定向聚能爆破弱化综掘工作面逆断层应用研究

doi:10.13722/j.cnki.jrme.2018.1447

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (721 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要针对综掘工作面过逆断层采用普通爆破预先弱化硬岩时巷道围岩和构造区域煤岩体的稳定性问题，通过理论分析和对比模拟实验研究爆破扰动逆断层构造带的突出原因，提出改变装药结构，采用定向聚能爆破的预防对策并进行现场应用。研究发现，爆破应力波传播到逆断层构造区域时，在煤岩交界面发生波的透射和反射，爆破振动的累积损伤使不同煤岩介质交界面的破坏最为严重，加大了煤岩体的损伤程度和破坏范围，为瓦斯动力灾害的发生提供了弱面，有利于突出的发生；定向聚能爆破可以使爆破作用集中在岩体方向，减少应力波对构造区域煤岩体的扰动；在本实验条件下，聚能方向的应力比普通爆破增加2倍左右，非聚能方向的应力减小约3倍。现场应用表明，采用定向聚能爆破后，综掘工作面坚硬岩石中的裂纹损伤扩展，达到了预先弱化的目的和综掘机破碎岩石的要求，工作面上方逆断层构造区域的煤岩体基本完整，为综掘工作面安全快速通过硬岩逆断层提供了保证。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	高魁1
	2
	刘泽功1
	2
	刘健1
	2
	朱飞昊1
	乔国栋1
	张树川1
	2

关键词 ：采矿工程, 煤与瓦斯突出, 爆破应力波, 地质构造带, 逆断层, 定向聚能爆破

Abstract：Aiming at the stability problems of the surrounding rock of roadways and the coal-rock in the tectonic area resulted from ordinary blasting in the reverse fault of the comprehensive excavation face，the coal and gas outbursts caused by blasting disturbance in the reverse fault structural zone were studied through theoretical analysis and comparison simulation experiments. Prevention measures such as changing the charge structure and using the directional cumulative blasting were proposed and applied in practice. It was found that the transmission and reflection of the blasting stress wave occur at the interface of coal and rock when the blasting stress wave propagates to the reverse fault structure area. The cumulative damage of blasting vibration causes the most serious damage to the interface of different coal and rock media，enlarges the damage degree and scope of coal and rock and provides a weak surface for the occurrence of coal and gas outburst even gas dynamic disasters. Directional cumulative blasting can concentrate the blasting action in the direction of rock and reduce the disturbance of the stress wave to the coal-rock in the structural area. Under the experimental conditions，the stresses in the energy accumulation and non-accumulation directions are respectively about 2 times and one third of those of ordinary blasting. The field application of directional accurately cumulative blasting in crossing hard rock faults in fully mechanized excavation face shows that，after blasting，the crack damage expands in the hard rock of the working face which meets the purpose of pre-weakening and the requirement of the rock breaking of the comprehensive excavator，and the coal-rock in the reverse fault structure area above the working face is basically complete which provides a guarantee for safe and rapid crossing the hard rock reverse faults in fully mechanized excavation face.

Key words： mining engineering coal and gas outburst blasting stress wave geological structure belt reverse fault directional cumulative blasting

引用本文:

高魁1，2，刘泽功1，2，刘健1，2，朱飞昊1，乔国栋1，张树川1，2. 定向聚能爆破弱化综掘工作面逆断层应用研究[J]. 岩石力学与工程学报, 2019, 38(7): 1408-1419.
GAO Kui1，2，LIU Zegong1，2，LIU Jian1，2，ZHU Feihao1，QIAO Guodong1，ZHANG Shuchuan1，2. Application research of directional cumulative blasting for weakening reverse faults in fully mechanized excavation face. , 2019, 38(7): 1408-1419.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2018.1447 或 http://www.rockmech.org/CN/Y2019/V38/I7/1408

[18]	陈建平，高文学，陶连金. 爆破工程地质控制论[J]. 工程地质学报，2006，14(5)：616-619.(CHEN Jianping，GAO Wenxue，TAO Lianjin. Theory of rock blasting control in geology engineering[J]. Journal of Engineering Geology，2006，14(5)：616-619.(in Chinese))
[28]	宗琦. 岩石炮孔预切槽爆破断裂成缝机理研究[J]. 岩土工程学报，1998，20(1)：30-33.(ZONG Qi. Investigations into mechanism of fracture formation for grooved hole-well blasting[J]. Chinese Journal of Geotechnical Engineering，1998，20(1)：30-33.(in Chinese))
[3]	余永强，杨小林，梁为民，等. 控制爆破致裂提高矿井瓦斯抽放率试验研究[J]. 煤炭学报，2007，32(4)：377-381.(YU Yongqiang，YANG Xiaolin，LIANG Weimin，et al. Testing research of improving mine gas drainage under suction by controlling blasting to cause crack[J]. Journal of China Coal Society，2007，32(4)：377-381.(in Chinese))
[4]	郭德勇，张慧杰，吕鹏飞，等. 断层对深孔聚能爆破煤层增透的影响[J]. 北京科技大学学报，2014，36(10)：1 281-1 286.(GUO Deyong，ZHANG Huijie，LU Pengfei，et al. Effect of fault on deep-hole cumulative blasting to improve coal bed permeability[J]. Journal of University of Science and Technology Beijing，2014，36(10)：1 281-1 286.(in Chinese))
[6]	高魁，刘泽功，刘健，等. 深孔爆破在深井坚硬复合顶板沿空留巷强制放顶中的应用[J]. 岩石力学与工程学报，2013，32(8)： 1 588-1 594.(GAO Kui，LIU Zegong，LIU Jian，et al. Study on application of deep borehole blasting to gob-side entry retaining forced roof caving in hard and compound roof deep well[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(8)：1 588-1 594.(in Chinese))
[8]	何满潮，高玉兵，杨军，等. 无煤柱自成巷聚能切缝技术及其对围岩应力演化的影响研究[J]. 岩石力学与工程学报，2017，36(6)：1 314-1 325.(HE Manchao，GAO Yubing，YANG Jun，et al. An energy-gathered roof cutting technique in no-pillar mining and its impact on stress variation in surrounding rocks[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(6)：1 314-1 325.(in Chinese))
[1]	张超，林柏泉，周延，等．控制爆破致裂提高矿井瓦斯抽放率试验研究[J]. 煤炭学报，2014，39(增1)：100-104.(ZHANG Chao，LIN Baiquan，ZHOU Yan，et al. Application of multi-seam metal jet directed pre-split blasting technology in gas extraction[J]. Journal of China Coal Society，2014，39(Supp.1)：100-104.(in Chinese))
[2]	龚敏，张凤舞，文斌，等. 煤巷底板岩石爆破提高瓦斯抽放率的应用与数值模拟[J]. 煤炭学报，2012，37(6)：972-977.(GONG Min，ZHANG Fengwu，WEN Bin，et al. Numerical simulation and application on blasting to improve gas drainage rate in floor rock of coal roadway[J]. Journal of China Coal Society，2012，37(6)：972-977.(in Chinese))
[9]	郭德勇，商登莹，吕鹏飞，等. 深孔聚能爆破坚硬顶板弱化试验研究[J]. 煤炭学报，2013，38(7)：1 149-1 153.(GUO Deyong，SHANG Dengying，LÜ Pengfei，et al. Experimental research of deep-hole cumulative blasting in hard roof weakening[J]. Journal of China Coal Society，2013，38(7)：1 149-1 153.(in Chinese))
[19]	孙重旭，孔凡正. 炮采炮掘工作面煤与瓦斯突出的特点与防治[J]. 煤炭工程师，1998，25(3)：19-22.(SUN Zhongxu，KONG Fanzheng. The characteristics and prevention of coal and gas outburst in blasting mining face[J]. Coal Engineer，1998，25(3)：19-22.(in Chinese))
[11]	汪海波，徐轩，宗琦，等. 综掘硬岩段深孔超前爆破研究与应用[J]. 煤炭学报，2017，42(4)：908-915.(WANG Haibo，XU Xuan，ZONG Qi，et al. Research and application of hard rock deep-hole advance blasting in comprehensive roadway excavation[J]. Journal of China Coal Society，2017，42(4)：908-915.(in Chinese))
[12]	杨仁树，张召冉，杨立云，等. 基于硬岩快掘技术的切缝药包聚能爆破试验研究[J]. 岩石力学与工程学报，2013，32(2)：317-323.(YANG Renshu，ZHANG Zhaoran，YANG Liyun，et al. Cumulative blasting experiment study of slotted cartridge based on hard-rock rapid driving technology[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(2)：317-323.(in Chinese))
[14]	张春华，刘泽功，徐涛，等. 石门对掘揭开急倾斜煤层突出与爆破增透消突技术[J]. 煤炭学报，2010，35(1)：85-88.(ZHANG Chunhua，LIU Zegong，XU Tao，et al. Coal and gas outburst in steep inclined coal seam uncovered by two reverse drifts and technology of outburst elimination by increasing permeability with blasting[J]. Journal of China Coal Society，2010，35(1)：85-88.(in Chinese))
[16]	韩磊，侯水云，贾湛永. 深孔预裂爆破弱化坚硬陷落柱技术研究[J]. 煤炭工程，2018，50(6)：81-84.(HAN Lei，HOU Shuiyun，JIA Zhanyong. Technology research of deep hole presplit blasting for hard collapse column weakening[J]. Coal Engineering，2018，50(6)：81-84.(in Chinese))
[21]	吕进国，王涛，丁维波，等. 深部开采逆断层对冲击地压的诱导机制[J]. 煤炭学报，2018，43(2)：405-416.(LÜ Jinguo，WANG Tao，DING Weibo，et al. Induction mechanisms of coal bumps caused by thrust faults during deep mining[J]. Journal of China Coal Society，2018，43(2)：405-416.(in Chinese))
[22]	胡世丽，王星光，王观石. 子波传过软弱夹层的波形变化规律[J]. 地球物理学进展，2015，30(4)：1 896-1 902.(HU Shili，WANG Xingguang，WANG Guanshi. Waveform change rule of wavelet propagation across soft interlayer[J]. Progress in Geophysics，2015，30(4)：1 896-1 902.(in Chinese))
[24]	常未斌，樊少武，张浪，等. 基于爆炸应力波和构造煤带孕育煤与瓦斯突出危险状态的模型[J]. 煤炭学报，2014，39(11)：2 226-2 231.(CHANG Weibin，FAN Shaowu，ZHANG Lang，et al. A model based on explosive stress wave and tectonic coal zone which gestate dangerous state of coal and gas outburst[J]. Journal of China Coal Society，2014，39(11)：2 226-2 231.(in Chinese))
[26]	郭德勇，裴海波，宋建成，等. 煤层深孔聚能爆破致裂增透机理研究[J]. 煤炭学报，2008，33(12)：1 381-1 385.(GUO Deyong，PEI Haibo，SONG Jiancheng，et al. Study on splitting mechanism of coal bed deep-hole cumulative blasting to improve permeability[J]. Journal of China Coal Society，2008，33(12)：1 381-1 385.(in Chinese))
[29]	穆朝民，齐娟. 爆炸荷载作用下煤体裂纹扩展机理模型实验研究[J]. 振动与冲击，2012，31(13)：58-61.(MU Chaomin，QI Juan. Model investigation on cracks propagation in coal under blast loading[J]. Journal of Vibration and Shock，2012，31(13)：58-61.(in Chinese))
[7]	何满潮，郭鹏飞，张晓虎，等. 基于双向聚能拉张爆破理论的巷道顶板定向预裂[J]. 爆炸与冲击，2018，38(4)：795-803.(HE Manchao，GUO Pengfei，ZHANG Xiaohu，et al. Directional pre- splitting of roadway roof based on the theory of bilateral cumulative tensile explosion[J]. Explosion and Shock Waves，2018，38(4)：795-803.(in Chinese))
[17]	国家安全生产监督管理总局和国家煤矿安全监察局. 网站事故查调查处理[EB/OL]. http：//www.chinasafety.gov.cn/newpage/zwgk/ tdsgdccl/zwgk_tdsgdccl_lm.htm，2015-08-15.(State Administration of Safety in Production，State Administration of Coal Mine Safety. Investigation and treatment of accidents on websites[EB/OL]. http://www.chinasafety.gov.cn/newpage/zwgk/tdsgdccl/zwgk_tdsgdccl_ lm.htm，2015-08-15.(in Chinese))
[27]	何满潮，曹伍富，单仁亮，等. 双向聚能拉伸爆破新技术[J]. 岩石力学与工程学报，2003，22(12)：2 047-2 051.(HE Manchao，CAO Wufu，SHAN Renliang，et al. New blasting technology-bilateral cumulative tensile explosion[J]. Chinese Journal of Rock Mechanics and Engineering，2003，22(12)：2 047-2 051.(in Chinese))
[5]	穆朝民，王海露，黄文尧，等. 高瓦斯低透气性煤体定向聚能爆破增透机制[J]. 岩土力学，2013，34(9)：2 496-2 500.(MU Chaomin，WANG Hailu，HUANG Wenyao，et al. Increasing permeability mechanism using directional cumulative blasting in coal seams with high concentration of gas and low permeability[J]. Rock and Soil Mechanics，2013，34(9)：2 496-2 500.(in Chinese))
[15]	黄文尧，穆朝民，宗琦，等. 水胶药柱深孔预裂爆破弱化综采面硬岩断层分析[J]. 重庆大学学报，2013，36(7)：102-107.(HUANG Wenyao，MU Chaomin，ZONG Qi，et al. Analysis on weakening hard rock used by long-hole presplitting blast in fully mechanized coal face with water-gel explosive grain[J]. Journal of Chongqing Universiny，2013，36(7)：102-107.(in Chinese))
[25]	夏彬伟，刘承伟，卢义玉，等. 缝槽水压爆破导向裂缝扩展实验研究[J]. 煤炭学报，2016，41(2)：432-438.(XIA Binwei，LIU Chengwei，LU Yiyu，et al. Experimental study of propagation of directional fracture with slotting hydraulic blasting[J]. Journal of China Coal Society，2016，41(2)：432-438.(in Chinese))
[10]	刘健，刘泽功，高魁，等. 深孔爆破在综放开采坚硬顶煤预先弱化和瓦斯抽采中的应用[J]. 岩石力学与工程学报，2014，33(增1)：3 361-3 367.(LIU Jian，LIU Zegong，GAO Kui，et al. Application of deep borehole blasting to top-coalpre-weakening and gas extraction in fully mechanized caving[J]. Chinese Journal of Rock Mechanics and Engineering，2014，33(Supp.1)：3 361-3 367.(in Chinese))
[13]	刘健，刘泽功，石必明. 低透气性突出煤层巷道快速掘进的试验研究[J]. 煤炭学报，2007，32(8)：827-831.(LIU Jian，LIU Zegong，SHI Biming. Study on the roadway excavation rapidly in the low permeability outburst coal seam[J]. Journal of China Coal Society，2007，32(8)：827-831.(in Chinese))
[23]	穆朝民，宫能平. 煤体在冲击荷载作用下的损伤机制[J]. 煤炭学报，2017，42(8)：2 011-2 018.(MU Chaomin，GONG Nengping. Damage mechanism of coal under impact loads[J]. Journal of China Coal Society，2017，42(8)：2 011-2 018.(in Chinese))
[20]	张子敏，张玉贵. 大平煤矿特大型煤与瓦斯突出瓦斯地质分析[J]. 煤炭学报，2005，30(2)：137-140.(ZHANG Zimin，ZHANG Yugui. Investigation into coal-gas outburst occurred in Daping coal mine，by using theories of gas-geology[J]. Journal of China Coal Society，2005，30(2)：137-140.(in Chinese))
[30]	郭德勇，赵杰超，张超，等. 煤层深孔聚能爆破控制孔作用机制研究[J]. 岩石力学与工程学报，2018，37(4)：919-930.(GUO Deyong，ZHAO Jiechao，ZHANG Chao，et al. Mechanism of control hole on coal crack initiation and propagation under deep-hole cumulative blasting in coal seam[J]. Chinese Journal of Rock Mechanics and Engineering，2018，37(4)：919-930.(in Chinese))