发泡球粒粒径对混合轻量砂强度影响试验研究

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (0 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为确定发泡球粒粒径对混合轻量砂的强度影响规律，采用三轴固结不排水试验系统研究发泡颗粒混合轻量砂在不同配比下(2～6 mm范围内4种不同发泡颗粒平均粒径，水泥掺入比13%和20%，发泡颗粒体积比为1.8)的强度特性。试验结果表明：发泡颗粒混合轻量砂是一种结构性土体，其应力–应变关系曲线具非线性、多阶段性、应变硬化和应变软化特性。Mohr破坏包络线有折线形和直线形2种表现形式，取决于自身结构强度和所选取的固结压力。变形模量和抗压强度具有可调节性，随水泥掺入比增大而增大。配比一定时，随发泡颗粒粒径增大，变形模量线性减小，抗压强度呈指数递减。黏聚力和内摩擦角均随着发泡颗粒粒径的增大而呈递减的趋势，但内摩擦角减小的幅度较小。水泥含量对黏聚力影响较大，对内摩擦角影响不明显。发泡颗粒粒径在2～5 mm范围内增大时，单价降低率远远大于强度衰减率，继续增大优势不明显，粒径为5～6 mm时，制样难度大大增加。综合考虑，推荐采用4～5 mm粒径的发泡颗粒进行工程设计。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：土力学, 轻量砂, 发泡颗粒, 粒径, 抗压强度, 变形模量, 三轴试验

Abstract：A series of triaxial tests were carried out to investigate the influence law of expanded polystyrene size(EPS) on strength characteristics of light-weight sand(4 kinds of EPS sizes in range of 2–6 mm)，cement mass ratio is 13% and 20%，EPS volume ratio is 1.8). Results show that the light-weight sand is a kind of structural soil，nonlinearity，multi-stage，strain hardening and strain softening are the properties of its stress-strain relation curves. Broken line and straight line are the two different types of Mohr failure envelope，which depends on the structural strength and consolidation pressure. Deformation modulus and compressive strength are adjustable，both growing with the increase of cement mixed ratio. For a certain mixed ratio，with the increase of EPS size，deformation modulus decreases linearly and compressive strength decreases exponentially. Cohesive strength and internal frictional angle decrease with the increase of EPS size，but the reduction of internal frictional angle is smaller. The cement mixed ratio has a big influence on the cohesive strength and little influence on the internal frictional angle. The reduction rate of unit price is far more greater than that of strength，with the increase of EPS size from 2 to 5 mm，but the advantage is not obvious when the EPS size continues to grow. The difficulty of sample preparation is highly increased when the EPS particle sizes are 5–6 mm. Take all factors into consideration，4–5 mm particle sizes of EPS are recommended in practical engineering.

Key words： soil mechanics light-weight sand expanded polystyrene size(EPS) particle size compressive strength deformation modulus triaxial test

收稿日期: 2012-06-18

引用本文:

谢书萌1，2，徐光黎2，叶三霞3，胡焕忠2. 发泡球粒粒径对混合轻量砂强度影响试验研究[J]. 岩石力学与工程学报, 2013, 32(s2): 3056-3063.
XIE Shumeng1，2，XU Guangli2，YE Sanxia3，HU Huanzhong2. TEST FOR INFLUENCE LAW OF EXPANDED POLYSTYRENE(EPS) PARTICLE SIZE ON STRENGTH CHARACTERISTICS OF MIXED LIGHT-WEIGHT SAND. , 2013, 32(s2): 3056-3063.

链接本文:

https://rockmech.whrsm.ac.cn/CN/Y2013/V32/Is2/3056

[1]	姬凤玲. 淤泥泡沫塑料颗粒轻质混合土力学特性研究[博士学位论文][D]. 南京：河海大学，2005.(JI Fengling. Study on mechanical properties of lightweight bead-treated soil made from silt[Ph. D. Thesis][D]. Nanjing： Hohai University，2005.(in Chinese)) " target="_blank">
[2]	叶三霞. 黏土与EPS颗粒轻质混合土的变形与强度试验研究[硕士学位论文][D]. 武汉：中国地质大学，2010.(YE Sanxia. Experimental study on the deformation strength properties of lightweight clay-EPS beads soil[M. S. Thesis][D]. Wuhan：China University of Geosciences，2010.(in Chinese)) " target="_blank">
[3]	徐光黎，小玉荣二，坂手道明. 发泡颗粒混合轻量土及其原位力学性质[J]. 水文地质工程地质，2004，(增1)：18-23.(XU Guangli，KODAMA E，SAKATE M. New application and its in-situ properties of foamed particle light soil[J]. Hydrogeology and Engineering Geology，2004，(Supp.1)：18-23.(in Chinese)) " target="_blank">
[4]	徐光黎，杨银湖. 轻量土及其在工程中的应用[J]. 地质科技情报. 2005，(4)：94-98.(XU Guangli，YANG Yinhu. Light-weight soils and their applications[J]. Geological Science and Technology Information， 2005，(4)：94-98.(in Chinese)) " target="_blank">
[5]	MURTY V R，PRAVEEN G V. Use of chemically stabilized soil as cushion material below light weight structures founded on expansive soils[J]. Journal of Materials in Civil Engineering，2008，20(5)：392-400.(in Chinese)) " target="_blank">
[6]	长坂勇二，山田纯男フラダン-テ-ジ. 発泡ビ-ズと建設発生土を用いた軽量混合土[J]. 土と基礎，1994，42(10)：25-30.(NAGASAKA Y，YAMADA S. Foamed particle light-weight soil with foamed beads[J]. Soil and Foundations，1994，42(10)：25-30.(in Japanse)) " target="_blank">
[7]	汤峻，朱伟，李明东，等. 砂土EPS颗粒混合轻质土的物理力学特性[J]. 岩土力学，2007，28(5)：1 045-1 049.(TANG Jun，ZHU Wei，LI Mingdong，et al. Physico-mechanical properties of sand EPS beads-mixed lightweight soil[J]. Rock and Soil Mechanics，2007，28(5)：1 045-1 049.(in Chinese)) " target="_blank">
[8]	侯天顺，徐光黎，楼建东. 轻量砂抗剪强度特性三轴试验研究[J]. 中南大学学报：自然科学版，2011，42(11)：3 521-3 529.(HOU Tianshun，XU Guangli，LOU Jiandong. Triaxial compression test on shear strength characteristics of light weight sand[J]. Journal of Central South University：Science and Technology，2011，42(11)：3 521-3 529.(in Chinese)) " target="_blank">
[9]	侯天顺，徐光黎，楼建东. 轻量砂变形及强度特性三轴试验研究[J]. 岩土力学，2011，32(10)：2 989-2 997.(HOU Tianshun，XU Guangli，LOU Jiandong. Triaxial test for deformation and strength characteristics of light weight sand[J]. Rock and Soil Mechanics，2011，32(10)：2 989-2 997. " target="_blank">
[10]	魏艳蕾，王静，龚建波，等. 建筑用砂轻量土的物理力学性质试验研究[J]. 地下空间与工程学报，2010，6(6)：1 152-1 160.(WEI Yanlei，WANG Jing，GONG Jianbo，et al. Study on physico-mechanical properties of light-weight soil[J]. Chinese Journal of Underground Space and Engineering，2010，6(6)：1 152-1 160.(in Chinese)) " target="_blank">
[11]	侯天顺，徐光黎. EPS粒径对轻量土抗剪强度的影响规律[J]. 岩土工程学报，2011，33(10)：1 634-1 641.(HOU Tianshun，XU Guangli. Influence law of EPS size on shear strength of light weight soil[J]. Chinese Journal of Geotechnical Engineering，2011，33(10)：1 634-1 641.(in Chinese)) " target="_blank">
[12]	中华人民共和国国家标准编写组. GB/T50123—1999土工试验方法标准[S]. 北京：中国计划出版社，1999.(The National Standards Compilation Group of People?s Republic of China. GBT50123—1999 Standard for soil test method[S]. Beijing：China Planning Press， 1999.(in Chinese)) " target="_blank">
[13]	龚晓南，熊传祥，项可祥，等. 黏土结构性对其力学性质的影响及形成原因分析[J]. 水利学报，2000，(10)：43-47.(GONG Xiaonan， XIONG Chuanxiang，XIANG Kexiang，et al. The formation of clay structure and its influence on mechanical characteristics of clay[J]. Journal of Hydraulic Engineering，2000，(10)：43-47.(in Chinese)) " target="_blank">
[14]	沈珠江. 软土工程特性和软土地基设计[J]. 岩土工程学报，1998，20(1)：100-111.(SHEN Zhujiang. Engineering properties of soft soils and design of soft ground[J]. Chinese Journal of Geotechnical Engineering， 1998，20(1)：100-111.(in Chinese))
[15]	马殿光. 淤泥再生废弃泡沫塑料轻质混合土试验研究[硕士学位论文][D]. 南京：河海大学，2005.(MA Dianguang. Experimental study on the stabilized light soil(SLS) made of sludge and waste expanded polystyrene[M. S. Thesis][D]. Nanjing：Hohai University，2005.(in Chinese)) " target="_blank">
[16]	童瑞铭. EPS颗粒混合轻质土(LSES)与砂土的动力特性对比试验研究[硕士学位论文][D]. 南京：河海大学，2007.(TONG Ruiming. Comparative experiment research on dynamic behaviors of lightweight sand-EPS beads soil with sand[M. S. Thesis][D]. Nanjing：Hohai University，2007.(in Chinese)) " target="_blank">
[17]	俞峰. 低围压下砂土与EPS颗粒混合轻质土的动力变形特性研究[硕士学位论文][D]. 南京：河海大学，2006.(YU Feng. Study on the dynamic deformation characteristics of lightweight sand-EPS beads soil under low confine pressure[M. S. Thesis][D]. Nanjing：Hohai University，2006.(in Chinese)) " target="_blank">