碱激发矿粉固化连云港软土试验研究

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (5769 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为了减轻使用波特兰水泥作为软土固化剂存在的高能耗、CO2排放和不可再生资源消耗等环境问题，通过室内配合比试验初步研究碱激发矿粉对连云港软土的固化效果，并与水泥固化进行对比。结果表明：Na2CO3对矿粉固化土的激发效果非常有限；NaOH激发矿粉的效果最好，7 d，28 d，90 d无侧限抗压强度最高，但是在90 d后会发生一定的强度衰减；矿粉+电石渣固化土的7 d，28 d强度比水泥固化土低，而90 d，180 d强度比水泥固化土高。Na2CO3，NaOH和Na2SO4能够加速矿粉+电石渣固化土的强度增长速率，其中，Na2CO3的效果最弱，虽然可以在90 d内提高矿粉+电石渣固化土的强度，但180 d强度反而略低；NaOH激发的矿粉+电石渣固化土强度在7 d，28 d，90 d龄期均有较大的提高，但从90 d到180 d会发生强度衰减；Na2SO4激发矿粉+电石渣的效果最好，可以在实际工程中进行应用，不仅可以减小水泥生产过程带来的环境影响，还能提高软土固化效果，降低工程造价。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：土力学, 软土, 固化, 矿粉, 碱激发, 无侧限抗压强度

Abstract：In order to mitigate the environmental impacts in terms of high energy consumption，CO2 emissions and no-renewable resources consumption associated with Portland cement(PC) soft soil stabilization，the stabilization effect of alkali-activated ground granulated blast-furnace slag(GGBS) for Lianyugang soft soil was investigated through laboratory test and then it was compared with that of PC. The results show that the Na2CO3-activated GGBS had the minimum stabilization efficacy for this soft soil. NaOH-activated GGBS stabilized soil had the highest unconfined compressive strength(UCS) at 7，28 and 90 days，however its UCS decreased after 90 days. The GGBS-carbide slag stabilized soil had lower 7-day and 28-day UCS than that of PC mix，whilst the former had much higher 90-day and 180-day UCS than the latter. The Na2CO3，NaOH and Na2SO4 could accelerate the strength development rate of GGBS-carbide slag stabilized soil. The Na2CO3-activated GGBS-carbide slag stabilized soil had only slightly higher 7-day，28-day，90-day UCS and lower 180-day UCS than those without Na2CO3. NaOH significantly increased the UCS of GGBS-carbide slag stabilized soil at 7，28 and 90 days. However the UCS decrease was observed from 90 days to 180 days. The Na2SO4 had the highest activating efficacy for GGBS-carbide slag stabilized soil，and thus was suggested to use in practice due to both the economical and environmental benefits.

Key words： soil mechanics soft soil stabilization ground granulated blast-furnace slay(GGBS) alkali- activation unconfined compressive strength

收稿日期: 2013-05-02

引用本文:

易耀林，李晨，孙川，张正甫，刘松玉. 碱激发矿粉固化连云港软土试验研究[J]. 岩石力学与工程学报, 2013, 32(9): 1820-1826.
YI Yaolin，LI Chen，SUN Chuan，ZHANG Zhengfu，LIU Songyu. TEST ON ALKALI-ACTIVATED GROUND GRANULATED BLAST-FURNACE SLAG(GGBS) FOR LIANYUNGANG SOFT SOIL STABILIZATION. , 2013, 32(9): 1820-1826.

链接本文:

http://www.rockmech.org/CN/Y2013/V32/I9/1820

[13]	HUANG X，LI Z G，NING J G，et al. Principle and method of optimization design for soft soil stabilizer[J]. Journal of Wuhan University of Technology：Material Science，2009，24(1)：154-160.
[18]	SONG S，SOHN D，JENNINGS H M，et al. Hydration of alkali-activated ground granulated blast-furnace slag[J]. Journal of Materials Science，2000，35(1)：249-257.
[2]	刘松玉，钱国超，章定文. 粉喷桩复合地基理论与工程应用[M]. 北京：中国建筑工业出版社，2006：1-3.(LIU Songyu，QIAN Guochao，ZHANG Dingwen. The principle and application of dry jet mixing composite foundation[M]. Beijing：China Architecture and Building Press，2006：1-3.(in Chinese)) " target="_blank">
[6]	HIGGINS D D. GGBS and sustainability[J]. Construction Materials，2007，160(3)：99-101. " target="_blank">
[10]	YI Y L，LISKA M，AL-TABBAA A. Initial investigation into the use of GGBS-MgO in soil stabilization[C]// Proceedings of the 4th International Conference on Grouting and Deep Mixing. [S.l.]：ASCE Geotechnical Special Publication，2012：444-453. " target="_blank">
[15]	SHI C J，KRIVENKO P V，ROY D. Alkali-activated cements and concretes[M]. New York：Taylor and Francis，2006：6-125. " target="_blank">
[16]	董永刚，曹建新，刘飞，等. 电石渣理化性质的分析与表征[J]. 环境科学与技术，2008，31(9)：95-98.(DONG Yonggang，CAO Jianxin，LIU Fei，et al. Analysis and characterization of physiochemical property of carbide slag[J]. Environmental Science and Technology，2008，31(9)：95-98.(in Chinese)) " target="_blank">
[20]	RICHARDSON J M，BIERNACKI J，STUTZMAN P E，et al. Stoichiometry of slag hydration with calcium hydroxide[J]. Journal of the American Ceramic Society，2002，85(4)：947-953. " target="_blank">
[3]	TERASHI M. The state of practice in deep mixing methods[C]// The 3rd International Specialty Conference on Grouting and Ground Treatment. [S.l.]：ASCE Geotechnical Special Publish，2003：25-49. " target="_blank">
[7]	JAMES R，KAMRUZZAMAN A H M，HAQUEAND A，et al. Behaviour of lime-slag-treated clay[J]. Ground Improvement，2008，161(4)：207-21. " target="_blank">
[11]	庄心善，王功勋，田苾. 含工业废料加固土的特性研究[J]. 土木工程学报，2005，38(8)：114-117.(ZHUANG Xinshan，WANG Gongxun，TIAN Bi. A study on the characteristics of soils consolidated with industrial wastes[J]. China Civil Engineering Journal，2005，38(8)：114-117.(in Chinese)) " target="_blank">
[1]	章定文，刘松玉，于新豹. 连云港海相软土特性研究[J]. 华中科技大学学报：城市科学版，2003，20(4)：71-74.(ZHANG Dingwen，LIU Songyu，YU Xinbao. Study on engineering characteristics of marine clay in Lianyungang[J]. Journal of Huazhong University of Science and Technology：Urban Science，2003，20(4)：71-74.(in Chinese))
[4]	HOLM G. State of practice in dry deep mixing methods[C]// The 3rd International Specialty Conference on Grouting and Ground Treatment. [S.l.]：ASCE Geotechnical Special Publish，2003：145-163. " target="_blank">
[5]	CHEW S H，KAMRUZZAMAN A H M，LEE F H. Physicochemical and engineering behavior of cement treated clays[J]. Journal of Geotechnical and Geoenvironmental Engineering，2004，130(7)：696-706. " target="_blank">
[8]	JEGANDAN S，LISKA M，OSMAN A A-M，et al. Sustainable binders for soil stabilization[J]. Ground Improvement，2010，163(1)：53-61. " target="_blank">
[9]	NIDZAM R M，KINUTHIA J M. Sustainable soil stabilization with blastfurnace slag-a review[J]. Construction Materials，2010，163(3)：157-165. " target="_blank">
[12]	方祥位，孙树国，陈正汉，等. GT 型土壤固化剂改良土的工程特性研究[J]. 岩土力学，2006，27(9)：1 545-1 548.(FANG Xiangwei，SUN Shuguo，CHEN Zhenghan，et al. Study on engineering properties of improved soil by GT soil firming agent[J]. Rock and Soil Mechanics，2006，27(9)：1 545-1 548.(in Chinese)) " target="_blank">
[14]	ROY D M. Alkali-activated cements：opportunities and challenges[J]. Cement and Concrete Research，1999，29(2)：249-254. " target="_blank">
[17]	顾力扬，易耀林，郭鹏飞，等. 矿粉-熟石灰固化连云港软土试验研究[C]// 第十二届全国地基处理学术讨论会论文集. 昆明：云南人民出版社，2012：217-221.(GU Liyang，YI Yaolin，GUO Pengfei，et al. Laboratory tests on GGBS-hydrated lime for Lianyugang soft soil stabilization[C]// Proceedings of the 12th National Academic Conference on Ground Improvement. Kunming：Yunnan People?s Press，2012：217-221.(in Chinese)) " target="_blank">
[19]	CHEN W. Hydration of slag cement：theory，modeling and application[Ph. D. Thesis][D]. Netherlands：University of Twente，2006. " target="_blank">
[21]	YANG K，CHO A R，SONG J K，et al. Hydration products and strength development of calcium hydroxide-based alkali-activated slag mortars[J]. Construction and Building Materials，2012，29：410-419. " target="_blank">
[22]	彭家惠，楼宗汉. 钙矾石形成机制的研究[J]. 硅酸盐学报，2000，28(6)：511-515.(PENG Jiahui，LOU Zonghan. Study on the mechanism of ettringite formation[J]. Journal of the Chinese Ceramic Society，2000，28(6)：511-515.(in Chinese)) " target="_blank">
[23]	SHI C J. Strength，pore structure and permeability of alkali-activated slag mortars[J]. Cement and Concrete Research，1996，26(12)：1 789-1 799. " target="_blank">