|
|
|
| LABORATORY STUDY OF DEFORMATION AND FAILURE OF SOFT ROCK FOR DEEP GROUND TUNNELLING WITH TBM |
| HUANG Xing1，LIU Quansheng1，2，LIU Kaide3，KANG Yongshui1，LIU Xuewei1 |
| (1. State Key Laboratory of Geomechanics and Geotechnical Engineering，Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，Wuhan，Hubei 430071，China；2. School of Civil Engineering，Wuhan University，Wuhan，Hubei 430072，China；3. Xi?an Research Institute，China Coal Technology and Engineering Group，Xi?an，Shaanxi 710054，China) |
|
|
|
|
Abstract The TBM excavation in deep stratum is a process of smooth and quasi-static unloading of high initial confining pressure. In order to reveal the deformation and failure characteristics of soft rock at deep ground under the condition of TBM tunnelling，triaxial unloading tests on sandy mudstone with different unloading rates were carried out. The pre-peak stress-strain curves under the condition of smooth and quasi-static unloading of confining pressure were found close to the ones obtained from the conventional triaxial compression test. At the yielding stage upon unloading，the specimens exhibit damage dilatation，the lateral deformation grows accelerated，resulting in a turning of the volumetric strain from shrinkage into dilatation. After the peak strength，the specimens slide along the fracture surface already formed to display the modest brittle drop of strength once or twice. Then a linear strain softening stage accompanied by multistage micro fractures occurs on the stress-strain curve with a line segment of a small slope as the confining pressure is continuously and slowly unloaded. The complete deformation process of unloading is composed of the elastic deformation，the damage dilation，the post-peak brittle drop，the linear strain softening and the residual stress period. The specimens display composite shear-tension failure macroscopically accompanied with axial splitting cracks during the process of smooth unloading. Many split cracks link and cross each other to form a shear band of a certain width. The rock in the shear band is squeezed and wears into the fine particles and the powder as a result of the interaction of axial extrusion and the shear stress along the shear plane.
|
|
Received: 26 September 2013
|
|
|
|
| [1] 刘泉声，黄 兴，时 凯，等. 煤矿超千米深部全断面岩石巷道掘进机的提出及关键岩石力学问题[J]. 煤炭学报，2012，37(12)：2 006–2 013.(LIU Quansheng，HUANG Xing，SHI Kai，et al. Utilization of full face roadway boring machine in coal mines deeper than 1 000 km and the key rock mechanics problems[J]. Journal of China Coal Society，2012，37(12)：2 006–2 013.(in Chinese))
[2] 王梦恕，李典璜，张镜剑，等. 岩石隧道掘进机(TBM)施工及工程实例[M]. 北京：中国铁道出版社，2004：121–124.(WANG Mengshu，LI Dianhuang，ZHANG Jingjian，et al. Tunneling with rock TBM and related case histories[M]. Beijing：China Railway Publishing House，2004：121–124.(in Chinese))
[3] 张镜剑，傅冰骏. 隧道掘进机在我国应用的进展[J]. 岩石力学与工程学报，2007，26(2)：226–238.(ZHANG Jingjian，FU Bingjun. Advances in tunnel boring machine application in China[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(2)：226–238.(in Chinese))
[4] 时 凯. 复合地层TBM盘形滚刀破岩机制及刀盘–掘进面相互作用[博士学位论文][D]. 武汉：中国科学院武汉岩土力学研究所，2013.(SHI Kai. Mechanism of rock fragmentation by disc cutters and interaction between cutterhead of TBM and mixed-face[Ph. D. Thesis][D]. Wuhan：Wuhan Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，2013.(in Chinese))
[5] 刘泉声，黄 兴，时 凯，等. 超千米深部全断面岩石掘进机卡机机制[J]. 煤炭学报，2013，38(1)：78–84.(LIU Quansheng，HUANG Xing，SHI Kai，et al. Jamming mechanism of full face tunnel boring machine in over thousand-meter depths[J]. Journal of China Coal Society，2013，38(1)：78–84.(in Chinese))
[6] 黄 兴. 深部软弱地层TBM掘进围岩挤压大变形与卡机致灾机制[博士学位论文][D]. 武汉：中国科学院武汉岩土力学研究所，2014.(HUANG Xing. Mechanism of large squeezing deformation and shield jamming in deep soft ground tunnelling by TBM[Ph. D. Thesis][D]. Wuhan：Wuhan Institute of Rock and Soil Mechanics， Chinese Academy of Sciences，2014.(in Chinese))
[7] 尚彦军，史永跃. 昆明上公山隧道复杂地质条件下TBM卡机及护盾变形问题分析和对策[J]. 岩石力学与工程学报，2005，24(21)：3 858–3 863.(SHANG Yanjun，SHI Yongyue. TBM Jamming and deformation in complicated geological conditions and engineering measures[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(21)：3 858–3 863.(in Chinese))
[8] 黄润秋，黄 达. 卸荷条件下花岗岩力学特性试验研究[J]. 岩石力学与工程学报，2008，27(11)：2 205–2 213.(HUANG Runqiu，HUANG Da. Experimental research on mechanical properties of granites under unloading condition[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(11)：2 205–2 213.(in Chinese))
[9] 张成良，赵晓霞. 辉绿岩在加、卸荷条件下的岩体力学特性试验[J]. 煤炭学报，2011，36(增2)：224–230.(ZHANG Chengliang，ZHAO Xiaoxia. Experiment on mechanics properties of diabase under the press of loading and unloading[J]. Journal of China Coal Society，2011，36(Supp.2)：224–230.(in Chinese))
[10] 李建林，王瑞红，蒋昱州，等. 砂岩三轴卸荷力学特性试验研究[J]. 岩石力学与工程学报，2010，29(10)：2 034–2 041.(LI Jianlin，WANG Ruihong，JIANG Yuzhou，et al. Experimental study of sandstone mechanical properties by unloading triaxial tests[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(10)：2 034–2 041. (in Chinese))
[11] RAMONI M，ANAGNOSTOU G. The interaction between shield，ground and tunnel support in tbm tunnelling through squeezing ground[J]. Rock Mechanics Rock Engineering，2011，44：37–61.
[12] GRAZIANI A，CAPATA A，ROMBADI P. Analysis of rock- TBM-lining interaction in squeezing rock[J]. Felsbau Magazin，2007，25(6)：23–31.
[13] 李 清，杨仁树，李均雷，等. 爆炸荷载作用下动态裂纹扩展试验研究[J]. 岩石力学与工程学报，2005，24(16)：2 912–2 916.(LI Qing，YANG Renshu，LI Junlei，et al. Experimental study on propagation of dynamic cracks under blasting loading[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(16)：2 912–2 916. (in Chinese))
[14] 陈静曦. 裂纹扩展速度监测分析[J]. 岩石力学与工程学报，1998，17(4)：425–428.(CHEN Jingxi. Monitoring analysis for the velocity of crack propagation[J]. Chinese Journal of Rock Mechanics and Engineering，1998，17(4)：425–428.(in Chinese))
[15] 严 鹏，卢文波，陈 明，等. 深部岩体开挖方式对损伤区影响的试验研究[J]. 岩石力学与工程学报，2011，30(6)：1 097–1 106. (YAN Peng，LU Wenbo，CHEN Ming，et al. In-situ test research on influence of excavation method on induced damage zone in deep tunnel[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(6)：1 097–1 106.(in Chinese))
[16] 严 鹏，卢文波，许红涛. 高地应力条件下隧洞开挖动态卸荷的破坏机制初探[J]. 爆炸与冲击，2007，27(3)：283–288(YAN Peng，LU Wenbo，XU Hongtao. A prmiary study to damage mechanism of initial stress dynamic unloading when excavating under high geo-stress condition[J]. Explosion and Shock Waves，2007，27(3)：283–288.(in Chinese))
[17] 薛备芳. 掘进机开挖法与钻爆法对围岩稳定性影响比较[J]. 水利电力施工机械，1995，17(4)：16–17.(XUE Beifang. Comparison of the influence on the tunnel surrounding rock between TBM and blasting excavation[J]. Construction Machinery for Hydraulic Engineering and Power Station，1995，17(4)：16–17.(in Chinese))
[18] 陈炳瑞，冯夏庭，曾雄辉，等. 深埋隧洞 TBM掘进微震实时监测与特征分析[J]. 岩石力学与工程学报，2011，30(2)：275–283.(CHEN Bingrui，FENG Xiating，ZENG Xionghui，et al. Real-time microseismic monitoring and its characteristic analysis during tbm tunneling in deep-buried tunnel[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(2)：275–283.(in Chinese))
[19] 李建林，王乐华. 节理岩体卸荷非线性力学特性研究[J]. 岩石力学与工程学报，2007，26(10)：1 968–1 975.(LI Jianlin，WANG Lehua. Study on unloading nonlinear mechanical characteristics of jointed rock mass[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(10)：1 968–1 975.(in Chinese))
[20] 刘恺德. 采动条件下含瓦斯煤岩力学行为变异机制研究[博士学位论文][D]. 武汉：中国科学院武汉岩土力学研究所，2013.(LIU Kaide. Study on variation mechanism of mechanical behavior of coal containing gas under mining conditions[Ph. D. Thesis][D]. Wuhan：Wuhan Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，2013.(in Chinese))
[21] 朱杰兵. 高应力下岩石卸荷及其流变特性研究[博士学位论文][D]. 北京：中国科学院研究生院，2009.(ZHU Jiebing. Study on unloading mechanics and its rheological properties of rock under high stress[Ph. D. Thesis][D]. Beijing：Graduate School of Chinese Academy of Sciences，2009.(in Chinese))
[22] 邱士利，冯夏庭，张传庆，等. 不同卸围压速率下深埋大理岩卸荷力学特性试验研究[J]. 岩石力学与工程学报，2010，29(9)：1 807– 1 817.(QIU Shili，FENG Xiating，ZHANG Chuanqing，et al. Experimental research on mechanical properties of deep-buried marble under different unloading rates of confining pressures[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(9)：1 807–1 817. (in Chinese))
[23] 黄润秋，黄 达. 高地应力条件下卸荷速率对锦屏大理岩力学特性影响规律的试验研究[J]. 岩石力学与工程学报，2010，29(1)：21–33.(HUANG Runqiu，HUANG Da. Experimental research on affection laws of unloading rates on mechanical properties of Jinping marble under high geostress[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(1)：21–33.(in Chinese))
[24] 张 凯，周 辉，潘鹏志，等. 不同卸荷速率下岩石强度特性试验研究[J]. 岩土力学，2010，31(7)：2 072–2 078.(ZHANG Kai，ZHOU Hui，PAN Pengzhi，et al. Characteristics of strength of rocks under different unloading rates[J]. Rock and Soil Mechanics，2010，31(7)：2 072–2 078.(in Chinese))
[25] 尤明庆，华安增. 岩石试样的三轴卸围压试验[J]. 岩石力学与工程学报，1998，17(1)：24–29.(YOU Mingqing，HUA anzeng. Triaxial confining depressure test of rocks ample[J]. Chinese Journal of Rock Mechanics and Engineering，1998，17(1)：24–29.(in Chinese))
[26] LU X L，LIU Q S，SU P F. Deformation mechanism and support measures for stress-induced cracked rock mass of deep coal mine roadway[C]// International Symposium on Geomechanics and Geotechnics：From Micro to Macro. London：Taylor and Francis Group，2011：845–853.
[27] 伍向阳. 岩石的应力松弛、应变硬化和应变软化[J]. 地球物理学进展，1996，11(4)：71–76.(WU Xiangyang. Stress relaxation，strain hardening and strain softening in rocks[J]. Progress in Geophysics，1996，11(4)：71–76.(in Chinese)) |
|
|
|
2015, Vol. 34 
