液氮压裂作用下页岩破裂特征试验研究

doi:10.13722/j.cnki.jrme.2020.0202

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (238929 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要液氮压裂作为一种新型无水压裂方法，有望为页岩气高效开发提供一条新途径。为揭示液氮压裂作用下页岩破裂特征，利用自主研制的试验装置开展了液氮压裂试验，获得不同初始温度及液氮处理方式下页岩的破裂压力及裂缝形态，在此基础上探讨液氮压裂对页岩的致裂机制，进而提出一种新的液氮压裂方法。研究表明，超低温液氮产生的热冲击效应会对页岩破裂压力及破裂模式造成显著影响，当页岩温度从室温(25 ℃)升高至80 ℃和150 ℃时，破裂压力分别降低22.58%和32.26%，破裂模式从室温状态下的沿初始弱面破坏转变成沿孔眼轴线的拉张破坏。经液氮低温处理页岩的破裂模式以随机分布的局部裂缝为主，局部裂缝的复杂性随页岩初始温度的升高而增大。在液氮低温冷冻状态下，由于页岩的渗透性的增大，在压裂过程中岩样表面出现了严重的漏气现象，破裂模式转变为开度较小的局部裂缝。液氮低温冷冻会导致页岩破裂压力升高，但能够降低流体进入页岩的难度，有利于页岩内压力的传递。液氮压裂可对页岩储层产生热冲击、低温损伤、冷冻开裂和压力致裂多重致裂效应，建议采用氮气压裂–液氮冷冻交替作业的施工方式，以充分发挥液氮的低温冷冻作用。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	蔡承政1
	2
	任科达1
	2
	杨玉贵1
	胡国忠3

关键词 ：岩石力学, 页岩, 液氮压裂, 破裂特征, 裂缝形态

Abstract：Liquid nitrogen(LN) fracturing，as a novel waterless fracturing technology，is expected to provide a new approach for shale gas development. To reveal the cracking characteristics of shale due to LN fracturing， laboratory simulation experiments were performed on shale samples utilizing a self-designed experimental apparatus. The effects of shale initial temperature and LN treatment on cracking characteristics and fracture pattern of shale were researched，and the shale cracking mechanism induced by LN fracturing was explored. Finally，a novel fracturing technology with LN was proposed based on the experimental results. The investigations show that the thermal shock induced by LN remarkably affects the breakdown pressure and the cracking mode of shale. As the shale temperature increases from room temperature(25 ℃) to 80 ℃ and 150 ℃，the breakdown pressure decreases by 22.58% and 32.26%，respectively. During LN fracturing experiments，the samples at room temperature were fractured along the original weak plane，whilethe cracking mode of 80 ℃ and 150 ℃ samples transforms to tensile rupture along the borehole axis. For LN cool-treated samples，the cracking mode mainly presents in the form of local fractures，whose complexity increases with the sample initial temperature. For the samples under LN cooling condition，the obvious gas leakage phenomenon was observed on the sample surface due to the increase of the permeability of shale. The cracking mode of the samples under LN cooling condition transforms to local fracture with low aperture. Under LN cooling condition，the breakdown pressure increases compared with original samples. However，the re-open of existing cracks induced by LN cooling could make the fluid permeate into the shale more easily，which is beneficial to the pressure transmission. The multiple cracking effect on shale can be generated by LN fracturing，including thermal shock，cryogenic damage，low-temperature cracking and pressure-induced cracking. The alternate treatment of gaseous nitrogen fracturing and LN cooling was proposed to make full use of the low-temperature cooling effect of LN.

Key words： rock mechanics shale liquid nitrogen(LN) fracturing cracking characteristics fracture pattern

引用本文:

蔡承政1，2，任科达1，2，杨玉贵1，胡国忠3. 液氮压裂作用下页岩破裂特征试验研究[J]. 岩石力学与工程学报, 2020, 39(11): 2183-2203.
CAI Chengzheng1，2，REN Keda1，2，YANG Yugui1，HU Guozhong3. Experimental research on shale cracking characteristics due to liquid nitrogen fracturing. , 2020, 39(11): 2183-2203.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2020.0202 或 http://rockmech.whrsm.ac.cn/CN/Y2020/V39/I11/2183

[26]	TRAN D，SETTARI A，NGHIEM L. Initiation and propagation of secondary cracks in thermo-poroelastic media[R]. [S. l.]：[s. n.]，2012.
[38]	ALQATAHNI N B，CHA M，YAO B，et al. Experimental investigation of cryogenic fracturing of rock specimens under true triaxial confining stresses[R]. SPE180071，2016.
[41]	WU X，HUANG Z，LI G，et al. Experiment on coal breaking with cryogenic nitrogen jet[J]. Journal of Petroleum Science and Engineering，2018，169：405-415.
[10]	LEBLANC D P，MARTEL T，GRAVES D G，et al. Application of propane(LPG) based hydraulic fracturing in the McCully gas field，New Brunswick，Canada[R]. SPE 144093，2011.
[28]	ENAYATPOUR S，PATZEK T. Thermal shock in reservoir rock enhances the hydraulic fracturing of gas shales[R]. SPE 168936，URTeC1620617，2013.
[1]	戴金星，秦胜飞，胡国艺，等. 新中国天然气勘探开发70年来的重大进展[J]. 石油勘探与开发，2019，46(6)：1 037-1 046.(DAI Jinxing，QIN Shengfei，HU Guoyi，et al. Major progress in the natural gas exploration and development in the past seven decades in China[J]. Petroleum Exploration and Development，2019，46(6)：1 037-1 046.(in Chinese))
[4]	KING G E. Hydraulic fracturing 101：What every representative，environmentalist，regulator，reporter，investor，university researcher，neighbor and engineer should know about estimating frac risk and improving frac performance in unconventional gas and oil wells[R]. SPE 152596，2012.
[6]	BRANTLEY S L，YOXTHEIMER D，ARJMAND S，et al. Water resource impacts during unconventional shale gas development：The Pennsylvania experience[J]. International Journal of Coal Geology，2014，126(Supp.1)：140-156.
[13]	王海柱，沈忠厚，李根生. 超临界CO2开发页岩气技术[J]. 石油钻探技术，2011，39(3)：30-35.(WANG Haizhu，SHEN Zhouhou，LI Gensheng. Feasibility analysis on shale gas exploitation with supercritical CO2[J]. Petroleum Drilling Techniques，2011，39(3)：30-35.(in Chinese))
[19]	徐红芳. 适用于页岩气开发的液化氮气汽化压裂技术[硕士学位论文][D]. 秦皇岛：燕山大学，2013.(XU Hongfang. Liquid nitrogen gasification fracturing technology applicable to shale gas development[M. S. Thesis][D]. Qinhuangdao：Yanshan University，2013.(in Chinese))
[22]	PERKINS T D，GONZALEZ J A. The effect of thermoelastic stresses on injection well fracturing[J]. SPE Journal，1985，25(1)：78-88.
[24]	WANG Y，DUSSEAULT M B. A coupled conductive-convective thermo-poroelastic solution and implications for wellbore stability[J]. Journal of Petroleum Science and Engineering，2003，38(3/4)：187-198.
[30]	CAI C，LI G，HUANG Z，et al. Experimental study of the effect of liquid nitrogen cooling on rock pore structure[J]. Journal of Natural Gas Science and Engineering，2014，21：507-517.
[32]	CAI C，LI G，HUANG Z，et al. Experiment of coal damage due to super-cooling with liquid nitrogen[J]. Journal of Natural Gas Science and Engineering，2015，(22)：42-48.
[34]	ZHAI C，QIN L，LIU S，et al. Pore structure in coal：Pore evolution after cryogenic freezing with cyclic liquid nitrogen injection and its implication on coalbed methane extraction[J]. Energy and Fuels，2016，30(7)：6 009-6 020.
[36]	WU X，HUANG Z，SONG H，et al. Variations of physical and mechanical properties of heated granite after rapid cooling with liquid nitrogen[J]. Rock Mechanics and Rock Engineering，2019，52(7)：2 123-2 139.
[9]	陈勉，葛洪魁，赵金洲，等. 页岩油气高效开发的关键基础理论与挑战[J]. 石油钻探技术，2015，43(5)：7-14.(CHEN Mian，GE Hongkui，ZHAO Jinzhou，et al. The key fundamentals for the efficient exploitation of shale oil and gas and its related challenges[J]. Petroleum Drilling Techniques，2015，43(5)：7-14.(in Chinese))
[18]	LI Z F，XU H，ZHANG C. Liquid nitrogen gasification fracturing technology for shale gas development[J]. Journal of Petroleum Science and Engineering，2016，138：253-256.
[27]	ENAYATPOUR S，VAN OORT E，PATZEK T. Freeze Frac improves the productivity of gas shales[R]. SPE 166482，2013.
[35]	WU X，HUANG Z，LI R，et al. Investigation on the damage of high- temperature shale subjected to liquid nitrogen cooling[J]. Journal of Natural Gas Science and Engineering，2018，57：284-294.
[42]	ZHANG S，HUANG Z，ZHANG H，et al. Experimental study of thermal-crack characteristics on hot dry rock impacted by liquid nitrogen jet[J]. Geothermics，2018，76：253-260.
[44]	HUANG Z，WU X，LI R，et al. Mechanism of drilling rate improvement using high-pressure liquid nitrogen jet[J]. Petroleum Exploration and Development，2019，46(4)：810-818.
[47]	侯鹏，高峰，张志镇，等. 黑色页岩力学特性及气体压裂层理效应研究[J]. 岩石力学与工程学报，2016，35(4)：670-681.(HOU Peng，GAO Feng，ZHANG Zhizhen，et al. Mechanical property and bedding inclination effect on gas fracturing of black shale[J]. Chinese Journal of Rock Mechanics and Engineering，2016，35(4)：670-681.(in Chinese))
[51]	CHA M，ALQAHTANI N B，YAO B，et al. Cryogenic fracturing of wellbores under true triaxial-confining stresses：Experimental investigation[J]. SPE Journal，2018，23(4)：1 271-1 289.
[7]	BRYANT J E，HAGGSTROM J. An environmental solution to help reduce freshwater demands and minimize chemical use[R]. SPE 153867，2012.
[16]	MCDANIEL B W，GRUNDMANN S R，KENDRICK W D，et al. Field applications of cryogenic nitrogen as a hydraulic fracturing fluid[R]. SPE 38623，1997.
[25]	KOCABAS I. An analytical model of temperature and stress fields during cold-water injection into an oil reservoir[J]. SPE Production and Operations，2006，21(2)：282-292.
[33]	QIN L，ZHAI C，LIU S，et al. Failure mechanism of coal after cryogenic freezing with cyclic liquid nitrogen and its influences on coalbed methane exploitation[J]. Energy and Fuels，2016，30(10)：8 567-8 578.
[40]	GAO F，CAI C，YANG Y. Experimental research on rock fracture failure characteristics under liquid nitrogen cooling conditions[J]. Results in Physics，2018，(9)：252-262.
[49]	HUANG Z，ZHANG S，YANG R，et al. A review of liquid nitrogen fracturing technology[J]. Fuel，2020，266：117040.
[2]	董大忠，邹才能，杨桦，等. 中国页岩气勘探开发进展与发展前景[J]. 石油学报，2012，33(增1)：107-114.(DONG Dazhong，ZOU Caineng，YANG Hua，et al. Progress and prospects of shale gas exploration and development in China[J]. Acta Petrolei Sinica，2012，33(Supp.1)：107-114.(in Chinese))
[5]	张东晓，杨婷云. 美国页岩气水力压裂开发对环境的影响[J]. 石油勘探与开发，2015，42(5)：1-7.(ZHANG Dongxiao，YANG Tingyun. Environmental impacts of hydraulic fracturing in shale gas development in the United States[J]. Petroleum Exploration and Development，2015，42(5)：1-7.(in Chinese))
[11]	李根生，王海柱，沈忠厚，等. 超临界CO2射流在石油工程中应用研究与前景展望[J]. 中国石油大学学报：自然科学版，2013，37(5)：76-80.(LI Gensheng，WANG Haizhu，SHEN Zhonghou，et al. Application investigations and prospects of supercritical carbon dioxide jet in petroleum engineering[J]. Journal of China University of Petroleum：Natural Science，2013，37(5)：76-80.(in Chinese))
[20]	CAI C，LI G，HUANG Z，et al. A waterless fracturing treatment：liquid nitrogen fracturing and its application prospect[J]. SOCAR Proceedings，2015，3(3)：35-40.
[29]	衡帅，刘晓，李贤忠，等. 张拉作用下页岩裂缝扩展演化机制研究[J]. 岩石力学与工程学报，2019，38(10)：2 031-2 043.(HENG Shuai，LIU Xiao，LI Xianzhong，et al. Study on the fracture propagation mechanisms of shale under tension[J]. Chinese Journal of Rock Mechanics and Engineering，2019，38(10)：2 031-2 043.(in Chinese))
[31]	CHA M，YIN X，KNEAFSEY T，et al. Cryogenic fracturing for reservoir stimulation-Laboratory studies[J]. Journal of Petroleum Science and Engineering，2014，124：436-450.
[37]	CHA M，ALQAHTANI N B，YIN X，et al. Laboratory system for studying cryogenic thermal rock fracturing for well stimulation[J]. Journal of Petroleum Science and Engineering，2017，156：780-789.
[45]	谢和平，高峰，鞠杨，等. 页岩气储层改造的体破裂理论与技术构想[J]. 科学通报，2016，61(1)：36-46.(XIE Heping，GAO Feng，JU Yang，et al. Novel idea of the theory and application of 3D volume fracturing for stimulation of shale gas reservoirs[J]. Chinese Science Bulletin，2016，61(1)：36-46.(in Chinese))
[48]	CAI C，GAO F，YANG Y. The effect of liquid nitrogen cooling on coal cracking and mechanical properties[J]. Energy Exploration and Exploitation，2018，36(6)：1 609-1 628.
[14]	韩烈祥，朱丽华，孙海芳，等. LPG无水压裂技术[J]. 天然气工业，2014，34(6)：48-54.(HAN Liexiang，ZHU Lihua，SUN Haifang，et al. LPG waterless fracturing technology[J]. Natural Gas Industry，2014，34(6)：48-54.(in Chinese))
[23]	DUSSEAULT M B. Stress changes in thermal operations[R]. SPE 25089，1993.
[39]	YANG R，HUANG Z，SHI Y，et al. Laboratory investigation on cryogenic fracturing of hot dry rock under triaxial-confining stresses[J]. Geothermics，2019，79：46-60.
[8]	路保平. 中国石化页岩气工程技术进步及展望[J]. 石油钻探技术，2013，41(5)：1-8.(LU Baoping. Sinopec engineering technical advance and its developing tendency in shale gas[J]. Petroleum Drilling Techniques，2013，41(5)：1-8.(in Chinese))
[15]	RASSENFOSS S. In search of the waterless fracture[J]. Journal of Petroleum Technology，2013，65(6)：46-52.
[17]	GRUNDMANN S R，RODVELT G D，DIALS G A，et al. Cryogenic nitrogen as a hydraulic fracturing fluid in the Devonian shale[R]. SPE 51067，1998.
[3]	吴奇，胥云，刘玉章，等. 美国页岩气体积改造技术现状及对我国的启示[J]. 石油钻采工艺，2011，33(2)：1-7.(WU Qi，XU Yun，LIU Yuzhang，et al. The current situation of stimulated reservoir volume for shale in U.S.[J]. Oil Drilling and Production Technology，2011，32(2)：1-7.(in Chinese))
[12]	MIDDLETON R S，CAREY J W，CURRIER R P，et al. Shale gas and non-aqueous fracturing fluids：Opportunities and challenges for supercritical CO2[J]. Applied Energy，2015，147：500-509.
[21]	CAI C，HUANG Z，LI G，et al. Feasibility of reservoir fracturing stimulation with liquid nitrogen jet[J]. Journal of Petroleum Science and Engineering，2016，144：59-65.
[46]	JIANG L，CHENG Y，HAN Z，et al. Effect of liquid nitrogen cooling on the permeability and mechanical characteristics of anisotropic shale[J]. Journal of Petroleum Exploration and Production Technology，2019，9(1)：111-124.
[43]	YANG R，HONG C，HUANG Z，et al. Coal breakage using abrasive liquid nitrogen jet and its implications for coalbed methane recovery[J]. Applied Energy，2019，253：113485.
[50]	蔡承政，李根生，黄中伟，等. 液氮对页岩的致裂效应及在压裂中应用分析[J]. 中国石油大学学报：自然科学版，2016，40(1)：79-85.(CAI Chengzheng，LI Gensheng，HUANG Zhongwei，et al. Thermal cracking effect of liquid nitrogen on shale and its application analysis in hydraulic fracturing. Journal of China University of Petroleum：Natural Science，2016，40(1)：79-85.(in Chinese))