穿层爆破各煤层动态应力分布与抽放效果探讨

摘要
图/表
参考文献(15)
相关文章 (0)

全文: PDF (2559 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要穿层深孔爆破在石门揭煤及局部地段防止瓦斯突出有重要作用，由于爆破区域跨越多层煤、岩介质以及扇形布孔造成孔口孔底最小抵抗线不相等因素影响，穿层深孔爆破研究较为困难。在大量矿井试验基础上，利用三维数值模拟方法，研究有代表意义的穿层深孔爆破相关理论问题。建立穿层爆破计算模型，获得不同位置抽放孔有效应力随时间变化规律；探讨各抽放孔有效应力随距炮孔水平距离增加而衰减，以及不同抽放孔轴线方向两层煤中应力分布的差异。计算结果表明：复合介质孔口、孔底煤层中爆破裂隙贯通范围分别为1.4，1.8 m；孔底由于锥形波的叠加和应力波反射双重作用影响，在相同距离时孔底有效应力平均值较孔口大73%；煤–岩复合介质中煤层爆破效果优于单煤层爆破效果，同等情况下，复合介质煤层中孔口处有效应力极值较单煤层增加17%～42%，孔底增加6%～24%。现场实践表明，当作用在抽放孔轴线的平均有效应力由7.12 MPa增到12 MPa后，瓦斯抽放总量增加3倍以上。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	龚敏1
	熊本良2
	王楚翰1
	王华1

关键词 ：采矿工程；穿层爆破；煤&ndash, 岩介质；扇形布孔；数值计算

Abstract：The deep-hole blasting through strata has important role for outburst prevention in rock cross-cut coal uncovering and some special area. The difficulty of the research is caused by the area blasted in layers of coal-rock media and different burden in fan-patterned holes. Based on lots of mine experiments，a representative blasting theory through layers of coal-rock is studied by three-dimensional numerical simulation method. The numerical calculation models for the blasting through strata are constructed. The effective stresses variations of different locations at different times are acquired；the law that the effective stresses of different draining holes decreases with increase of the distance is analyzed；and distribution of effective stress along axis in the holes is discussed in the coal seams. The calculation results show that：(1) The perforation range of blasting cracks at top and bottom of the draining hole in layers of coal-rock media is up to 1.4 and 1.8 m respectively. (2) The average value of effective stress in bottom of the hole is 73% higher than in top at the same location because of actions of the stress interference and reflection in bottom of the hole. (3) The blasting effect in coal seam in layers of coal-rock media is better than in single coal seam. Under the same condition，the maximum value of the effective stress at top and bottom of the draining hole in the multi-media is 17%–42% and 6%–24% higher than in single coal seam. When average values of effective stress increases from 7.12 MPa to 12 MPa along axis of the hole，the gas draining gross increases more than 3 times.

Key words： mining engineering through strata blasting layers of coal-rock media fan-patterned holes numerical calculation

引用本文:

龚敏1，熊本良2，王楚翰1，王华1. 穿层爆破各煤层动态应力分布与抽放效果探讨[J]. 岩石力学与工程学报, 2012, 31(S1): 2989-2996.
GONG Min1，XIONG Benliang2，WANG Chuhan1，WANG Hua1 . DISCUSSION ON DISTRIBUTION OF DYNAMIC STRESS AND GAS DRAINING EFFICIENCY IN COAL SEAMS BY BLASTING THROUGH LAYERS OF COAL-ROCK. , 2012, 31(S1): 2989-2996.

链接本文:

https://rockmech.whrsm.ac.cn/CN/Y2012/V31/IS1/2989

[1] 吕有厂. 穿层深孔控制爆破防治冲击型突出研究[J]. 采矿与安全工程学报，2008，25(3)：337–340. (LU Youchang. Preventing rock burst by using deep crossing-hole controlled blasting[J]. Journal of Mining and Safety Engineering，2008，25(3)：337–340.(in Chinese)).

[2] 蓝成仁. 穿层深孔爆破提高瓦斯抽放量[J]. 煤矿安全，2003，34(8)：14–16.(LAN Chengren. Increasing suction quantity of firedamp by long hole blasting in crossing hole[J]. Safety in Coal Mines，2003，34(8)：14–16. (in Chinese))

[3] 陈鹏，郭金栋，李忠辉，等. 高瓦斯低透气性煤层石门揭煤卸压爆破试验[J]. 煤炭科学技术，2009，37(6)：49–56.(CHEN Peng，GUO Jindong，LI Zhonghui，et al. Test on pressure released blasting applied to seam opening of cross-cut in high gassy and low permeability seam[J]. Coal Science and Technology，2009，37(6)：49–56.(in Chinese))

[4] 李宗远，郭志强，王之贵，等. 崔庙煤矿穿层钻孔聚能爆破实验阶段效果分析[J]. 煤炭技术，2009，28(6)：99–101.(LI Zongyuan，GUO Zhiqiang，WANG Zhigui，et al. Effect analysis of experimental stage on mohaupt blasting with drilling through coal seams in Cuimiao coal mine [J]. Coal technology，2009，28(6)：99–101.(in Chinese))

[5] 刘健，刘泽功，石必明. 低透气性突出煤层巷道快速掘进的试验研究[J]. 煤炭学报，2007，32(8)：827–831.(LIU Jian，LIU Zegong，SHI Biming. Study on the roadway excavation rapidly in the low permeability outburst coal seam[J]. Journal of China Coal Society，2007，32(8)：827–831.(in Chinese))

[6] 刘文革，题正义，黄文尧. 轴对称聚能药管及其聚能效应[J]. 辽宁工程技术大学学报，2006，25(增1)：126–128.(LIU Wenge，TI Zhengyi，HUANG Wenyao. New axisymmetric amplitude transformer of explosive and its mohaupt effect[J]. Journal of Liaoning Technical University，2006，25(Supp.1)：126–128.(in Chinese)

[7] 林柏泉. 深孔控制卸压爆破及其防突作用机理的实验研究[J]. 阜新矿业学院：自然科学版，1995，14(3)：16–21.(LIN Baiquan. The research on outburst preventive mechanism of controlling stress relaxation blast in deep borehole of coal tunnel[J]. Journal of Fuxin Mining Institute：Natural Science，1995，14(3)：16–21.(in Chinese))

[8] QIU J D，GONG M. Application of technology of deep-hole preprinting blasting for gas control in Baijiao mine [C]// YU Ning ed. Prevention and Control Technology of Gas Disaster in coal Mine. Beijing：Science Press，2009：638–644.

[9] 余永强，杨小林，梁为民，等. 控制爆破致裂提高矿井瓦斯抽放率试验研究[J]. 煤炭学报，2007，32(4)：377–381.(YU Yongqiang，YANG Xiaolin，LIANG Weimin，et al. Testing research of improving mine gas drainage under suction by controlling blasting to cause crack[J]. Journal of China Coal Society，2007，32(4)：377–381.(in Chinese))

[10] 龚敏，黄毅华，王德胜，等. 松软煤层深孔预裂爆破力学特性的数值分析[J]. 岩石力学与工程学报，2008，27(8)：1 674–1 681.

(GONG Min，HUANG Yihua，WANG Desheng，et al. Analysis of numerical simulation on mechanics feature of deep-hole pre-splitting blasting in soft coal bed[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(8)：1 674–1 681.(in Chinese))

[11] 严加刚. 扇形中深孔孔间微差爆破在西石门铁矿的应用[J]. 矿业研究与开发，2003，23(5)：53–54.(YAN Jiagang. Application of fan middle deep-hole millisecond blasting in Xishimen iron mine[J]. Mining Research and Development，2003，23(5)：53–54.(in Chinese))

[12] 任凤玉，王文杰，韩文杰. 无底柱分段崩落法扇形炮孔爆破机制研究与应用[J]. 东北大学学报：自然科学版，2006，27(11)：1 267–1 269.(REN Fengyu，WANG Wenjie，HAN Wenjie. The blasting mechanism of fan-patterned holes and its application in sublevel caving[J]. Journal of North Astern University：Natural Science，2006，27(11)：1 267–1 269.(in Chinese))

[13] Livermore Software Technology Corporation. LS-DYNA keyword user′s manual[M]. California：Livermore Software Technology Corporation，2006.

[14] 北京科技大学. 川南矿区北京科技大学突出煤层深孔预裂爆破提高瓦斯抽放率总结报告[R]. 北京：北京科技大学，2010.(University of Science and Technology Beijing. Summarizing report of improving gas pre-drainage ratio by deep-hole pre-splitting blasting for outburst coal seam in Southern coal mine Sichuan province[R]. Beijing：University of Science and Technology Beijing，2010.(in Chinese))

[15] 龚敏，刘万波，王德胜，等. 提高煤矿瓦斯抽放效果的控制爆破技术[J]. 北京科技大学学报，2006，28(3)：223–226.(GONG Min， LIU Wanbo，WANG Desheng，et al. Control blasting technique to improve gas pre-drainage effect in a coal mine[J]. Journal of University of Science and Technology Beijing，2006，28(3)：223–226.(in Chinese))