川西须家河组致密砂岩高温后微组构特征及对力学性能的影响

doi:10.13722/j.cnki.jrme.2021.0135

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (21168 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Heat treatment，as a potential tight gas development technique，can improve the seepage capacity of tight sandstone，while will change the rock mechanical behaviors leading to the instability of well walls. In this paper，triaxial compression experiments were carried out on the tight sandstone samples from the Xujiahe Formation in western Sichuan at room temperature and after 100 ℃‐1 200 ℃ heat treatment，and the effects of the microfabric characteristics of tight sandstone after high temperature on the mechanical properties were explored combined with DTG，XRD and SEM. The results show that with increasing the temperature，the mechanisms of microcrack initiation and propagation present clay contracts due to water lose，lamellar illite dissection，cleavage surface separation of feldspar，microcracks propagation along the intergranular and forming a network，cracking and cambium forming lamellar cracks inside the particles. In the crack damage temperature range(400 ℃‐
1 000 ℃)，the specimen is more prone to failure under external forces，and the compaction and elastic stages expand. In the ranges of room temperature ‐200 ℃，300 ℃‐1 000 ℃ and 1 100 ℃‐1 200 ℃，mineral thermal expansion，thermal induced microcrack generation and expansion，sample glazing and other physical processes dominate the change of rock mechanical properties，respectively，leading to that the compressive strength and the elastic modulus first increase，then decrease and then rise again. After heat treatment at 400 ℃，the clay minerals lose interlayer water and shrink into pongy balls，resulting in abnormally high compressive strength and elastic modulus. The dehydration of chlorite at 800 ℃ increases the brittleness of the samples and inhibits the decrease of the elastic modulus.

Key words： rock mechanics tight sandstone heat treatment mechanical properties microfabric

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	ZHANG Yi1
	LI Gao1
	WANG Xiyong2
	CHEN Ze1
	LI Ze1
	WANG Rui1

Cite this article:

ZHANG Yi1,LI Gao1,WANG Xiyong2, et al. Microfabric characteristics of tight sandstone of Xujiahe formation in western Sichuan after high temperature and the effect on mechanical properties[J]. , 2021, 40(11): 2249-2259.

URL:

http://rockmech.whrsm.ac.cn/EN/10.13722/j.cnki.jrme.2021.0135 OR http://rockmech.whrsm.ac.cn/EN/Y2021/V40/I11/2249

[28]	马阳升. 实时高温作用下岩石力学特性实验研究[硕士学位论文][D]. 徐州：中国矿业大学，2018.(MA Yangsheng. Experimental study on mechanical properties of rock under real-time high temperature[M. S. Thesis][D]. Xuzhou：China University of Mining and Technology，2018.(in Chinese))
[36]	顾琢如. 熔制高铅光学玻璃黏土坩埚的试制生产[J]. 光学机械，1980，(5)：7-15.(GU Zhuoru. Trial-production of molten high lead optical glass clay crucible[J]. Optics and Precision Engineering，1980，(5)：7-15.(in Chinese))
[38]	李存宝，谢和平，谢凌志. 页岩起裂应力和裂纹损伤应力的试验及理论[J]. 煤炭学报，2017，42(4)：969-976.(LI Cunbao，XIE Heping，XIE Lingzhi. Experimental and theoretical study on the shale crack initiation stress and crack damage stress[J]. Journal of China Coal Society，2017，42(4)：969-976.(in Chinese))
[26]	ZHOU Y，CHEN W，LEI Y F. Combustion characteristics of tight sandstone[J]. Energy and Fuels，2018，32(5)：6 293-6 299.
[3]	戢俊文. 微波加热解除低渗透砂岩气层水锁损害的可行性研究[硕士学位论文][D]. 成都：西南石油大学，2007.(JI Junwen. Feasibility study on removing water locking damage of low permeability sandstone gas layer by microwave heating[M. S. Thesis][D]. Chengdu：Southwest Petroleum University，2007.(in Chinese))
[1]	李皋，孟英峰，唐洪明，等. 低渗透致密砂岩水锁损害机制及评价技术[M]. 成都：四川科学技术出版社，2012：2-6.(LI Gao，MENG Yingfeng，TANG Hongming，et al. Water locking damage mechanism and evaluation technology of low permeability tight sandstone[M]. Chengdu：Sichuan Science and Technology Press，2012：2-6.(in Chinese))
[4]	WANG H C，REZAEE R，SAEEDI A，et al. Numerical modelling of microwave heating treatment for tight gas sand reservoirs[J]. Journal of Petroleum Science and Engineering，2017，152：495-504.
[2]	LI G，MENG Y F，DONG Z X，et al. Mechanisms and significance of microfractures generated by microwave heating in sandstone reservoirs[J]. Petroleum Exploration and Development，2007，34(1)：93-97.
[6]	苏承东，韦四江，秦本东，等. 高温对细砂岩力学性质影响机制的试验研究[J]. 岩土力学，2017，38(3)：623-630.(SU Chengdong，WEI Sijiang，QIN Bendong，et al. Experimental study on the influence mechanism of high temperature on mechanical properties of fine sandstone[J]. Rock and Soil Mechanics，2017，38(3)：623-630.(in Chinese))
[8]	LI Z，FORTIN J，NICOLAS A，et al. Physical and mechanical properties of thermally cracked andesite under pressure[J]. Rock Mechanics and Rock Engineering，2019，52：3 509-3 529.
[11]	吴刚，翟松韬，王宇. 高温下花岗岩的细观结构与声发射特性研究[J]. 岩土力学，2015，36(增1)：351-356.(WU Gang，ZHAI Songtao，WANG Yu. Research on characteristics of mesostructure and acoustic emission of granite under high temperature[J]. Rock and Soil Mechanics，2015，36(Supp.1)：351-356.(in Chinese))
[12]	CHEN Y L，NI J，SHAO W，et al. Experimental study on the influence of temperature on the mechanical properties of granite under uniaxial compression and fatigue loading[J]. International Journal of Rock Mechanics and Mining Sciences，2012，56：62-66.
[14]	PENG J，RONG G，TANG Z，et al. Microscopic characterization of microcrack development in marble after cyclic treatment with high temperature[J]. Bulletin of Engineering Geology and the Environment，2019，78(8)：5 965-5 976.
[29]	张莉，王威，舒志国，等. 川东北元坝地区须家河组钙质交代—胶结致密层分布与成因[J]. 石油学报，2019，40(6)：692-705.(ZHANG Li，WANG Wei，SHU Zhiguo，et al. Primary geochemical characteristics and geochemical characteristics of the Xujiahe formation in Shandong province[J]. Acta Petrolei Sinica，2019，40(6)：692-705.(in Chinese))
[31]	李皋，孟英峰，董兆雄，等. 砂岩储集层微波加热产生微裂缝的机制及意义[J]. 石油勘探与开发，2007，34(1)：93-97.(LI Gao，MENG Yingfeng，DONG Zhaoxiong，et al. Mechanism and significance of microfractures generated by microwave heating in sandstone reservoirs[J]. Petroleum Exploration and Development，2007，34(1)：93-97.(in Chinese))
[32]	LI G，MENG Y F，TANG H M，et al. Clean up water blocking in gas reservoirs by microwave heating：laboratory studies[C]// The International Oil and Gas Conference and Exhibition. Beijing：[s. n.]，2006：SPE-101072-MS.
[34]	高平，刘若新，马宝林，等. 绿泥石片岩和斜长角闪岩在高温高压下的物理力学性质及其应用[J]. 地震地质，1994，16(1)：83-88.(GAO Ping，LIU Ruoxin，MA Baolin，et al. The physical and mechanical properties of chlorite-schist and plagiochase amphibolite at high P T conditions and its application[J]. Seismology and Geology，1994，16(1)：83-88.(in Chinese))
[39]	于鑫，李皋，陈泽，等. 川西须家河组致密砂岩高温后的物理力学特征参数实验研究[J]. 地质力学学报，2021，27(1)：1-9.(YU Xin，LI Gao，CHEN Ze，et al. Experimental study on physical and mechanical characteristic parameters of tight sandstone in Xujiahe Formation after high temperature[J]. Journal of Geomechanics，2021，27(1)：1-9.(in Chinese))
[41]	杨永明，鞠杨，陈佳亮，等. 温度作用对孔隙岩石介质力学性能的影响[J]. 岩土工程学报，2013，35(5)：856-864.(YANG Yongming，JU Yang，CHEN Jialiang，et al. Influence of temperature action on mechanical properties of porous rock media[J]. Chinese Journal of Geotechnical Engineering，2013，35(5)：856-864.(in Chinese))
[42]	ZHANG F，ZHAO J，HU D，et al. Laboratory investigation on physical and mechanical properties of granite after heating and water-cooling treatment[J]. Rock Mechanics and Rock Engineering，2018，(51)：677-694.
[44]	张连英. 高温作用下泥岩的损伤演化及破裂机制研究[博士学位论文][D]. 徐州：中国矿业大学，2012.(ZHANG Lianying. Research on Damage Evolution and Fracture Mechanisms of Mudstone under High Temperature[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，2012.(in Chinese))
[9]	KEANEY G M，JONES C，MEREDITH P，et al. Thermal damage and the evolution of crack connectivity and permeability in ultra-low permeability rocks[C]// The 6th North America Rock Mechanics Symposium. Houston：[s. n.]，2004：ARMA-04-537.
[16]	SIRDESAI N N，SINGH T N，PATHEGAMA G R. Thermal alterations in the poro-mechanical characteristic of an Indian sandstone-A comparative study[J]. Engineering Geology，2017，226(30)：208-220.
[18]	郤保平，吴阳春，王帅，等. 青海共和盆地花岗岩高温热损伤力学特性试验研究[J]. 岩石力学与工程学报，2020，39(1)：69-83.(XI Baoping，WU Yangchun，WANG Shuai，et al. The experimental study on mechanical properties of granite under high temperature and thermal damage in Gonghe Basin，Qinghai Province[J]. Chinese Journal of Rock Mechanics and Engineering，2020，39(1)：69-83.(in Chinese))
[19]	赵阳升，万志军，张渊，等. 20 MN伺服控制高温高压岩体三轴试验机的研制[J]. 岩石力学与工程学报，2008，27(1)：1-8.(ZHAO Yangsheng，WAN Zhijun，ZHANG Yuan，et al. Research and development of 20 MN servo-controlled rock triaxial testing system with high temperature[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(1)：1-8.(in Chinese))
[21]	阴伟涛，赵阳升，冯子军. 高温三轴应力下粗、细粒花岗岩力学特性研究[J]. 太原理工大学学报，2020，51(5)：5-11.(YIN Weitao，ZHAO Yangsheng，FENG Zijun. Study on the mechanical properties of coarse-grained and fine-grained granite under high temperature triaxial stress[J]. Journal of Taiyuan University of technology，2020，51(5)：5-11.(in Chinese))
[22]	李皋，陈泽，张毅，等. 高温电加热提高水锁损害致密砂岩渗透率实验研究[C]// 2018年全国天然气学术年会论文集. 福州：[s. n.]，2018：200-206.(LI Gao，CHEN Ze，ZHANG Yi，et al. Experimental study on improving permeability of tight sandstone damaged by water lock by high temperature electric heating[C]// Proceedings of 2018 National Natural Gas Academic Annual Conference. Fuzhou：[s. n.]，2018：200-206.(in Chinese))
[24]	LI C，HU Y Q，MENG T，et al. Experimental study of the influence of temperature and cooling method on mechanical properties of granite：Implication for geothermal mining[J]. Energy Science and Engineering，2020，8(5)：1 716-1 728.
[7]	赵怡晴，吴常贵，金爱兵，等. 热处理砂岩微观结构及力学性质试验研究[J]. 岩土力学，2020，41(7)：2 233-2 240.(ZHAO Yiqing，WU Changgui，JIN Aibing，et al. Experimental study on microstructure and mechanical properties of heat-treated sandstone[J]. Rock and Soil Mechanics，2020，41(7)：2 233-2 240.(in Chinese))
[17]	TIAN H，ZIEGLER M，KEMPKA T. Physical and mechanical behavior of claystone exposed to temperatures up to 1 000 ℃[J]. International Journal of Rock Mechanics and Mining Sciences，2014，70：144-153.
[27]	于鑫，李皋，陈泽. 致密砂岩加热过程单轴抗压强度变化[J]. 科学技术与工程，2019，19(32)：133-138.(YU Xin，LI Gao，CHEN Ze. Uniaxial compressive strength variation of tight sandstone during heating[J]. Science Technology and Engineering，2019，19(32)：133-138.(in Chinese))
[37]	王恩元，熊樱菲，吴婧玮，等. 古陶瓷釉面析晶的研究[J]. 陶瓷学报，2019，40(2)：239-246.(WANG Enyuan，XIONG Yingfei，WU Jingwei，et al. Crystallization of Ancient Porcelain Glaze[J]. Journal of Ceramics，2019，40(2)：239-246.(in Chinese))
[5]	KIM T W，ROSS C M，GUAN K. Permeability and porosity evolution of organic rich shales as a result of heating[C]// SPE195366，2019：1-43.
[15]	YU Q L，RANJITH P G，LIU H Y，et al. A mesostructure-based damage model for thermal cracking analysis and application in granite at elevated temperatures[J]. Rock Mechanics and Rock Engineering，2015，48(6)：2 263-2 282.
[25]	MAHANTA B，RANJITH P G，VISHAL V，et al. Temperature- induced deformational responses and microstructural alteration of sandstone[J]. Journal of Petroleum Science and Engineering，2020，192：107239.
[35]	张芳，聂东娥，霍明鹤，等. 钾长石对CO还原铁氧化物过程还原膨胀性的影响[J]. 钢铁研究学报，2020，32(11)：958-967.(ZHANG Fang，NIE Donge，HUO Minghe，et al. Effect of potassium feldspar on swelling behavior of iron oxide during CO reduction process[J]. Journal of Iron and Steel Research，2020，32(11)：958-967.(in Chinese))
[45]	ZHOU W，BANERJEE R，POE B，et al. Semianalytical production simulation of complex hydraulic-fracture networks[J]. SPE Journal，2014，19(1)：6-18.
[10]	LI M，WANG D M，SHAO Z L. Experimental study on changes of pore structure and mechanical properties of sandstone after high-temperature treatment using nuclear magnetic resonance[J]. Engineering Geology，2020，275：105739.
[13]	ERSOY H，KOLAYLI H，KARAHAN M，et al. Effect of thermal damage on mineralogical and strength properties of basic volcanic rocks exposed to high temperatures[J]. Bulletin of Engineering Geology and the Environment，2019，78(3)：1 515-1 525.
[23]	赵亚永，魏凯，周佳庆，等. 三类岩石热损伤力学特性的试验研究与细观力学分析[J]. 岩石力学与工程学报，2017，36(1)：142-151.(ZHAO Yayong，WEI Kai，ZHOU Jiaqing，et al. Laboratory study and micromechanical analysis of mechanical behaviors of three thermally damaged rocks[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(1)：142-151.(in Chinese))
[33]	邱国清. 储层敏感性机制及防治对策研究[J]. 中外能源，2014，19(6)：47-50.(QIU Guoqing. Study on the mechanism of reservoir sensitivity and countermeasures[J]. Sino-Global Energy，2014，19(6)：47-50.(in Chinese))
[43]	KUMARI W G P，RANJITH P G，PERERA M S A，et al. Mechanical behaviour of Australian Strathbogie granite under in-situ stress and temperature conditions：an application to geothermal energy extraction[J]. Geothermics，2017，(65)：44-59.
[20]	郤保平，赵阳升. 高温高压下花岗岩中钻孔围岩的热物理及力学特性试验研究[J]. 岩石力学与工程学报，2010，29(6)：1 245-1 253. (XI Baoping，ZHAO angsheng. Experimental study of thermophysico- mechanical property of drilling surrounding rock in granite under high temperature and high pressure[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(6)：1 245-1 253.(in Chinese))
[30]	吐洪江，韩国生，田野，等. 岩石热解热失重法计算砂岩储集层含油饱和度[J]. 录井工程，2013，24(3)：16-18.(TU Hongjiang，HAN Guosheng，TIAN Ye，et al. Calculation of oil saturation of sandstone reservoir by thermal weight loss method during rock pyrolysis[J]. Logging Engineering，2013，24 (3)：16-18.(in Chinese))
[40]	XU X，XU W，GUO Q F，et al. Experimental investigation and numerical simulation on the crack initiation and propagation of rock with pre-existing cracks[J]. IEEE Access，2020，PP(99)：1-12.