烧料礓石改性浆体–遗址土体界面抗剪性能试验

doi:10.13722/j.cnki.jrme.2016.0785

摘要
图/表
参考文献(26)
相关文章 (0)

全文: PDF (2827 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究土遗址锚固系统中浆体–土体界面抗剪性能，揭示锚固系统内部受力机制。试验选择目前土遗址锚固工程中常用的烧料礓石、粉煤灰、石英砂及遗址土作为主要浆体材料，同原状遗址土制成黏结试样。根据实际工作条件，对试样进行室外土体掩埋养护。通过浆体–土体界面直接剪切试验，得到不同配比浆体–土体界面的剪应力–位移关系曲线、抗剪强度参数及浆体–土体界面剪应力–位移拟合曲线。试验结果表明，浆体–土体界面未能有效黏结，界面抗剪强度主要依靠滑动摩擦及咬合摩擦承担；烧料礓石改性遗址土浆体与遗址土体黏结试样内摩擦角最大，浆体材料兼容性对界面抗剪强度的提高具有重要意义。室外掩埋养护土体温湿度的频繁波动和PS溶液的固化作用对界面黏结能力影响显著。因此，土遗址锚固工艺是保证锚固质量的关键因素之一。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王南1
	张景科1
	2
	单婷婷1
	郭青林2
	赵林毅2
	李最雄2

关键词 ：土力学；土遗址；锚固浆体；烧料礓石；浆体&ndash, 土体界面；直接剪切试验；抗剪性能

Abstract：To explore the shear resistance behavior of grout-soil interface in anchoring conservation of earthen sites and reveal the internal mechanical mechanism of anchorage system，calcined ginger nuts，fly ash，quartz sand and soil from earthen sites which are commonly used in anchoring engineering are selected as the main grout materials. Bonded samples were made by grout and undisturbed soil from earthen sites. Regarding the actual environment at which the anchor system survives，all the samples were buried and maintained in outdoor soil mass. The relationship between shear stress and displacement，strength parameters，and a new fitting formula were gained by direct shear test. The results show that slurry and soil fail to bond，interfacial shear strength should rely on sliding friction and particles interlock capacity. The mixing slurry of calcined ginger nuts with earthen sites soil presents the largest inner friction angle，which means that compatibility between slurry and soil is of important significance to improve shear strength of interface. Owing to the large variation of temperature and moisture and consolidation of grout-soil interface by PS solution，shear resistance of grout-soil interface is to some extent weakened. The experimental results reveal that anchor craft of earthen sites plays an important role in the improvement of shear strength.

Key words： soil mechanics earthen sites anchor slurry calcined ginger nuts grout-soil interface direct shear test shear resistance behavior

引用本文:

王南1，张景科1，2，单婷婷1，郭青林2，赵林毅2，李最雄2. 烧料礓石改性浆体–遗址土体界面抗剪性能试验[J]. 岩石力学与工程学报, 2016, 35(S2): 4279-4286.
WANG Nan1，ZHANG Jingke1，2，SHAN Tingting1，GUO Qinglin2，ZHAO Linyi2，LI Zuixiong2. Experiment on shear resistance behavior of interface between slurry modified by calcined ginger nuts and soil mass of earthen sites. , 2016, 35(S2): 4279-4286.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2016.0785 或 https://rockmech.whrsm.ac.cn/CN/Y2016/V35/IS2/4279

[1] 王旭东，李最雄，谌文武，等. 土遗址保护关键技术研究[M]. 北京：科学出版社，2013：9–12.(WANG Xudong，LI zuixiong，CHEN Wenwu，et al. Research on key technologies for the conservation of earthen sites[M]. Beijing: Science Press，2013：9–12.(in Chinese))

[2] 张景科，王南，谌文武，等. 夯筑土遗址中基于PS-(F+C)浆液的木锚杆锚固性能[J]. 四川大学学报：工程科学版，2015，47(4)：52–60.(ZHANG Jingke，WANG Nan，CHEN Wenwu，et al. Anchor performance of wood bolt fully grouted by PS-(F+C) slurry in rammed earth sites[J]. Journal of Sichuan University：Engineering Science，2015，47(4)：52–60.(in Chinese))

[3] 饶枭宇，李剑，杨静. 锚固注浆体性能试验研究[J]. 重庆交通大学学报：自然科学版，2009，28(3)：497–500.(RAO Xiaoyu，LI jian，YANG Jing. Experimental study on performance of cement- based grout for anchorage engineering[J]. Journal of Chongqing Jiaotong University：Natural Science，2009，28(3)：497–500.(in Chinese))

[4] 任非凡. 南竹加筋复合锚杆锚固机制研究[博士学位论文][D]. 兰州：兰州大学，2009.(REN Feifan. Study on the anchorage mechanism of the bamboo-steel composite rockbolts[Ph. D. Thesis][D]. Lanzhou：Lanzhou University，2009.(in Chinese))

[5] 孙满利，李最雄，王旭东，等. 南竹加筋复合锚杆加固土遗址研究[J]. 岩石力学与工程学报，2008，27(增2)：3 381–3 385.(SUN Manli，LI Zuixiong，WANG Xudong，et al. Study on reinforcement of earthen sites by bamboo-steel composite anchor[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(Supp.2)：3 381–3 385.(in Chinese))

[6] 孙满利，王旭东，李最雄，等. 木质锚杆加固生土遗址研究[J]. 岩土工程学报，2006，28(12)：2 156–2 159.(SUN Manli，WANG Xudong，LI Zuixiong，et al. Study on immature earthen sites reinforced with wood anchor[J]. Chinese Journal of Geotechnical Engineering，2006，28(12)：2 156–2 159.(in Chinese))

[7] 李最雄. 世界上最古老的混凝土[J]. 考古，1988，(8)：751–765.(LI Zuixiong. The oldest concrete in the world[J]. Archaeology，1988，(8)：751–756.(in Chinese))

[8] ZHANG J K，CHEN W W，LI Z X，et al. Study on workability and durability of calcined ginger nuts-based grouts used in anchoring conservation of earthen sites[J]. Journal of Cultural Heritage，2015，16(6)：831–837.

[9] 程良奎，胡建林，张培文. 岩土锚固技术新发展[J]. 工业建筑，2010，40(1)：98–101.(CHENG Liangkui，HU Jianlin，ZHANG Peiwen. The new development of ground anchorage in China[J]. Industrial Construction，2010，40(1)：98–101.(in Chinese))

[10] 沈俊，顾金才，张向阳，等. 拉力型和压力型自由式锚索现场拉拔试验研究[J]. 岩石力学与工程学报，2012，31(增1)：3 291–3 297. (SHEN Jun，GU Jincai，ZHANG Xiangyang，et al. Field pull-out test research on tension and pressure unbounded anchor cables[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(Supp.1)：3 291–3 297.(in Chinese))

[11] LIANG R Y，FENG Y. Development and application of anchor-soil interface models[J]. Journal of the Japanese Geotechnical Society Soils and Foundation，2002，42(2)：59–70.

[12] 邬爱清，韩军，罗超文，等. 单孔复合型锚杆锚固体应力分布特征研究[J]. 岩石力学与工程学报，2004，23(2)：247–251.(WU Aiqing，HAN Jun，LUO Chaowen，et al. Research on stress distribution along bolts with single borehole and multiple anchors[J]. Chinese Journal of Rock Mechanics and Engineering，2004，23(2)：247–251.(in Chinese))

[13] 张景科，陈鹏飞，谌文武，等. 夯土–水硬石灰与石英砂浆液-木锚杆锚固系统性能[J]. 土木建筑与环境工程，2015，37(3)：86–93.(ZHANG Jingke，CHEN Pengfei，CHEN Wenwu，et al. Anchor performance of wood bolt fully grouted by natural hydraulic lime and quartz sand slurry[J]. Journal of Civil Architectural and Environmental Engineering，2015，37(3)：86–93.(in Chinese))

[14] 孙满利，王旭东，李最雄. 土遗址保护初论[M]. 北京：科学出版社，2010：177–180.(SUN Manli，WANG Xudong，LI Zuixiong. Preliminary theory of earth site protection[M]. Beijing：Science Press，2010：177–180. (in Chinese))

[15] 郭青林，张景科，孙满利，等. 新疆北庭故城病害特征及保护加固研究[J]. 敦煌研究，2013(1)，13–17.(GUO Qinglin，ZHANG Jingke，SUN Manli，et al. A study on the characteristics of deterioration and the conservation of ancient Beiting city in xinjiang[J]. Dunhuang Research，2013(1)，13–17.(in Chinese))

[16] 陈昌富，梁冠亭，汤宇，等. 锚杆锚固体与土体界面特性室内测试新方法[J]. 岩土工程学报，2015，37(6)：1 115–1 122.(CHEN Changfu，LIANG Guanting，TANG Yu，et al. Anchoring solid-soil interface behavior using a novel laboratory testing technique[J]. Chinese Journal of Geotechnical Engineering，2015，37(6)：1 115–1 122.(in Chinese))

[17] 韩军，陈强，刘元坤，等. 锚杆灌浆体与岩(土)体间的黏结强度[J]. 岩石力学与工程学报，2005，24(19)：3 482–3 486.(HAN Jun，CHEN Qiang，LIU Yuankun，et al. Bond strength between anchor grout and rock or soil masses[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(19)：3 482–3 486.(in Chinese))

[18] 张永兴，饶枭宇，唐树明，等. 预应力锚索注浆体与岩石黏结界面抗剪强度试验[J]. 中国公路学报，2008，21(6)：1–6.(ZHANG Yongxing，RAO Xiaoyu，TANG Shuming，et al. Experiment on shear strength of cementation plane between grout and rock in prestressed anchor[J]. China Journal of Highway and Transport，2008，21(6)： 1–6.(in Chinese))

[19] 龚成中，龚维明，何春林，等. 孔壁粗糙度对深嵌岩桩承载特性的影响[J]. 中国公路学报，2011，24(2)：56–61.(GONG Chengzhong，GONG Weiming，HE Chunlin，et al. Influence of hole side roughness on bearing characteristic of deep rock-socketed pile[J]. China Journal of Highway and Transport，2011，24(2)：56–61.(in Chinese))

[20] 尤春安，战玉宝. 预应力锚索锚固段界面滑移的细观力学分析[J]. 岩石力学与工程学报，2009，28(10)：1 976–1 985.(YOU Chunan，ZHAN Yubao. Analysis of interfacial slip mesomechanics in anchorage section of prestressed anchor cable[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(10)：1 976–1 985.(in Chinese))

[21] 李黎，赵林毅. 中国古代石灰类材料研究[M]. 北京：文物出版社，2015：226–230.(LI Li，ZHAO Linyi. Research on lime materials in ancient China[M]. Beijing：Cultural Relics Press，2015：226–230.(in Chinese))

[22] 中华人民共和国行业标准编写组. GB–50666——2011 混凝土结构工程施工规范[S]. 北京：中国建筑工业出版社，2012.(The Professional Standards Compilation Group of People¢s Republic of China. GB–50666——2011 Code for construction of concrete structures[S]. Beijing：China Building Industry Press，2012.(in Chinese))

[23] 李最雄. 丝绸之路古遗址保护[M]. 北京：科学出版社，2008：51–55.(LI Zuixiong. Conservation of ancient sites on the silk road[M]. Beijing：Science Press，2008：51–55.(in Chinese))

[24] CHU L M，YIN J H. Study on soil–cement grout interface shear strength of soil nailing by direct shear box testing method[J]. Geomechanics and Geoengineering，2006，1(4)：259–273.

[25] 邓华锋，原先凡，李建林，等. 土石混合体直剪试验的破坏特征及抗剪强度取值方法研究[J]. 岩石力学与工程学报，2013，32(增2)：4 065–4 072.(DENG Huafeng，YUAN Xianfan，LI Jianlin，et al. Research on failure characteristics and determination method for shear strength of earth-rock aggregate in direct shear tests[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(Supp.2)：4 065–4 072.(in Chinese))

[26] 王刚，袁康，蒋宇静，等. 剪切荷载下岩体结构面–浆体–锚杆互相作用机制宏观研究[J]. 中南大学学报：自然科学版，2015，46(6)：2 207–2 215.(WANG Gang，YUAN Kang，JIANG Yujing，et al. Macro-micro mechanical on joint-grout bolt interaction in rockmass subjected to shear loading[J]. Journal of Central South University：Science and Technology，2015，46(6)：2 207–2 215.(in Chinese))