盾构隧道施工阶段管片上浮的力学分析

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (385 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要盾构隧道衬砌管片在施工阶段处于复杂的受力状态，易出现管片错台、整体上浮等现象。对盾构隧道施工阶段管片注浆段进行受力分析，考虑静态上浮力和动态上浮力，分别分析其作用机制，提出上浮阶段的衬砌环受力模型及计算公式。针对盾构隧道衬砌环在正常设计状态与上浮状态下的受力不同，采用修正惯用法衬砌设计理论分别对其进行内力计算，并将计算结果进行对比分析。结果表明：上浮状态下管片的弯矩值、剪力值和轴力值分别比正常设计状态下的管片内力增加64%，51%和46%，表明隧道上浮对管片受力不利。其中施工阶段动态上浮力对管片的受力影响非常大，超过静态上浮力，必须对其进行合理控制，防止压裂管片。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：隧道工程, 盾构, 施工, 管片, 上浮

Abstract：The lining segment is in a complex stress state during shield tunnel construction，which is prone to go dislocation and have wholly rising displacement. Based on the analysis of segment in grouting section and considering static buoyancy and dynamic buoyancy，the buoyancy is respectively analyzed during shield tunnel construction. The mechanical model for segment ring in floating phase and calculation formula are presented，respectively. Aiming at the difference of segment ring between normal design state and floating state，the modified routine method is carried out to calculate lining internal force to draw a comparison. The results show that，comparing with segment ring in the normal design state，the bending moment，shear force and axial force values of segment increase by 60%，51% and 46% in floating state，which indicates that segment floating is adverse to its safety. The stress of segment is affected by dynamic buoyancy greatly during construction stage，which is larger than static buoyancy and must controlled reasonably for preventing the segment fracture.

Key words： tunneling engineering shield construction segment floating

收稿日期: 2012-02-17

引用本文:

魏纲1，洪杰2，魏新江1，2. 盾构隧道施工阶段管片上浮的力学分析[J]. 岩石力学与工程学报, 2012, 31(6): 1257-1263.
WEI Gang1，HONG Jie2，WEI Xinjiang1，2. MECHANICAL ANALYSIS OF SEGMENT FLOATING DURING SHIELD TUNNEL CONSTRUCTION. , 2012, 31(6): 1257-1263.

链接本文:

http://www.rockmech.org/CN/Y2012/V31/I6/1257

[2]	沈征难. 盾构掘进过程中隧道管片上浮原因分析及控制[J]. 现代隧道技术，2004，41(6)：51-56.(SHEN Zhengnan. Analysis and control of segment floating during shield tunnel construction[J]. Modern Tunnelling Technology，2004，41(6)：51-56.(in Chinese))
[3]	李云丽. 盾构隧道施工过程管片结构受力特征研究[硕士学位论文][D]. 北京：北京交通大学，2008.(LI Yunli. Research on structural mechanics characteristics of segment in the process of shield tunnel construction[M. S. Thesis][D]. Beijing：Beijing Jiaotong University，2008.(in Chinese)) " target="_blank">
[8]	宋克志，袁大军，王梦恕. 盾构法隧道施工阶段管片的力学分析[J]. 岩土力学，2008，29(3)：619-623.(SONG Kezhi，YUAN Dajun，WANG Mengshu. Segmental mechanical analysis of shield tunnel during construction stage[J]. Rock and Soil Mechanics，2008，29(3)：619-623.(in Chinese))
[13]	叶飞，朱合华，丁文其，等. 施工期盾构隧道上浮机制与控制对策分析[J]. 同济大学学报：自然科学版，2008，36(6)：738-743.(YE Fei，ZHU Hehua，DING Wenqi，et al. Analysis and control of upward moving of shield tunnel under construction[J]. Journal of Tongji University：Natural Science，2008，36(6)：738-743.(in Chinese)) " target="_blank">
[16]	阮文军. 注浆扩散与浆液若干基本性能研究[J]. 岩土工程学报，2005，27(1)：69-73.(RUAN Wenjun. Research on diffusion of grouting and basic properties of grouts[J]. Chinese Journal of Geotechnical Engineering，2005，27(1)：69-73.(in Chinese))
[6]	官林星，朱合华，于宁. 考虑荷载工况组合的盾构衬砌横向受力分析[J]. 岩土力学，2004，25(8)：1 302-1 306.(GUAN Linxing，ZHU Hehua，YU Ning. Analysis of internal force of shield lining in cross-section considering load combination[J]. Rock and Soil Mechanics，2004，25(8)：1 302-1 306.(in Chinese))
[9]	肖明清，孙文昊，韩向阳. 盾构隧道管片上浮问题研究[J]. 岩土力学，2009，30(4)：1 041-1 045.(XIAO Mingqing，SUN Wenhao，HAN Xiangyang. Research on upward moving of segments of shield tunnel[J]. Rock and Soil Mechanics，2009，30(4)：1 041-1 045.(in Chinese)) " target="_blank">
[12]	叶飞，何川，王士民. 盾构隧道施工期衬砌管片受力特性及其影响分析[J]. 岩土力学，2011，32(6)：1 801-1 807.(YE Fei，HE Chuan，WANG Shimin. Analysis of mechanical characteristic of shield tunnel segments lining and its influence during construction[J]. Rock and Soil Mechanics，2011，32(6)：1 801-1 807.(in Chinese))
[20]	赵文，王钊宇，李建强. 盾构隧道施工中上浮管片的受力分布研究[C]// 第八届海峡两岸隧道与地下工程学技术研讨会. 台北：[s.n.]，2009：1-6.(ZHAO Wen，WANG Zhaoyu，LI Jianqiang. Force distribution of the floating segment in shield tunnel construction[C]// Proceedings of the 8th Cross-strait Tunnel and Underground Engineering Technology Seminar. Taipei：[s.n.]，2009：1-6.(in Chinese)) " target="_blank">
[1]	叶飞. 软土盾构隧道施工期上浮机制分析及控制研究[博士学位论文][D]. 上海：同济大学，2007.(YE Fei. Analysis and control for upward movement of soft soil shield tunnel during construction[Ph. D. Thesis][D]. Shanghai：Tongji University，2007.(in Chinese)) " target="_blank">
[4]	赵永明，杜守继，张强. 盾构隧道通缝拼装管片上浮的监测研究[J]. 地下空间与工程学报，2007，3(增 1)：1 354-1 357.(ZHAO Yongming，DU Shouji，ZHANG Qiang. Monitoring research on rising displacement for shield tunnel segment with straight joint[J]. Chinese Journal of Underground Space and Engineering，2007，3(Supp.1)：1 354-1 357.(in Chinese))
[7]	陈俊生，莫海鸿，梁仲元. 盾构隧道施工阶段管片局部开裂原因初探[J]. 岩石力学与工程学报，2006，25(5)：906-910.(CHEN Junsheng，MO Haihong，LIANG Zhongyuan. Study of local cracking of segments in shield tunnel during construction[J]. Chinese Journal of Rock Mechanics and Engineering，2006，25(5)：906-910.(in Chinese))
[10]	唐孟雄，陈如桂，陈伟. 广州地铁盾构隧道施工中管片受力监测与分析[J]. 土木工程学报，2009，42(3)：118-124.(TANG Mengxiong，Chen Rugui，CHEN Wei. Stress monitoring and internal force analysis of Guangzhou metro shield tunnel segment during construction[J]. China Civil Engineering Journal，2009，42(3)：118-124.(in Chinese))
[5]	张海波，殷宗泽，朱俊高，等. 盾构法隧道衬砌施工阶段受力特性的三维有限元模拟[J]. 岩土力学，2005，26(6)：990-994.(ZHANG Haibo，YIN Zongze，ZHU Jungao，et al. Three-dimensional FEM simulation of shield-driven tunnel lining during construction stage[J]. Rock and Soil Mechanics，2005，26(6)：990-994.(in Chinese))
[11]	叶飞，朱合华，丁文其. 基于弹性地基梁的盾构隧道纵向上浮分析[J]. 中国铁道科学，2008，29(4)：65-69.(YE Fei，ZHU Hehua，DING Wenqi. Longitudinal upward movement analysis of shield tunnel based on elastic foundation beam[J]. China Railway Science，2008，29(4)：65-69.(in Chinese))
[14]	叶飞，朱合华，何川. 盾构隧道壁后注浆扩散模式及对管片的压力分析[J]. 岩土力学，2009，30(5)：1 307-1 312.(YE Fei，ZHU Hehua，HE Chuan. Back-filled grouts diffusion model and its pressure to segments of shield tunnel[J]. Rock and Soil Mechanics，2009，30(5)：1 307-1 312.(in Chinese))
[15]	岩土注浆理论与工程实例协作组. 岩土注浆理论与工程实例[M]. 北京：科学出版社，2001：54-55.(Collaborative Group of Geotechnical Grouting Projects. Theory and projects of geotechnical grouting[M]. Beijing：Science Press，2001：54-55.(in Chinese)) " target="_blank">
[18]	Working Group No.2，International Tunneling Association. Guidelines for the design of shield tunnel lining[J]. Tunneling and Underground Space Technology，2000，15(3)：303-331. " target="_blank">
[17]	张凤祥，朱合华，傅德明. 盾构隧道[M]. 北京：人民交通出版社，2004：331-334.(ZHANG Fengxiang，ZHU Hehua，FU Deming. Shield tunnel[M]. Beijing：China Communications Press，2004：331-334.(in Chinese)) " target="_blank">
[19]	胡志平，罗丽娟，蔡志勇. 盾构隧道管片衬砌荷载模式比较分析[J]. 岩土工程技术，2004，18(1)：19-22.(HU Zhiping，LUO Lijuan，CAI Zhiyong. Analysis of the different load models in the lining segments of shield tunnel[J]. Geotechnical Engineering Technique，2004，18(1)：19-22.(in Chinese))