长期水浸作用下煤样渐进破坏特征及损伤本构模型

doi:10.13722/j.cnki.jrme.2023.0495

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (2703 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Water-rock interaction is an essential factor in the weakening of coal rock masses. Long-term immersion as a type of water-rock interaction is widespread in mining engineering and shaft engineering. The progressive damage characterization of coal samples during long-term immersion is obtained by a uniaxial compression experiment. The relationship between mechanical parameters and saturation and immersion time is established，and the macroscopic fracture extension characteristic of coal samples are analyzed. The results show that the soaking process of coal samples can be divided into two stages：unsaturated immersion and long-term(saturated) immersion. The peak stress in coal samples decreases by 46.3% and 34.5% in the unsaturated stage and long-term immersion stage，respectively，which conforms to the exponentially decreasing trend. During long-term immersion，the number of macroscopic cracks produced in coal samples after loading gradually decreases from 6–8 in a dry to 2–3 in a 360 d soaked. The damage mode changes from combined tensile and shear damage for unsaturated coal samples to single shear damage for 360 d soaked coal samples. Based on initial compression characteristics and critical damage strength characteristics in a coal sample，a damage constitutive model describing the whole deformation process of a coal sample under long-term immersion is proposed using continuous damage mechanics and statistical damage theory. According to this model，it can be found that the initial damage increases gradually from 0 in a dry sample to 0.773 for a soaked 360 d sample with the increase of soaking time. In addition，the error and fit between model curves and the experimental data are evaluated by introducing the root mean square error(RMSE) and the coefficient of determination(R2). The theoretical curves of the improved model are found to be the highest matching with the experimental data. The maximum value of RMSE and the minimum value of R2 for the improved model are 1.81 and 0.76，respectively，which are better than the models proposed in existing papers.

Key words： mining engineering coal long-term immersion characteristic stress strain difference damage constitutive model

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	HAN Penghua1
	2
	ZHAO Yixin1
	2
	GAO Sen1
	2
	GAO Yirui1
	2
	ZHANG Cun1
	2
	HU Yong3

Cite this article:

HAN Penghua1,2,ZHAO Yixin1, et al. Progressive damage characteristics and damage constitutive model of coal samples under long-term immersion[J]. , 2024, 43(4): 918-933.

URL:

http://rockmech.whrsm.ac.cn/EN/10.13722/j.cnki.jrme.2023.0495 OR http://rockmech.whrsm.ac.cn/EN/Y2024/V43/I4/918

[27]	LIU Y，DAI F. A damage constitutive model for intermittent jointed rocks under cyclic uniaxial compression[J]. International Journal of Rock Mechanics Mining Sciences，2018，103(1)：289-301.
[31]	贾蓬，毛松泽，孙占阳，等. 冻融损伤砂岩的能量演化及分段本构模型[J]. 中南大学学报：自然科学版，2023，54(3)：908-919.(JIA Peng，MAO Songze，SUN Zhanyang，et al. Energy evolution and piecewise constitutive model of freeze-thaw damaged sandstone[J]. Journal of Central South University：Science and Technology，2023，54(3)：908-919.(in Chinese))
[33]	XU X，GAO F，ZHANG Z. Thermo-mechanical coupling damage constitutive model of rock based on the Hoek-Brown strength criterion[J]. International Journal of Damage Mechanics，2018，27(8)：1 213-1 230.
[8]	楚亚培，张东明，杨瀚，等. 液氮冻结和冻融循环作用下煤样力学特性试验研究[J]. 煤炭科学技术，2023，51(5)：82-92.(CHU Yapei，ZHANG Dongming，YANG Han，et al. Study on evolution law of mechanical properties of coal samples subjected to freezing and freeze-thaw cycles of liquid nitrogen[J]. Coal Science and Technology，2023，51(5)：82-92.(in Chinese))
[18]	LIU Y，YIN G，LI M，et al. Mechanical properties and failure behavior of dry and water-saturated anisotropic coal under true-triaxial loading conditions[J]. Rock Mechanics and Rock Engineering，2019，53(11)：1-20.
[2]	张村，韩鹏华，王方田，等. 采动水浸作用下矿井地下水库残留煤柱稳定性[J]. 中国矿业大学学报，2021，50(2)：220-227. (ZHANG Cun，HAN Penghua，WANG Fangtian，et al. Study on mechanical properties and damage constitutive model of shale under hydro-mechanical coupling[J]. Journal of China University of Mining and Technology，2021，50(2)：220-227.(in Chinese))
[12]	刘新喜，李玉，王玮玮，等. 干湿循环作用下预制裂隙炭质页岩力学特性及强度准则研究[J]. 岩石力学与工程学报，2022，41(2)：228-239.(LIU Xinxi，LI Yu，WANG Weiwei，et al. Research on mechanical properties and strength criterion of carbonaceous shale with pre-existing fissures under drying-wetting cycles[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(2)：228-239.(in Chinese))
[22]	孟凡东，翟越，李宇白，等. 冻融循环作用后砂岩的动态抗拉性能及能量演化试验研究[J]. 岩石力学与工程学报，2021，40(12)：2 445-2 453.(MENG Fandong，ZHAI Yue，LI Yubai，et al. Experimental study on dynamic tensile properties and energy evolution of sandstone after freeze-thaw cycles[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(12)：2 445-2 453.(in Chinese))
[32]	曹文贵，赵衡，李翔，等. 基于残余强度变形阶段特征的岩石变形全过程统计损伤模拟方法[J]. 土木工程学报，2012，45(6)：139-145.(CAO Wengui，ZHAO Heng，LI Xiang，et al. A statistical damage simulation method for rock full deformation process with consideration of the deformation characteristics of residual strength phase[J]. China Civil Engineering Journal，2012，45(6)：139-145.(in Chinese))
[42]	姚强岭，王伟男，杨书懿，等. 含水率影响下砂质泥岩直剪特性及声发射特征[J]. 煤炭学报，2021，46(9)：2 910-2 922.(YAO Qiangling，WANG Weinan，YANG Shuyi，et al. A statistical damage simulation method for rock full deformation process with consideration of the deformation characteristics of residual strength phase[J]. Journal of China Coal Society，2021，46(9)：2 910-2 922.(in Chinese))
[3]	顾大钊. 煤矿地下水库理论框架和技术体系[J]. 煤炭学报，2015，40(2)：239-246.(GU Dazhao. Study on mechanical properties and damage constitutive model of shale under hydro-mechanical coupling[J]. Journal of China Coal Society，2015，40(2)：239-246.(in Chinese))
[1]	刘世奇，张村，曾一凡，等. 蓄水采空区区段煤柱采动水浸弱化机制与失稳特征[J]. 采矿与安全工程学报，2022，39(6)：1 084- 1 094.(LIU Shiqi，ZHANG Cun，ZENG Yifan，et al. Weakening mechanism and instability characteristics of coal pillar under mining disturbance and water immersion in water storage goaf[J]. Journal of Mining and Safety Engineering，2022，39(6)：1 084-1 094.(in Chinese))
[4]	顾大钊，颜永国，张勇，等. 煤矿地下水库煤柱动力响应与稳定性分析[J]. 煤炭学报，2016，41(7)：1 589-1 597.(GU Dazhao，YAN Yongguo，ZHANG Yong，et al. Study on mechanical properties and damage constitutive model of shale under hydro-mechanical coupling[J]. Journal of China Coal Society，2016，41(7)：1 589-1 597.(in Chinese))
[6]	孙文洁，任顺利，武强，等. 新常态下我国煤矿废弃矿井水污染防治与资源化综合利用[J]. 煤炭学报，2022，47(6)：2 161-2 169. (SUN Wenjie，REN Shunli，WU Qiang，et al. Waterpollution?s prevention and comprehensive utilization of abandoned coal mines in China under the new normal life[J]. Journal of China Coal Society，2022，47(6)：2 161-2 169.(in Chinese))
[7]	AI T，WU S，ZHANG R，et al. Changes in the structure and mechanical properties of a typical coal induced by water immersion[J]. International Journal of Rock Mechanics Mining Sciences，2021，138(1)：104597.
[5]	谢和平，侯正猛，高峰，等. 煤矿井下抽水蓄能发电新技术：原理、现状及展望[J]. 煤炭学报，2015，40(5)：965-972.(XIE Heping，HOU Zhengmeng，GAO Feng，et al. Study on mechanical properties and damage constitutive model of shale under hydro-mechanical coupling[J]. Journal of China Coal Society，2015，40(5)：965-972.(in Chinese))
[11]	YAO Q，CHEN T，TANG C，et al. Influence of moisture on crack propagation in coal and its failure modes[J]. Engineering Geology，2019，258(1)：105156.
[13]	SONG M，HU Q，LI Q，et al. Effects of damage on resistivity response and volatility of water-bearing coal[J]. Fuel，2022，324(1)：124553.
[14]	YAO Q，CHEN T，JU M，et al. Effects of water intrusion on mechanical properties of and crack propagation in coal[J]. Rock Mechanics and Rock Engineering，2016，49(12)：4 699-4 709.
[15]	CHEN S，JIANG T，WANG H，et al. Influence of cyclic wetting‐drying on the mechanical strength characteristics of coal samples：A laboratory‐scale study[J]. Energy Science and Engineering，2019，7(6)：3 020-3 037.
[17]	SUN X，XU H，ZHENG L，et al. An experimental investigation on acoustic emission characteristics of sandstone rockburst with different moisture contents[J]. Science China-Technological Sciences，2016，59(10)：1 549-1 558.
[21]	宋彦琦，马宏发，刘济琛，等. 冻融灰岩单轴声发射损伤特性试验研究[J]. 岩石力学与工程学报，2022，41(增1)：2 603-2 614.(SONG Yanqi，MA Hongfa，LIU Jichen，et al. Experimental investigation on the damage characteristics of freeze-thaw limestone by the uniaxial compression and acoustic emission monitoring tests[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(Supp.1)：2 603-2 614. (in Chinese))
[23]	HAN P，ZHAO Y，ZHANG C，et al. Effects of water on mechanical behavior and acoustic emission characteristics of coal in Brazilian tests[J]. Theoretical and Applied Fracture Mechanics，2022，122(1)：103636.
[24]	夏冬，杨天鸿，徐涛，等. 浸水时间对饱水岩石损伤破坏过程中声发射特征影响的试验[J]. 煤炭学报，2015，40(增2)：337-345.(XIA Dong，YANG Tianhong，XU Tao，et al. Experimental study on AE properties during the damage process of water-saturated rock specimens based on time effect[J]. Journal of China Coal Society，2015，40(Supp.2)：337-345.(in Chinese))
[25]	HU Q，ZHANG Y，LI Q，et al. Experimental research on progressive failure characteristics of water-immersed coal：Implications for hydraulic fracturing[J]. Engineering Geology，2022，308(1)：106809.
[9]	YU L，YAO Q，CHONG Z，et al. Mechanical and micro-structural damage mechanisms of coal samples treated with dry-wet cycles[J]. Engineering Geology，2022，304(1)：106637.
[28]	刘保国，于明圆，孙景来，等. 水-力耦合作用下页岩力学特性及其损伤本构模型研究[J]. 岩石力学与工程学报，2023，42(5)：1 041-1 054.(LIU Baoguo，YU Mingyuan，SUN Jinglai，et al. Study on mechanical properties and damage constitutive model of shale under hydro-mechanical coupling[J]. Chinese Journal of Rock Mechanics and Engineering，2023，42(5)：1 041-1 054.(in Chinese))
[35]	BIAN K，LIU J，ZHANG W，et al. Mechanical behavior and damage constitutive model of rock subjected to water-weakening effect and uniaxial loading[J]. Rock Mechanics and Rock Engineering，2019，52(1)：97-106.
[37]	TANG M，WANG G，CHEN S，et al. An objective crack initiation stress identification method for brittle rock under compression using a reference line[J]. Rock Mechanics and Rock Engineering，2021，54(8)：4 283-4 298.
[38]	JIANG W，LAI Y，MA Q，et al. Mechanical damage model and brittleness index of frozen rocks based on statistical damage theory[J]. Acta Geotechnica，2023，18(9)：4 687-4 713.
[41]	朱珍德，邢福东，王思敬，等. 地下水对泥板岩强度软化的损伤力学分析[J]. 岩石力学与工程学报，2004，23(增2)：4 739-4 743. (ZHU Zhende，XING Fudong，WANG Sijing，et al. Analysis of strength softening of argillite under groundwater by damage mechanics[J]. Chinese Journal of Rock Mechanics and Engineering，2004，23(Supp.2)：4 739-4 743.(in Chinese))
[45]	翁磊，张皓量，张勇，等. 低温下饱水粉砂岩的动态力学特性及本构模型研究[J]. 应用力学学报，2022，39(6)：1 096-1 107. (WENG Lei，ZHANG Haoliang，ZHANG Yong，et al. Energy evolution and piecewise constitutive model of freeze-thaw damaged sandstone[J]. Chinese Journal of Applied Mechanics，2022，39(6)：1 096-1 107.(in Chinese))
[10]	YAO Q，TANG C，XIA Z，et al. Mechanisms of failure in coal samples from underground water reservoir[J]. Engineering Geology，2020，267(1)：105494.
[16]	HAN P，ZHAO Y，ZHANG C，et al. Progressive damage characteristic and microscopic weakening mechanism of coal under long-term soaking[J]. Rock Mechanics and Rock Engineering，2023，56(11)：7 861-7 881.
[20]	TANG C，YAO Q，XU Q，et al. Mechanical failure modes and fractal characteristics of coal samples under repeated drying-saturation conditions[J]. Natural Resources Research，2021，30(6)：4 439-4 456.
[30]	赵洪宝，吉东亮，刘绍强，等. 冲击荷载下复合岩体动力响应力学特性及本构模型研究[J]. 岩石力学与工程学报，2023，42(1)：88-99.(ZHAO Hongbao，JI Dongliang，LIU Shaoqiang，et al. Study on dynamic response and constitutive model of composite rock under impact loading[J]. Chinese Journal of Rock Mechanics and Engineering，2023，42(1)：88-99.(in Chinese))
[40]	XIE N，TANG H，YANG J，et al. Damage evolution in dry and saturated brittle sandstone revealed by acoustic characterization under uniaxial compression[J]. Rock Mechanics and Rock Engineering，2021，55(3)：1 303-1 324.
[19]	HAN P，ZHANG C，WANG X，et al. Study of mechanical characteristics and damage mechanism of sandstone under long-term immersion[J]. Engineering Geology，2023，315(1)：107020.
[26]	曹文贵，林星涛，张超，等. 基于非线性动态强度准则的岩石动态变形过程统计损伤模拟方法[J]. 岩石力学与工程学报，2017，36(4)：794-802.(CAO Wengui，LIN Xingtao，ZHANG Chao，et al. A statistical damage simulation method of dynamic deformation process for rocks based on nonlinear dynamic strength criterion[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(4)：794-802.(in Chinese))
[36]	李桂臣，李菁华，孙元田，等. 泥岩多尺度模型与水岩作用特性研究进展[J]. 煤炭学报，2022，47(3)：1 138-1 154.(LI Guichen，LI Jinghua，SUN Yuantian，et al. Advance of multi-scale study on both analytic models and water-rock interaction characteristics of mudstone[J]. Journal of China Coal Society，2022，47(3)：1 138-1 154. (in Chinese))
[29]	张慧梅，孟祥振，彭川，等. 冻融-荷载作用下基于残余强度特征的岩石损伤模型[J]. 煤炭学报，2019，44(11)：3 404-3 411. (ZHANG Huimei，MENG Xiangzhen，PENG Chuan，et al. Rock damage constitutive model based on residual intensity characteristics under freeze-thaw and load[J]. Journal of China Coal Society，2019，44(11)：3 404-3 411.(in Chinese))
[39]	JIANG W，LAI Y，YU F，et al. Mechanical properties investigation and damage constitutive models of red sandstone subjected to freeze-thaw cycles[J]. Cold Regions Science and Technology，2023，207(1)：103776.
[34]	ZHA F，HUANG K，KANG B，et al. Deterioration characteristic and constitutive model of red-bed argillaceous siltstone subjected to drying-wetting cycles[J]. Lithosphere，2022，2022(1)：8786210.
[44]	LIU X，NING J，TAN Y，et al. Damage constitutive model based on energy dissipation for intact rock subjected to cyclic loading[J]. International Journal of Rock Mechanics and Mining Sciences，2016，85(1)：27-32.
[43]	LI H，QIAO Y，HE M，et al. Effect of water saturation on dynamic behavior of sandstone after wetting-drying cycles[J]. Engineering Geology，2023，319(1)：107105.