瓦斯抽采钻孔孔周裂隙演化及等效裂纹宽度试验研究

doi:10.13722/j.cnki.jrme.2019.0072

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (491 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为探究瓦斯抽采钻孔孔周裂隙扩展特征，取不同含水率的含孔方形试样，开展在渐进性破坏过程中数字散斑相关测量，获得单轴压缩下试样表面裂纹扩展过程中应变场的演化特征；采用RSM-SY7声波仪获取试样在破坏过程中的透射波形、波速和时间，根据声波透射过程中的时差计算公式，计算出试样在破坏过程中的等效裂纹宽度，揭示含水率对含孔试样裂纹扩展规律的影响。结果表明：(1) 在试样渐进性破坏过程中，随着含水率的增大裂隙扩展明显减少，峰值应力?p的离散性显著降低；(2) 超声波检测结果显示，饱水状态下首波到达时间较干燥状态下延迟8～10 ?s，且声波能量在时间域上衰减较快；(3) 对试样破坏过程中等效裂纹宽度和应力水平试验曲线的拟合，得出等效裂纹宽度随应力水平的增高呈现指数级增长，可以对裂纹扩展参数进行定量化描述；裂隙扩展速率随含水率的增高显著降低，其中控制含水组的等效裂纹宽度在0.003～0.004 mm范围，干燥试样的等效裂纹宽度在0.012～0.013 mm范围。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张天军1
	2
	纪翔1
	张磊2
	庞明坤1

关键词 ：采矿工程, 含水率, 含孔试样, 数字散斑测量, 超声波, 等效裂纹宽度

Abstract：In order to explore the characteristics of crack propagation around the gas drilling borehole，the uniaxial compression test of the pore samples under different water conditions was carried out，and the evolution characteristics of the strain field in the surface crack propagation process of the samples during compression was measured by the digital speckle correlation measurement. The transmission waveform，the wave velocity and time during compression was measured by RSM-SY7 ultrasonic system. According to the calculation formula of time difference during the acoustic wave transmission process，the equivalent crack width of the sample during the failure process is calculated，and the influence of water content on the crack propagation rule of the sample with holes is revealed. The results show that：(1) In the progressive failure process of the sample, the crack propagation decreases obviously with the increase of water content，and the dispersion of peak stress σp decreases obviously. (2) The ultrasonic testing results show that the arrival time of the first wave in the saturated state is delayed by 8–10 ?s compared with that in the dry state，and the acoustic wave energy decays rapidly in the time domain. (3) Fitting the test curve of equivalent crack width and stress level in the failure process of the sample，it is concluded that the equivalent crack width increases exponentially with the increase of stress level，which can quantitatively describe the crack propagation parameters. The crack propagation rate decreases significantly with the increase of water content，with the equivalent crack width of the control water content group being between 0.003 mm and 0.004 mm，and the equivalent crack width of the dry sample being between 0.012 mm and 0.013 mm.

Key words： mining engineering moisture content porous sample digital speckle correlation measurement ultrasonic equivalent crack width

引用本文:

张天军1，2，纪翔1，张磊2，庞明坤1. 瓦斯抽采钻孔孔周裂隙演化及等效裂纹宽度试验研究[J]. 岩石力学与工程学报, 2019, 38(S2): 3625-3633.
ZHANG Tianjun1，2，JI Xiang1，ZHANG Lei2，PANG Mingkun1. Experimental study on evolution of circumferential crack and equivalent crack width of gas drilling borehole. , 2019, 38(S2): 3625-3633.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2019.0072 或 http://rockmech.whrsm.ac.cn/CN/Y2019/V38/IS2/3625

[21]	肖杰，刘保国. 水泥石膏相似材料配比试验研究[J]. 岩土工程技术，2015，29(2)：65–68.(XIAO Jie，LIU Baoguo. Experimental study on the proportion of cement gypsum similar materials[J]. Geotechnical Engineering，2015，29(2)：65–68.(in Chinese))
[1]	李鹏，刘建，朱杰兵，等. 软弱结构面剪切蠕变特性与含水率关系研究[J]. 岩土力学，2008，29(7)：1 865–1 871.(LI Peng，LIU Jian，ZHU Jiebing，et al. Relationship between shear creep properties and water content of weak structural planes[J]. Rock and Soil Mechanics，2008，29(7)：1 865–1 871.(in Chinese))
[3]	彭瑞东，张玉军，杨永明，等. 孔隙煤岩损伤破坏行为的数值模拟[J]. 煤炭学报，2014，39(6)：1 039–1 048.(PENG Ruidong，ZHANG Yujun，YANG Yongming，et al. Numerical simulation of damage and failure behavior of pore coal[J]. Journal of China Coal Society，2014，39(6)：1 039–1 048.(in Chinese))
[4]	张天军，任金虎，陈占清，等. 破碎泥岩渗透特性试验研究[J]. 河南理工大学学报自然科学版，2014，33(4)：426–431.(ZHANG Tianjun，REN Jinhu，CHEN Zhanqing，et al. Experimental study on permeability characteristics of fractured mudstone[J]. Journal of Henan Polytechnic University，2014，33(4)：426–431.(in Chinese))
[6]	许江，耿加波，彭守建，等. 不同含水率条件下煤与瓦斯突出的声发射特性[J]. 煤炭学报，2015，40(5)：1 047–1 054.(XU Jiang，GENG Jiabo，PENG Shoujian，et al. Acoustic emission characteristics of coal and gas outburst under different water content conditions[J]. Journal of China Coal Society，2015，40(5)：1 047–1 054.(in Chinese))
[9]	NAKAYAMA T，HAGIWARA Y. On the relation between discontinuities in rock and power spectrum attenuation of elastic wave[J]. Nihon Kogyokaishi，1988，104(1207)：555–560.
[7]	马少鹏，王来贵，赵永红. 岩石圆孔结构破坏过程变形场演化的实验研究[J]. 岩土力学，2006，27(7)：1 082–1 086.(MA Shaopeng，WANG Laigui，ZHAO Yonghong. Experimental study on deformation field evolution during failure procedure of a rock borehole structure[J]. Rock and Soil Mechanics，2006，27(7)：1 082–1 086.(in Chinese))
[11]	朱合华，周治国，邓涛. 饱水对致密岩石声学参数影响的试验研究[J]. 岩石力学与工程学报，2005，24(5)：823–828.(ZHU Hehua，ZHOU Zhiguo，DENG Tao. Experimental study on the influence of saturated water on acoustic parameters of tight rock[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(5)：823–828.(in Chinese))
[13]	尤明庆，苏承东，李小双. 损伤岩石试样的力学特性与纵波速度关系研究[J]. 岩石力学与工程学报，2008，27(3)：458–467.(YOU Mingqing，SU Chengdong，LI Xiaoshuang. Study on the relationship between mechanical properties and longitudinal wave velocity of damaged rock specimens[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(3)：458–467.(in Chinese))
[14]	刘向君，刘洪，徐晓雷，等. 低孔低渗砂岩加载条件下的声波传播特性实验研究[J]. 岩石力学与工程学报，2009，28(3)：560–567.(LIU Xiangjun，LIU Hong，XU Xiaolei，et al. Experimental study on acoustic wave propagation characteristics of low porosity and low permeability sandstone under loading conditions[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(3)：560–567.(in Chinese))
[16]	王云刚，李满贵，陈兵兵，等. 干燥及饱和含水煤样超声波特征的实验研究[J]. 煤炭学报，2015，40(10)：2 445–2 450.(WANG Yungang，LI Mangui，CHEN Bingbing，et al. Experimental study on ultrasonic wave characteristics of coal samples under dry and water saturated conditions[J]. Journal of China Coal Society，2015，40(10)：2 445–2 450.(in Chinese))
[5]	EBERHARDT E，STEAD D，STIMPSON B，et al. Identifying crack initiation and propagation thresholds in brittle rock[J]. Canadian Geotechnical Journal，1998，35(2)：222–233.
[15]	陈旭，俞缙，李宏，等. 不同岩性及含水率的岩石声波传播规律试验研究[J]. 岩土力学，2013，34(9)：2 527–2 533.(CHEN Xu，YU Jin，LI Hong，et al. Experimental study of propagation characteristics of acoustic wave in rocks with different lithologies and water contents[J]. Rock and Soil Mechanics，2013，34(9)：2 527– 2 533.(in Chinese))
[17]	王云刚，杨廷廷，王琼洋，等. 煤样中超声波传播特性研究[J]. 中国安全科学学报，2017，(12)：68–73.(WANG Yungang，YANG Tingting，WANG Qiongyang，et al. Study on ultrasonic propagation characteristics in coal samples[J]. China Safety Science Journal，2017，(12)：68–73.(in Chinese))
[19]	张天军，张磊，李树刚，等. 含孔试样渐进性破坏的表面变形特征[J]. 煤炭学报，2017，42(10)：2 623–2 630.(ZHANG Tianjun，ZHANG Lei，LI Shugang，et al. Characteristics of the surface deformation of specimens with a hole during the progressive failure[J]. Journal of China Coal Society，2017，42(10)：2 623–2 630.(in Chinese))
[23]	张明升. 大型轴锻件裂纹超声波探伤[J]. 无损检测，1983，(3)：5–11.(ZHANG Mingsheng. Ultrasonic flaw detection of cracks in large shaft forgings[J]. Non-destructive Testing，1983，(3)：5–11.(in Chinese))
[24]	张晓平，王思敬，韩庚友，等. 岩石单轴压缩条件下裂纹扩展试验研究——以片状岩石为例[J]. 岩石力学与工程学报，2011，30(9) ：1 772–1 781.(ZHANG Xiaoping，WANG Sijing，HAN Gengyou，et al. Crack propagation study of rock based on uniaxial compressive test—A case study of schistose rock[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(9)：1 772–1 781.(in Chinese))
[2]	MOHAMAD E T，LATIFI N，AREFNIA A，et al. Effects of moisture content on the strength of tropically weathered granite from Malaysia[J]. Bulletin of Engineering Geology and the Environment，2015，75(1)：1–22.
[12]	周治国，朱合华，陈伟. 饱水岩样声波传播规律的试验研究[J]. 岩石力学与工程学报，2004，25(5)：911–917.(ZHOU Zhiguo，ZHU Hehua，CHEN Wei. Experimental study on acoustic wave propagation law of saturated rock samples[J]. Chinese Journal of Rock Mechanics and Engineering，2004，25(5)：911–917.(in Chinese))
[22]	王洪亮，范鹏贤，王明洋，等. 应变率对红砂岩渐进破坏过程和特征应力的影响[J]. 岩土力学，2011，32(5)：1 340–1 346.(WANG Hongliang，FAN Pengxian，WANG Mingyang，et al. In-fluence of strain rate on progressive failure process and characteristic stresses of red sandstone[J]. Rock and Soil Mechanics，2011，32(5)：1 340– 1 346.(in Chinese))
[8]	潘红宇，葛迪，张天军，等. 应变率对岩石裂隙扩展规律的影响[J]. 煤炭学报，2018，43(3)：675–683.(PAN Hongyu，GE Di，ZHANG Tianjun，et al. Influence of strain rate on the rock fracture propagation law[J]. Journal of China Coal Society，2018，43(3)：675–683.(in Chinese))
[10]	成林，王赟，张玉贵，等. 煤岩声波特征研究现状及展望[J]. 地球物理学进展，2013，28(1)：452–461.(CHENG Lin，WANG Wei，ZHANG Yugui，et al. Current status and prospects of acoustic wave characteristics of coal and rock[J]. Progress in Geophysics，2013，28(1)：452–461.(in Chinese))
[18]	张天军，张磊，李树刚，等. 含水含孔试样破坏的波速及功率谱密度特征[J]. 煤炭学报，2018，43(12)：3 387–3 394.(ZHANG Tianjun，ZHANG Lei，LI Shugang，et al. Characteristic of the surface deformation of specimens with a hole during the progressive failure[J]. Journal of China Coal Society，2018，43(12)：3 387–3 394.(in Chinese))
[20]	杨仁树，张宇菲，杨立云，等. 石膏类相似材料的配比试验研究[J]. 中国矿业，2013，(10)：125–130.(YANG Renshu，ZHANG Yufei，YANG Liyun，et al. Study on proportioning test of gypsum-like materials[J]. China Mining Magazine，2013，(10)：125–130.(in Chinese))