地层沉陷过程中埋地高密度聚乙烯(HDPE)管道力学行为研究

doi:10.13722/j.cnki.jrme.2017.0230

摘要
图/表
参考文献(27)
相关文章 (15)

全文: PDF (548 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要

地层沉陷的发生和发展会导致管道的不均匀沉降变形，进而造成破坏失效。现有研究成果大多基于Winkler弹性地基梁理论进行地层沉陷作用下埋地管道受力变形的分析，这一理论适用的前提是“管土始终接触”。然而由于管土的刚度差异以及管道上方填土的土拱效应，可能出现“管土分离”，致使Winkler弹性地基梁理论的适用性值得商榷。因此，需要以试验数据为基础，证实“管土分离”现象的存在，并研究此种状态下管道的受力变形变化规律。利用自制的大型模型试验箱，以长江砂为填料，通过下调控制模型箱底板的不同位移模式模拟地层沉陷的形成和发展，进而研究埋地HDPE双壁波纹管道的受力变形特征。试验结果表明：(1) 在模型箱底板的下调过程中，HDPE管道及其填土表面的竖向位移均符合修正高斯分布曲线，且管道竖向位移曲线的宽度系数小于填土表面竖向位移曲线的宽度系数；(2) HDPE管道的上覆土压力在模型箱底板的下调过程中总体呈现出增加的趋势，并呈现出“三维土拱效应”的变化特征；(3) 管道下方土压力测试数据证实了地层沉陷发展过程中的“管土分离”现象，而Winkler弹性地基梁理论由于采用了“管土不分离”的假定，其对于埋地管道竖向位移以及其纵向弯矩的计算过于保守，其管道竖向位移的计算值是本文实测值的1.1～9倍，纵向弯矩的计算值是实测应变计算值的3～11倍。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	周敏1
	2
	杜延军1
	2
	王非1
	2
	尤佺1
	2
	董冬冬1
	2

关键词 ：土力学, 地层沉陷, HDPE双壁波纹管道, 模型试验, 土压力, 管道变形, 管土分离

Abstract：

The failure of buried HDPE pipes may occur as a result of large differential deformation caused by the localized land subsidence. The buried pipe subjected to the land subsidence is commonly analyzed using the theory of beams on Winkler elastic foundation. The theory assumes that the pipe deforms with soil and no separation is expected. However，separation of the pipe and soil may occur due to the stiffness difference and the soil arching effect triggered above the pipe when the land subsidence is developed. Therefore，it is necessary to investigate the possible “pipe-soil separation and performance of the pipe under this condition. In this study，series of large-scale model tests are conducted to investigate the mechanical responses of buried HDPE pipes by using a custom-made model box. Yangtze River sand is used as the backfill. Movable plates installed at the bottom of model box are lowered in target sequences to simulate the land subsidence. Test results show that (1) the vertical displacement of HDPE pipes and settlement trough at the soil surface are well fitted by using the modified Gaussian distribution curves. The width parameters of fitted curves for vertical displacement of HDPE pipes are smaller than those for settlement trough at the soil surface；(2) the earth pressure at the top of the HDPE pipe experiences an overall increase with lowering of bottom plates of the model box. Three-dimensional soil arching effect is observed during the test；(3) the earth pressures measured underneath the pipe reduce to zero with the lowering of the bottom plates. It is indicated that the pipe-soil separation occurs at the bottom of the pipe. It is also found that the vertical displacement and longitudinal bending moment of the HDPE pipe calculated by the theory of beams on Winkler elastic foundation are 1.1 to 9 times and 3 to 11 times those measured in this study，respectively.

Key words： soil mechanics land subsidence HDPE pipe model test earth pressure pipe deformation pipe-soil separation

引用本文:

周敏1，2，杜延军1，2，王非1，2，尤佺1，2，董冬冬1，2. 地层沉陷过程中埋地高密度聚乙烯(HDPE)管道力学行为研究[J]. 岩石力学与工程学报, 2017, 36(S2): 4177-4187.
ZHOU Min1，2，DU Yanjun1，2，WANG Fei1，2，YOU Quan1，2，DONG Dongdong1，2. Mechanical response of buried HDPE pipes subjected to localized land subsidence. , 2017, 36(S2): 4177-4187.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2017.0230 或 https://rockmech.whrsm.ac.cn/CN/Y2017/V36/IS2/4177

[1]	邢丽霞，阙列东. 我国的地面塌陷及其危害[J]. 中国地质灾害与防治学报，1997，8(增)：23-28.(XING Lixia，QUE Liedong. The distribution and harm of the land collapses in China[J]. The Chinese Journal of Geological Hazard and Control，1997，8(Supp.)：23-28.(in Chinese))
[2]	吴念. 我国HDPE双壁波纹管发展现状[J]. 塑料，2007，36(5)：39-42.(WU Nian. Development of domestic double-wall corrugated pipes[J]. Plastics，2007，36(5)：39-42.(in Chinese))
[3]	陈秀华. HDPE双壁波纹管在市政排水工程中的应用优势[J]. 广东建材，2006，(6)：7-9.(CHEN Xiuhua. The advantages of HDPE double-wall corrugated pipe in municipal drainage project[J]. Guangdong Building Materials，2006，(6)：7-9.(in Chinese))
[4]	GARCIAD，MOOREI. Behavior of bell and spigot joints in buried thermoplastic pipelines[J]. Transportation Research Record：Journal of the Transportation Research Board，2013，2332：29-40.
[5]	WANGF，DUY J，YANG X M. Physical modeling on ground responses to tunneling in sand considering the existence of HDPE pipes[J]. ASTM Geotechnical Testing Journal，2015，38(1)：85-97.
[6]	BRACHMANR W I，MOOREI D，MUNROS M. Compaction effects on strains within profiled thermoplastic pipes[J]. Geosynthetics International，2008，15(2)：72-85.
[7]	TREDORUI B. Beams on elastic foundation the simplified continuum approach[J]. Buletinul Institutului Politehnic din lasi. Sectia Constructii，Arhitectura，2009，55(4)：37.
[8]	HETENYIM. Beams on elastic foundation：theory with applications in the fields of civil and mechanical engineering[M]. Ann Arbor：University of Michigan Press，1946：24-29.
[9]	O¢ROURKEM J，HMADIK E.Analysis of continuous buried pipelines for seismic wave effects[J]. Earthquake engineering and structural dynamics，1988，16(6)：917-929.
[10]	IIMURAS. Simplified mechanical model for evaluating stress in pipeline subject to settlement[J]. Construction and Building Materials，2004，18(6)：469-479.
[11]	张士乔，李洵，吴小刚. 地基差异沉降时管道的纵向力学性状分析[J]. 中国农村水利水电，2003，(7)：46-48.(ZHANG Tuqiao，LI Xun，WU Xiaogang. Analysis of longitudinal mechanical properties for pipeline during foundation uneven settlement[J]. China Rural Water and Hydropower，2003，(7)：46-48.(in Chinese))
[12]	冯启民，高惠英. 受沉陷作用埋地管道破坏判别方法[J]. 地震工程与工程振动，1997，17(2)：59-66.(FENG Qimin，GAO Huiying. Damage criteria of buried pipelines through ground settlement zone[J]. Earthquake Engineering and Engineering Vibration，1997，17(2)：59-66.(in Chinese))
[13]	高惠瑛，冯启民. 场地沉陷埋地管道反应分析方法[J]. 地震工程与工程振动，1997，17(1)：68-75.(GAO Huiying，FENG Qimin. Response analysis for buried pipelines through settlement zone[J]. Earthquake Engineering and Engineering Vibration，1997，17(1)：68-75.(in Chinese))
[14]	Japanese Gas Works Association. JGWA Recommended Practices for Earthquake resistant design for gas pipelines[S]. [S. l.]：[s. n.]，1982.
[15]	中华人民共和国国家标准编写组. GB 50332—2002 给水排水工程管道结构设计规范[S]. 北京：中国建筑工业出版社，2002.(The National Standards Compilation Group of People¢s Republic of China. GB 50332—2002 Structural design code for pipelines water supply and waste water engineering[S]. Beijing：China Architecture and Building Press，2002.(in Chinese))
[16]	HACHIYAM，INOUEY，TOHDAJ，et al. Response of buried pipelines subjected to differential ground settlement[J]. Physical Modelling in Geotechnics：ICPMG’02，2002：911-916.
[17]	VORSTER T E B. The effects of tunnelling on buried pipes[Ph.D. Thesis][D]. Cambridge：Cambridge University，2005.
[18]	KOBAYASHIT，NAKANEH，SUZUKIN，et al. Parametric study on flexibility of buried pipeline subject to large ground displacement[C]//Proceedings of the Second US-Japan Workshop on Liquefaction，Large Ground Deformation and Their Effects on Lifeline Facilities.[S. l.]：[s. n.]， 1989：348-362.
[19]	SUZUKIH. Damage to buried pipes caused by large ground displacement[C]//Proceedings of the First Japan-US Workshop on Liquefaction，Large Ground Deformation and Their Effects on Lifeline.[S. l.]：[s. n.]，1988：127-132.
[20]	周敏，杜延军，王非，等. 地层沉陷中埋地HDPE管道力学状态及模型试验分析[J]. 岩土工程学报，2016，38(2)：253-262.(ZHOUMin，DUYanjun，WANGFei，et al.Physical modeling of mechanical responsesof HDPE pipes and subsurface settlement caused by land subsidence[J]. Chinese Journal of Geotechnical Engineering，2016，38(2)：253-262.(in Chinese))
[21]	VORSTER T E，KLAR A，SOGA K，et al. Estimating the effects of tunneling on existing pipelines[J]. Journal of Geotechnical and Geoenvironmental Engineering，2005，131(11)：1399-1410.
[22]	AASHTO.LRFD bridge design specifications[S].Washington，D. C：American Association of State Highway and Transportation Officials，2012.
[23]	MOOREI D，HUF. Linear viscoelastic modelling of profiled high density polyethylene pipe[J]. Canadian Journal of Civil Engineering，1996，23(2)：395-407.
[24]	TERZAGHIK. Theoretical soil mechanics[M]. New York：John Wiley andSons，Inc.，1943：66-76.
[25]	MOSERA P，FOLKMAN S.Buried pipe design[M].3th ed. Utah：McGraw-Hill Professional，1990：10-33.
[26]	CHUA K M. Time-dependent interaction of soil and flexible pipe[Ph.D. Thesis][D]. State of Texas：Texas A andM University，1986.
[27]	中华人民共和国行业标准编写组. CECS 164：2004埋地聚乙烯排水管管道工程技术规程[S]. 北京：中国建筑工业出版社，2004.(The Professional Standards Compilation Group of People¢s Republic of China. CECS 164：2004 Technical specification for buried PE pipeline of sewer engineering[S]. Beijing：China Architecture and Building Press，2004.(in Chinese))