基于径向变形增量的煤间歇性破坏过程损伤演化分析

doi:10.13722/j.cnki.jrme.2022.0536

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1514 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要煤样单轴压缩条件下常发生间歇性破坏行为，复杂破坏过程的损伤评价有助于明晰伴随该过程的能量演化，对矿业工程灾害预警及防治具有重要意义。为探究间歇性破坏过程损伤演化，对标准煤样进行常规单轴加载，实时监测其变形特征发现，外载荷作用下煤样局部裂隙丛集发生剧烈损伤时，轴向载荷突降，径向变形剧烈增长，且载荷越接近峰值强度，增长速率越快。损伤源于内部裂隙发育扩展，导致试样沿径向快速膨胀，据此提出基于径向变形增量的损伤表征方法，对煤等非均质介质的非线性损伤评价具有更强适用性。对比基于径向变形增量的损伤评价结果与声发射特征及裂隙发育扩展演化，三者高度一致的演化过程佐证基于径向变形评价损伤的可靠性。研究结果表明，间歇性破坏阶段，裂隙局部丛集或者沿最大主应力方向相互连接贯通形成大尺度破裂，试样径向膨胀，局部剧烈破坏导致其损伤变量激增。间歇性破坏行为源于试样内部不同区域反复发生的局部剧烈损伤，锯齿状应力–应变曲线及伴随该过程的非线性损伤演化表明煤等非均质介质在外载作用下存在损伤突变现象。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	卢志国1
	2
	3
	鞠文君1
	2
	3
	高富强1
	2
	3
	孙卓越1
	2
	3
	彭相愿1
	2
	3

关键词 ：岩石力学, 有效承载面积, 径向变形, 损伤变量, 非线性损伤, 间歇性破坏

Abstract：Intermittent failure behavior often occurs in coal samples under uniaxial compression. The damage assessment of complex failure process is helpful to clarify the energy evolution accompanying the process，which is of great significance to the early warning and prevention of mining engineering disasters. To explore the damage evolution in the process of intermittent failure，the standard coal sample was subjected to conventional uniaxial loading，and its deformation characteristics were monitored in real time. It is found that when severe damage occurs to the local crack cluster of coal sample under external load，the axial load drops suddenly，and the radial deformation increases sharply. The closer the load is to the peak strength，the faster the growth rate is. The damage originates from the development and expansion of internal cracks，resulting in the rapid expansion of the sample along the radial direction. Thus a method of damage characterization based on radial deformation increment was proposed，which is more applicable to the nonlinear damage evaluation of heterogeneous media such as coal. Comparing the damage evaluation based on radial deformation increment with acoustic emission and the development and expansion evolution of fracture，the highly consistent evolution process of the above three proves the reliability of damage evaluation based on radial deformation. The results show that，the cracks are locally clustered or interconnected along the direction of the maximum principal stress to form large-scale fracture in the intermittent failure stage. The radial expansion of the sample causes local severe damage，which leads to a sharp increase in its damage variables. Intermittent failure behavior originates from repeated local severe damage in different areas of the sample. The zigzag stress-strain curve and the nonlinear damage evolution accompanying this process indicate that the damage mutation phenomenon exists in heterogeneous media such as coal under external load.

Key words： rock mechanics effective bearing areas radial deformation damage variable nonlinear damage intermittent failure

引用本文:

卢志国1，2，3，鞠文君1，2，3，高富强1，2，3，孙卓越1，2，3，彭相愿1，2，3. 基于径向变形增量的煤间歇性破坏过程损伤演化分析[J]. 岩石力学与工程学报, 2023, 42(S1): 3529-3540.
LU Zhiguo1，2，3，JU Wenjun1，2，3，GAO Fuqiang1，2，3，SUN Zhuoyue1，2，3，PENG Xiangyuan1，2，3. Damage evolution analysis of coal during intermittent failure process based on radial deformation increment. , 2023, 42(S1): 3529-3540.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2022.0536 或 http://rockmech.whrsm.ac.cn/CN/Y2023/V42/IS1/3529

[25]	赵明阶，徐蓉. 岩石损伤特性与强度的超声波速研究[J]. 岩土工程学报，2000，22(6)：720-722.(ZHAO Mingjie，XU Rong. The rock damage and strength study based on ultrasonic velocity[J]. Chinese Journal of Geotechnical Engineering，2000，22(6)：720-722.(in Chinese))
[2]	宋红华，赵毅鑫，姜耀东，等. 单轴受压条件下煤岩非均质性对其破坏特征的影响[J]. 煤炭学报，2017，42(12)：3 125-3 132.(SONG Honghua，ZHAO Yixin，JIANG Yaodong，et al. Influence of heterogeneity on the failure characteristics of coal under uniaxial compression condition[J]. Journal of China Coal Society，2017，42(12)：3 125-3 132.(in Chinese))
[5]	卢志国，鞠文君，高富强，等. 基于非线性储能与释放特征的煤冲击倾向性指标[J]. 岩石力学与工程学报，2021，40(8)：1 559-1569. (LU Zhiguo，JU Wenjun，GAO Fuqiang，et al. Bursting liability index of coal based on nonlinear storage and release characteristics of elastic energy[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(8)：1 559-1 569.(in Chinese))
[7]	冯夏庭，丁梧秀. 应力-水流-化学耦合下岩石破裂全过程的细观力学试验[J]. 岩石力学与工程学报，2005，24(9)：1 465-1 473. (FENG Xiating，DING Wuxiu. Meso-mechanical experiment of microfracturing process of rock under coupled mechanical- hydrological-chemical environment[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(9)：1 465-1 473.(in Chinese))
[9]	苗子臻，李曙光，霍润科，等. 受酸腐蚀砂岩力学特性及其统计损伤本构模型[J]. 铁道学报，2023，45(1)：141-149.(MIAO Zizhen，LI Shuguang，HUO Runke，et al. Mechanical properties and statistical damage constitutive model of acid-corroded sandstone[J]. Journal of the China Railway Society，2023，45(1)：141-149.(in Chinese))
[12]	兰世瑞，宋大钊，李振雷，等. 基于损伤因子的断层滑移过程声发射特征试验研究[J]. 采矿与岩层控制工程学报，2021，3(3)：82-90.(LAN Shirui，SONG Dazhao，LI Zhenlei，et al. Experimental study on acoustic emission characteristics of fault slip process based on damage factor[J]. Journal of Mining and Strata Control Engineering，2021，3(3)：82-90.(in Chinese))
[15]	王晓军，张河，陈青林，等. 不同岩爆倾向性灰岩加载声发射特征及损伤模型[J]. 岩石力学与工程学报，2022，41(7)：1 373- 1 383.(WANG Xiaojun，ZHANG He，CHEN Qinglin，et al. Acoustic emission characteristics and damage model of limestone loading with different rockburst tendencies[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(7)：1 373-1 383.(in Chinese))
[17]	彭俊，蔡明，荣冠，等. 裂纹闭合应力及其岩石微裂纹损伤评价[J]. 岩石力学与工程学报，2015，34(6)：1 091-1 100.(PENG Jun，CAI Ming，RONG Guan，et al. Stresses for crack closure and its application to assessing stress-induced microcrack damage[J]. Chinese Journal of Rock Mechanics and Engineering，2015，34(6)：1 091- 1 100.(in Chinese))
[10]	胡建华，曾平平，杨东杰，等. 深部循环荷载下花岗岩损伤变形与细观结构分析[J]. 中国有色金属学报，2022，32(4)：1 187- 1 198.(HU Jianhua，ZENG Pingping， YANG Dongjie，et al. Analysis of damage deformation and mesoscopic structure of granite under deep cyclic loading[J]. The Chinese Journal of Nonferrous Metals，2022，32(4)：1 187-1 198.(in Chinese))
[19]	张超，杨楚卿，白允，等. 岩石类脆性材料损伤演化分析及其模型方法研究[J]. 岩土力学，2021，42(9)：2 344-2 354.(ZHANG Chao，YANG Chuqing，BAI Yun，et al. Investigation of damage evolution and its model of rocklike brittle materials[J]. Rock and Soil Mechanics，2021，42(9)：2 344-2 354.(in Chinese))
[20]	曹文贵，赵衡，张玲，等. 考虑损伤阀值影响的岩石损伤统计软化本构模型及其参数确定方法[J]. 岩石力学与工程学报，2008，27(6)：1 148-1 154.(CAO Wengui，ZHAO Heng，ZHANG Ling，et al. Damage statistical softening constitutive model for rock considering effect of damage threshold and its parameters determination method[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(6)：1 148-1 154.(in Chinese))
[22]	谢勇，何文，朱志成，等. 单轴压缩下充填体声发射特性及损伤演化研究[J]. 应用力学学报，2015，32(4)：670-676.(XIE Yong，HE Wen，ZHU Zhicheng，et al. Study on backfill acoustic emission characteristic and damage evolution under uniaxial compression[J]. Chinese Journal of Applied Mechanics，2015，32(4)：670-676.(in Chinese)).
[27]	苗胜军，刘泽京，赵星光，等. 循环荷载下北山花岗岩能量耗散与损伤特征[J]. 岩石力学与工程学报，2021，40(5)：928-938.(MIAO Shengjun，LIU Zejing，ZHAO Xingguang，et al. Characteristics of energy dissipation and damage of Beishan granite under cyclic loading and unloading[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(5)：928-938.(in Chinese))
[30]	杨超，许轩，王乐华，等. 不同特征应力区间单裂隙砂岩与完整岩石蠕变特性的相关关系[J]. 岩石力学与工程学报，2022，41(7)：1 347-1 357.(YANG Chao，XU Xuan，WANG Lehua，et al. Relationship between creep characteristics of intact rock and single-flawed sandstones under different critical stress intervals[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(7)：1 347-1 357.(in Chinese))
[32]	孙海. 承载煤岩损伤演化的红外辐射响应机制及量化表征[博士学位论文][D]. 徐州：中国矿业大学，2019.(SUN Hai. Infrared radiation response mechanism and quantitative characterization during damage evolution of loading coal and rock[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，2019.(in Chinese))
[35]	宋义敏，姜耀东，马少鹏，等. 岩石变形破坏全过程的变形场和能量演化研究[J]. 岩土力学，2012，33(5)：1 352-1 356.(SONG Yimin，JIANG Yaodong，MA Shaopeng，et al. Evolution of deformation fields and energy in whole process of rock failure[J]. Rock and Soil Mechanics，2012，33(5)：1 352-1 356.(in Chinese))
[37]	石浩，宋雷，王敦显，等. 基于裂纹长度幂律排布的损伤砂岩强度模型[J]. 中国矿业大学学报，2022，(2)：263-272.(SHI Hao，SONG Lei，WANG Dunxian，et al. Strength model for damaged sandstone based on power-law distribution of crack length[J]. Journal of China University of Mining and Technology，2022，(2)：263-272.(in Chinese))
[8]	张乐，党发宁，丁卫华，等. 基于改进差分盒维数法的混凝土细观损伤定量研究[J]. 应用基础与工程科学学报，2021，29(4)：973-985.(ZHANG Le，DANG Faning，DING Weihua，et al. Quantitative study of concrete mesoscopic damage based on the improved differential box counting method[J]. Journal of Basic Science and Engineering，2021，29(4)：973-985.(in Chinese))
[18]	范杰，朱星，胡桔维，等. 3D-DIC 技术在砂岩裂纹扩展及损伤监测中的试验研究[J]. 岩土力学，2023(待刊).(FAN Jie，ZHU Xing，HU Juwei，et al. Research on three-dimensional digital image correlation technology in sandstone crack propagation and damage monitoring[J]. Rock and Soil Mechanics，2023(to be pressed).(in Chinese))
[28]	张尧，李波波，许江，等. 基于能量耗散的煤岩三轴受压损伤演化特征研究[J]. 岩石力学与工程学报，2021，40(8)：1 614-1 627. (ZHANG Yao，LI Bobo，XU Jiang，et al. Study on triaxial compression damage evolution characteristics of coal based on energy dissipation[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(8)：1 614-1 627.(in Chinese))
[3]	卢志国，鞠文君，高富强，等. 结构性煤体间歇性破坏行为的实验及数值模拟研究[J]. 岩石力学与工程学报，2020，39(5)：971-983. (LU Zhiguo，JU Wenjun，GAO Fuqiang，et al. Experimental and numerical simulation research on intermittent failure of structural coal[J]. Chinese Journal of Rock Mechanics and Engineering，2020，39(5)：971-983.(in Chinese))
[13]	张玉良，吴必胜，赵高峰. 基于声发射监测的岩石热损伤实时演化研究[J]. 中南大学学报：自然科学版，2021，52(8)：2 945-2 958. (ZHANG Yuliang，WU Bisheng，ZHAO Gaofeng. Study on thermal damage evolution of rock based on acoustic emission[J]. Journal of Central South University：Science and Technology，2021，52(8)： 2 945-2 958.(in Chinese))
[23]	范华林，金丰年. 岩石损伤定义中的有效模量法[J]. 岩石力学与工程学报，2000，19(4)：422-425.(FAN Hualin，JIN Fengnian. Effective modulus method in damage mechanics of rock[J]. Chinese Journal of Rock Mechanics and Engineering，2000，19(4)：422-425.(in Chinese)).
[33]	张全胜，杨更社，任建喜. 岩石损伤变量及本构方程的新探讨[J].岩石力学与工程学报，2003，22(1)：30-34.(ZHANG Quansheng，YANG Gengshe，REN Jianxi. New study of damage variable and constitutive equation of rock[J]. Chinese Journal of Rock Mechanics and Engineering，2003，22(1)：30-34.(in Chinese))
[6]	朱红光，易成，单海霞，等. 基于CT 图像分析的准脆性材料轴压损伤研究[J]. 中国矿业大学学报，2011，40(5)：816-822.(ZHU Hongguang，YI Cheng，SHAN Haixia，et al. Damage of quasi-birttle materials uniaxial compression based on CT image analysis[J]. Journal of China University of Mining and Technology，2011，40(5)：816-822.(in Chinese))
[16]	汪斌，朱杰兵，严鹏，等. 大理岩损伤强度的识别及基于损伤控制的参数演化规律[J]. 岩石力学与工程学报，2012，31(增2)： 3 967-3 973.(WANG Bin，ZHU Jiebing，YAN Peng，et al. Damage strength determination of marble and its parameters evaluation based on damage control test[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(Supp.2)：3 967-3 973.(in Chinese))
[26]	张艳博，王科学，姚旭龙，等. 基于波速场成像技术的岩石损伤评价研究[J]. 岩石力学与工程学报，2019，38(12)：2 404-2 417. (ZHANG Yanbo，WANG Kexue，YAO Xulong，et al. Rock damage evaluation based on wave velocity field imaging technology[J]. Chinese Journal of Rock Mechanics and Engineering，2019，38(12)：2 404-2 417.(in Chinese))
[36]	李文洲，司林坡，卢志国，等. 煤单轴压缩起裂强度确定及其关键因素影响分析[J]. 煤炭学报，2021，46(增2)：670-680.(LI Wenzhou，SI Linpo，LU Zhiguo，et al. Determination of coal cracking initiation strength under uniaxial compression and analysis of its key factors[J]. Journal of China Coal Society，2021，46(Supp.2)：670-680.(in Chinese))
[1]	李术才，朱维申. 复杂应力状态下断续节理岩体断裂损伤机制研究及其应用[J]. 岩石力学与工程学报，1999，18(2)：142-146.(LI Shucai，ZHU Weishen. Fracture damage mechanism of discontinuous jointed rockmass under the state of complex stress and its application[J]. Chinese Journal of Rock Mechanics and Engineering，1999，18(2)：142-146.(in Chinese))
[4]	MIAO S J，CAI M F，GUO Q F，et al. Rock burst prediction based on in-situ stress and energy accumulation theory[J]. International Journal of Rock Mechanics and Mining Sciences，2016，83(1)：86-94.
[11]	刘保县，黄敬林，王泽云，等. 单轴压缩煤岩损伤演化及声发射特性研究[J]. 岩石力学与工程学报，2009，28(增1)：3 234-3 238.(LIU Baoxian，HUANG Jinglin，WANG Zeyun，et al. Study on damage evolution and acoustic emission character of coal rock under uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(Supp.1)：3 234-3 238.(in Chinese))
[14]	李浩然，王子恒，孟世荣，等. 高温三轴应力下大理岩损伤演化与声发射活动特征研究[J]. 岩土力学，2021，42(10)：2 672-2 682.(LI Haoran，WANG Ziheng，MENG Shirong，et al. Acoustic emission activity and damage evolution characteristics of marble under triaxial stress at high temperatures[J]. Rock and Soil Mechanics，2021，42(10)：2 672-2 682.(in Chinese))
[21]	邓华锋，胡安龙，李建林，等. 水岩作用下砂岩劣化损伤统计本构模型[J]. 岩土力学，2017，38(3)：631-639.(DENG Huafeng，HU Anlong，LI Jianlin，et al. Statistical constitutive model of sandstone deterioration and damage under water and rock action[J]. Rock and Soil Mechanics，2017，38(3)：631-639.(in Chinese))
[24]	尤明庆，苏承东，李小双. 损伤岩石试样的力学特性与纵波速度关系研究[J]. 岩石力学与工程学报，2008，27(3)：458-467.(YOU Mingqing，SU Chengdong，LI Xiaoshuang. Study on relation between mechanical properties and longitudinal wave velocities for damaged rock samples[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(3)：458-467.(in Chinese))
[31]	LEMAITRE J. How to use damage mechanics[J]. Nuclear Engineering and Design，1984，80(2)：233-245.
[34]	徐晓炼，张茹，戴峰，等. 煤岩特性对超声波速影响的试验研究[J]. 煤炭学报，2015，40(4)：793-800.(XU Xiaolian，ZHANG Ru，DAI Feng，et al. Effect of coal and rock characteristics on ultrasonic velocity[J]. Journal of China Coal Society，2015，40(4)：793-800.(in Chinese))
[29]	文志杰，田雷，蒋宇静，等. 基于应变能密度的非均质岩石损伤本构模型研究[J]. 岩石力学与工程学报，2019，38(7)：1 332-1 343. (WEN Zhijie，TIAN Lei，JIANG Yujing，et al. Research on damage constitutive model of inhomogeneous rocks based on strain energy density[J]. Chinese Journal of Rock Mechanics and Engineering，2019，38(7)：1 332-1 343.(in Chinese))