-966.(in Chinese))
[26]	陈致君，尧军平，胡启耀. 拉伸速率对含缺陷单晶镁塑性变形机制的影响[J]. 塑性工程学报，2022，29(11)：138-144.(CHEN Zhijun，YAO Junping，HU Qiyao. Effect of tensile rate on plastic deformation mechanism of single crystal magnesium containing defects[J]. Journal of Plasticity Engineering，2022，29(11)：138-144.(in Chinese))