单轴压缩下宏观裂纹倾角对煤体特性影响研究

doi:10.13722/j.cnki.jrme.2016.0878

摘要
图/表
参考文献(22)
相关文章 (15)

全文: PDF (3139 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要

为研究宏观裂纹倾角对煤体特性的影响，采用YAW4306电伺服试验系统和CTA–1声发射采集系统对不同预制裂纹倾角的煤样进行单轴压缩声发射试验，分析试验过程的声发射信号特征，研究裂纹倾角对声发射响应、煤样峰值强度和裂纹扩展方式的影响。试验结果表明：宏观裂纹的存在对试样声发射信号的变化规律有显著影响，且声发射信号变化与载荷变化具有很高的一致性，能够很好地反映含宏观裂纹煤样受压时内部破裂发展情况；裂纹的存在降低煤体的强度，且随着裂纹倾角的减小，峰值强度受影响越来越明显，呈现出逐渐减小的趋势，通过曲线拟合，得出二者近似成二次函数关系；裂纹倾角为0°，15°，30°和45°的煤样，其破坏过程中主要裂纹形态为翼型裂纹，并伴有各方向细微次生裂纹；倾角为60°和75°的煤样，其主要裂纹形式为反翼裂纹；当倾角增至90°时，煤样无表面扩展裂纹，此时煤样的破裂方式为劈裂。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李德行1
	2
	王恩元1
	2
	李楠3
	孔祥国1
	2
	王笑然1
	2

关键词 ：岩石力学, 宏观裂纹, 声发射, 峰值强度, 裂纹扩展方式

Abstract：

To investigate the influence of macro-crack dip angles on the coal characteristics，acoustic emission(AE) tests under uniaxial compression of coal samples with different dip angles pre-existing crack were carried out by YAW4306 electric mechanical test system and CTA–1 acoustic emission monitor. AE signal characteristics in test process were analyzed，and the effects of macro-crack dip angles on AE response characteristics，peak stress and crack propagation modes were studied. The results show that：the existence of macro-cracks in specimen under uniaxial compression has a significant impact on AE signals，and the response of AE signals is of high consistency with the applied load，so it can well reflect the internal rupture development when macroscopic defects appear under uniaxial compression. The peak stress increase with the dip angles of the cracks，which presents quadratic function relationship by curve fitting. When the dip angle of pre-existing cracks is 0°，15°，30°and 45°respectively，the major crack morphology of coal samples in the failure process is wing crack，accompanied by subtle secondary cracks. While the dip angle rises to 60°and 75°，anti-wing cracks appear on the surface of the coal specimen. There is no obvious propagating crack on the surface when the dip angle reaches to 90°，and the coal samples show a splitting failure mode.

Key words： rock mechanics macro-crack acoustic emission(AE) peak strength crack propagation modes

引用本文:

李德行1，2，王恩元1，2，李楠3，孔祥国1，2，王笑然1，2. 单轴压缩下宏观裂纹倾角对煤体特性影响研究[J]. 岩石力学与工程学报, 2017, 36(S1): 3206-3213.
LI Dexing1，2，WANG Enyuan1，2，LI Nan3，KONG Xiangguo1，2，WANG Xiaoran1，2. Research on the coal characteristics of macro-crack dip angles under uniaxial compression. , 2017, 36(S1): 3206-3213.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2016.0878 或 https://rockmech.whrsm.ac.cn/CN/Y2017/V36/IS1/3206

[1]	钱鸣高，石平五. 矿山压力与岩层控制[M]. 徐州：中国矿业大学出版社，2003：109-112.(QIAN Minggao，SHI Pingwu. Mining pressure and strata control[M]. Xuzhou：China University of Mining and Technology Press，2003：109-112.(in Chinese))
[2]	姜耀东，潘一山，姜福兴，等. 我国煤炭开采中的冲击地压机制和防治[J]. 煤炭学报，2014，39(2)：205-213.(JIANG Yaodong，PAN Yishan，JIANG Fuxing，et al. Mechanism and prevention of rock burst in coal mining in China[J]. Journal of China Coal Society，2014，39(2)：205-213.(in Chinese))
[3]	CAI M，KAISER P K，TASAKA Y，et al. Generalized crack initiation and crack damage stress thresholds of brittle rock masses near underground excavations[J]. International Journal of Rock Mechanics and Mining Sciences，2004，41(5)：833-847.
[4]	ASHBY M F，HALLAM S D. The failure of brittle solids containing small cracks under compressive stress states[J]. Acta Metallurgy，1986，34(3)：497-510.
[5]	林鹏，黄凯珠，王仁坤，等. 不同角度单裂纹缺陷试样的裂纹扩展与破坏行为[J]. 岩石力学与工程学报，2005，24(增2)：5 652- 5 657.(LIN Peng，WONG R H C，WANG Renkun，et al. Crack growth mechanism and failure behavior of specimen containing single flaw with different angles[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(Supp.2)：5 652-5 657.(in Chinese))
[6]	李术才，朱维申. 复杂应力状态下断续节理岩体断裂损伤机制研究及其应用[J]. 岩石力学与工程学报，1999，18(2)：142-146.(LI Shucai，ZHU Weishen. Fracture damage mechanism of discontinuous jointed rockmass under the state of complex stress and its application[J]. Chinese Journal of Rock Mechanics and Engineering，1999，18(2)：142-146.(in Chinese))
[7]	宋彦琦，李名，王晓，等. 基于高速摄影的单预制裂纹大理岩加卸载试验[J]. 中国矿业大学学报，2014，43(5)：773-781.(SONG Yanqi，LI Ming，WANG Xiao，et al. Observation of marble with single pre-existing crack using high-speed photography under loading and unloading conditions[J]. Journal of China University of Mining and Technology，2014，43(5)：773-781.(in Chinese))
[8]	赵兴东，李元辉，袁瑞甫，等. 基于声发射定位的岩石裂纹动态演化过程研究[J]. 岩石力学与工程学报，2007，26(5)：944-950. (ZHAO Xingdong，LI Yuanhui，YUAN Ruifu，et al. Study on crack dynamic propagation process of rock samples based on acoustic emission location[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(5)：944-950.(in Chinese))
[9]	王恩元，何学秋，刘贞堂，等. 煤体破裂声发射的频谱特征研究[J]. 煤炭学报，2004，29(3)：289-292.(WANG Enyuan，HE Xueqiu，LIU Zhentang，et al. Study on frequency spectrum characteristics of acoustic emission in coal or rock deformation and fracture[J]. Journal of China Coal Society，2004，29(3)：289-292.(in Chinese))
[10]	王恩元. 含瓦斯煤破裂的电磁辐射和声发射效应及其应用研究[博士学位论文][D]. 徐州：中国矿业大学，1997.(WANG Enyuan. The effect of EME& AE during the fracture of coal containing gas and its applications[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，1997.(in Chinese))
[11]	杨永杰，王德超，郭明福，等. 基于三轴压缩声发射试验的岩石损伤特征研究[J]. 岩石力学与工程学报，2014，33(1)：98-104.(YANG Yongjie，WANG Dechao，GUO Mingfu，et al. Study of rock damage characteristics based on acoustic emission tests under triaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2014，33(1)：98-104.(in Chinese))
[12]	李术才，许新骥，刘征宇，等. 单轴压缩条件下砂岩破坏全过程电阻率与声发射响应特征及损伤演化[J]. 岩石力学与工程学报，2014，33(1)：14-23.(LI Shucai，XU Xinji，LIU Zhengyu，et al. Electrical resistivity and acoustic emission response characteristic and damage evolution of sandstone during whole process of uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2014，33(1)：14-23.(in Chinese))
[13]	刘杰，王恩元，李忠辉，等. 预制裂纹煤样单轴压缩表面电位实验研究[J]. 煤炭学报，2011，36(7)：1 135-1 138.(LIU Jie，WANG Enyuan，LI Zhonghui，et al. Experiment study on surface potential of pre-cracked coal under uniaxial compression[J]. Journal of China Coal Society，2011，36(7)：1 135-1 138.(in Chinese))
[14]	宋晓艳，李忠辉. 预制裂纹煤系岩石破坏的电磁辐射规律研究[J]. 煤矿安全，2015，46(10)：56-59.(SONG Xiaoyan，LI Zhonghui. Study on electromagnetic radiation laws from coal measures rock with precrack during its failure[J]. Safety in Coal Mines，2015，46(10)：56-59.(in Chinese))
[15]	许江，程立朝，谭皓月，等. 原生裂纹对煤岩剪切破坏宏细观演化规律的影响研究[J]. 岩石力学与工程学报，2013，32(1)：33-40. (XU Jiang，CHENG Lizhao，TAN Haoyue，et al. Effects of original cracks on macro-meso evolution law of coal shear failure[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(1)：33-40.(in Chinese))
[16]	赵程，田加深，松田浩，等. 单轴压缩下基于全局应变场分析的岩石裂纹扩展及其损伤演化特性研究[J]. 岩石力学与工程学报，2015，34(4)：763-769.(ZHAO Cheng，TIAN Jiashen，SONG Tianhao，et al. Crack propagation and damage of rock under uniaxial compression based on global strain field analysis[J]. Chinese Journal of Rock Mechanics and Engineering，2015，34(4)：763-769.(in Chinese))
[17]	方恩权，蔡永昌，朱合华. 单轴压缩岩石不同边界裂纹扩展数值模拟研究[J]. 地下空间与工程学报，2009，5(1)：100-104.(FANG Enquan，CAI Yongchang，ZHU Hehua. Numerical studies of crack propagation in free boundary shape under uniaxial compression[J]. Chinese Journal of Underground Space and Engineering，2009，5(1)：100-104.(in Chinese))
[18]	梁正召，李连崇，唐世斌，等. 岩石三维表面裂纹扩展机制数值模拟研究[J]. 岩土工程学报，2011，32(10)：1 615-1 622.(LIANG Zhengzhao，LI Lianchong，TANG Shibin，et al. 3D numerical simulation of growth of surface crack of rock specimens[J]. Chinese Journal of Geotechnical Engineering，2011，32(10)：1 615-1 622.(in Chinese))
[19]	ZHANG X P，LOUIS NGAI Y W. Cracking processes in rock-like material containing a single flaw under uniaxial compression：A numerical study based on parallel bonded-particle model approach[J]. Rock Mechanics and Rock Engineering，2012，45(6)：711-737.
[20]	杨圣奇，温森，李良权. 不同围压下断续预制裂纹粗晶大理岩变形和强度特性的试验研究[J]. 岩石力学与工程学报，2007，26(8)：1 572-1 587.(YANG Shengqi，WEN Sen，LI Liangquan. Experimental study on deformation and strength properties of coarse marble with discontinous pre-existing cracks under different confining pressures[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(8)：1 572-1 587.(in Chinese))
[21]	张晓平，王思敬，韩庚友，等. 岩石单轴压缩条件下裂纹扩展试验研究——以片状岩石为例[J]. 岩石力学与工程学报，2011，30(9)：1 772-1 781.(ZHANG Xiaoping，WANG Sijing，HAN Gengyou，et al. Crack propagation study of rock based on uniaxial compressive test—a case study of schistose rock[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(9)：1 772-1 781.(in Chinese))
[22]	郭彦双，黄凯珠，朱维申，等. 辉长岩中张开型表面裂隙破裂模式研究[J]. 岩石力学与工程学报，2007，26(3)：525-531.(GUO Yanshuang，HUANG Kaizhu，ZHU Weishen，et al. Study on fracture pattern of open surface-flaw in gabbro[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(3)：525-531.(in Chinese))