深部厚顶煤巷道让压型锚索箱梁支护系统现场试验对比研究

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (642 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要针对巨野矿区深部高地应力厚顶煤巷道支护特点，以“先抗后让再抗”支护理念为指导，研制高强让压型锚索箱梁(PRABB)支护系统。该系统具有预紧力损失小、定量让压、支护力传递效果好、护表面积大等特点。分别以箱型支护梁和矿用12#工字钢为托梁设计了横梁、纵向单梁和纵向双梁共6种支护系统。以赵楼煤矿深部厚顶煤巷道为工程背景，利用数值试验对其支护效果进行初步分析，并在3302工作面顺槽进行6种支护系统的现场试验对比研究。现场试验结果表明：(1) 相对于原支护方案，6种锚索梁支护系统均能有效控制巷道围岩变形；(2) PRABB支护系统试验段巷道支护效果整体优于工字钢锚索梁方案，前者围岩变形量比后者小15%～25%；(3) 纵向单梁支护系统对巷道围岩的控制效果最好，纵向双梁支护系统次之，横梁支护系统相对较差。根据试验结果对钢梁不同布置方式的围岩控制机制进行分析表明：纵向单梁支护系统可有效控制厚顶煤巷道顶板关键部位的变形，调动围岩自承能力，使巷道变形得到较好控制。在深部厚顶煤巷道支护时，采用PRABB支护系统纵向单梁方案，可达到经济有效控制巷道围岩变形的目的。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：采矿工程, 厚顶煤巷道, 让压型锚索箱梁, 布置方式, 数值试验, 现场试验

Abstract：Considering the situation of deep roadway of Juye mining area，of which the ground stress is high and the top coal is thick，and guided by the support idea，which is first anti-pressure，second pressure relief，third anti-pressure，high strength pressure relief anchor box beam(PRABB) support system was developed. PRABB support system has the advantage of low prestress loss，quantitative pressure relief，good supporting force transmission effects and a large contact area. Taking mine I-steel beam #12 and box support beam as trimmer beam respectively，two cross anchor beam support systems，two longitudinal single anchor beam support systems and two longitudinal double anchor beams support systems were designed. Taking deep thick top coal roadway of Zhaolou colliery as the engineering background，preliminary analysis of supporting effects of the support systems was produced by numerical test，and all the support systems were field-tested in crossheading of working face 3302. The field test results show that：(1) Six support systems are all better in controlling surrouding rock deformation than original support scheme. (2) Support effects of PRABB support systems are better than those of mine I-steel anchor beam support systems，and the roadway deformation of PRABB support systems is 15%–25% less than that of mine I-steel anchor beam support systems. (3) Among all the support systems，the longitudinal single anchor beam support systems are best in controlling surrounding rock，the longitudinal double anchor beams support systems take second place，the cross anchor beam support systems are relatively poor. Control mechanisms of different arrangement modes of beams are analyzed by test results. By longitudinal single anchor beam support systems，deformation of key position in thick top coal roadway is controlled well；it is helpful in making the best of self-bearing ability of surrounding rock and controlling roof deformation. In the deep thick top coal roadway supporting，longitudinal single anchor box beam support system is better for controlling surrouding rock deformation in a cost-effective way；so that the supporting demand is satisfied.

Key words： mining engineering thick top coal roadway pressure relief anchor box beam(PRABB arrangement mode numerical test field test

收稿日期: 2011-11-17

引用本文:

李术才1，王琦1，2，李为腾1，王德超1，李智1，江贝3，王汉鹏1，王洪涛1. 深部厚顶煤巷道让压型锚索箱梁支护系统现场试验对比研究[J]. 岩石力学与工程学报, 2012, 31(4): 656-666.
LI Shucai1，WANG Qi1，2，LI Weiteng1，WANG Dechao1，LI Zhi1，JIANG Bei3，. COMPARATIVE FIELD TEST STUDY OF PRESSURE RELIEF ANCHOR BOX BEAM SUPPORT SYSTEM IN DEEP THICK TOP COAL ROADWAY. , 2012, 31(4): 656-666.

链接本文:

http://www.rockmech.org/CN/Y2012/V31/I4/656

[3]	孙晓明，张国锋，蔡峰，等. 深部倾斜岩层巷道非对称变形机制及控制对策[J]. 岩石力学与工程学报，2009，28(6)：1 137-1 143. (SUN Xiaoming，ZHANG Guofeng，CAI Feng，et al. Asymmetric deformation mechanism within inclined rock strata induced by excavation in deep roadway and its controlling countermeasures[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(6)：1 137-1 143.(in Chinese)) " target="_blank">
[6]	何满潮，谢和平，彭苏萍，等. 深部开采岩体力学研究[J]. 岩石力学与工程学报，2005，24(16)：2 803-2 813.(HE Manchao，XIE Heping，PENG Suping，et al. Study on rock mechanics in deep mining engineering[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(16)：2 803-2 813.(in Chinese)) " target="_blank">
[8]	齐干，李占金，唐强达，等. 深部大断面软岩巷道变形力学机制及耦合支护设计[J]. 采矿与安全工程学报，2009，26(4)：455-459. (QI Gan，LI Zhanjin，TANG Qiangda，et al. Deformation mechanical mechanism and coupling support design for deep large-section soft-rock roadway[J]. Journal of Mining and Safety Engineering，2009，26(4)：455-459.(in Chinese)) " target="_blank">
[1]	陈炎光，陆士良. 中国煤矿巷道围岩控制[M]. 徐州：中国矿业大学出版社，1994：77-82.(CHEN Yanguang，LU Shiliang. Surrounding rock control of coal mine roadway in China[M]. Xuzhou：China University of Mining and Technology Press，1994：77-82.(in Chinese)) " target="_blank">
[2]	何满潮，王晓义，刘文涛，等. 孔庄矿深部软岩巷道非对称变形数值模拟与控制对策研究[J]. 岩石力学与工程学报，2008，27(4)：673-678.(HE Manchao，WANG Xiaoyi，LIU Wentao，et al. Numerical simulation on asymmetric deformation of deep soft rock roadway in Kongzhuang coal mine[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(4)：673-678.(in Chinese))
[4]	康红普，林健，张晓，等. 潞安矿区井下地应力测量及分布规律研究[J]. 岩土力学，2010，31(3)：827-843.(KANG Hongpu，LIN Jian，ZHANG Xiao，et al. In-situ stress measurements and distribution laws in Lu?an underground coal mines[J]. Rock and Soil Mechanics，2010，31(3)：827-843.(in Chinese)) " target="_blank">
[5]	何满潮，齐干，程骋，等. 深部复合顶板煤巷变形破坏机制及耦合支护设计[J]. 岩石力学与工程学报，2007，26(5)：987-993. (HE Manchao，QI Gan，CHENG Ping，et al. Deformation and damage mechanisms and coupling support design in deep coal roadway with compound roof[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(5)：987-993.(in Chinese))
[7]	何满潮，陈新，梁国平，等. 深部软岩工程大变形力学分析设计系统[J]. 岩石力学与工程学报，2007，26(5)：934-943.(HE Manchao，CHEN Xin，LIANG Guoping，et al. Software system for large deformation mechanical analysis of soft rock engineering at great depth[J]. Chinese Journal of Rock Mechanics and Engineering，2007，26(5)：934-943.(in Chinese))
[9]	KANG H P，LIN J，WU Y Z. Development of high pretensioned and intensive supporting system and its application in coal mine roadways[J]. Procedia Earth and Planetary Science，2009，1(1)：479-485.
[10]	康红普，吴拥政，李建波. 锚杆支护组合构件的力学性能与支护效果分析[J]. 煤炭学报，2010，35(7)：1 057-1 065.(KANG Hongpu，WU Yongzheng，LI Jianbo. Analysis of mechanical performances and supporting function of combination components for rock bolting[J]. Journal of China Coal Society，2010，35(7)：1 057-1 065.(in Chinese)) " target="_blank">
[11]	康红普，王金华，林健. 高预应力强力支护系统及其在深部巷道中的应用[J]. 煤炭学报，2007，32(12)：1 233-1 238.(KANG Hongpu，WANG Jinhua，LIN Jian. High pretensioned stress and intensive bolting system and its application to deep roadways[J]. Journal of China Coal Society，2007，32(12)：1 233-1 238.(in Chinese)) " target="_blank">
[14]	高明仕，张农，郭春生，等. 三维锚索与巷帮卸压组合支护技术原理及工程实践[J]. 岩土工程学报，2005，27(5)：587-590.(GAO Mingshi，ZHANG Nong，GUO Chunsheng，et al. Mechanics and practice of combined supporting technology of 3D anchor-cable and unloading technology of wall of roadway[J]. Chinese Journal of Geotechnical Engineering，2005，27(5)：587-590.(in Chinese))
[15]	柏建彪，王襄禹，姚喆. 高应力软岩巷道耦合支护研究[J]. 中国矿业大学学报，2007，36(4)：421-425.(BAI Jianbiao，WANG Xiangyu，YAO Zhe. Study of coupling support in soft rock roadway under high stress[J]. Journal of China University of Mining and Technology，2007，36(4)：421-425.(in Chinese)) " target="_blank">
[16]	肖同强. 深部构造应力作用下厚煤层巷道围岩稳定与控制研究[博士学位论文][D]. 徐州：中国矿业大学，2011.(XIAO Tongqiang. Study on surrounding rock stability and control of deep roadway in thick coal seam under the action of tectonic stress[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，2011.(in Chinese)) " target="_blank">
[19]	马念杰，侯朝炯. 采准巷道矿压理论及应用[M]. 徐州：中国矿业大学出版社，1995：82-91.(MA Nianjie，HOU Chaojiong. Mining pressure theory and application to preparation roadway surrounding rock control[M]. Xuzhou：China University of Mining and Technology Press，1995：82-91.(in Chinese)) " target="_blank">
[12]	ZHANG N，WANG C，ZHAO Y M. Rapid development of coalmine bolting in China[J]. Procedia Earth and Planetary Science，2009，1(1)：41-46.
[13]	张农，高明仕. 煤巷高强预应力锚杆支护技术与应用[J]. 中国矿业大学学报，2004，33(4)：524-527.(ZHANG Nong，GAO Mingshi. High-strength and pretension bolting support of coal roadway and its application[J]. Journal of China University of Mining and Technology，2004，33(4)：524-527.(in Chinese)) " target="_blank">
[17]	LIU B，YUE Z Q，THAM L G. Analytical design method for a truss-bolt system for reinforcement of fractured coal mine roofs- illustrated with a case study[J]. International Journal of Rock Mechanics and Mining Sciences，2005，42(2)：195-218. " target="_blank">
[20]	钱鸣高，刘听成. 矿山压力及其控制[M]. 北京：煤炭工业出版社，1990：57-61.(QIAN Minggao，LIU Tingcheng. Mining pressure and control[M]. Beijing：China Coal Industry Publishing House，1990：57-61.(in Chinese)) " target="_blank">
[18]	陈兴和. 深井断层破碎带煤巷锚网梁索支护的研究[J]. 煤炭科技，2007，(1)：14-15.(CHEN Xinghe. Research on anchor mesh beam cable supporting for deep coal mine roadway in fault fracture zone[J]. Coal Science and Technology Magazine，2007，(1)：14-15.(in Chinese)) " target="_blank">