冲击荷载作用下岩石动态力学特性及破裂特征研究

doi:10.13722/j.cnki.jrme.2017.0539

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1400 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要采用分离式霍布金森压杆(split Hopkinson pressure bar，SHPB)试验系统对灰岩，白云岩和砂岩3类岩石进行动态冲击试验，得到岩石的动强度因子，耗散能密度及破碎尺寸与应变率的变化关系。在此基础上结合晶体离散元方法，采用高分辨率扫描和图像处理技术建立了晶体尺度试样模型，研究岩石材料高应变率力学特性和损伤特征。通过与室内SHPB试验对比，验证数值模拟的准确性。结果表明：岩石材料的动态屈服强度具有明显的率相关性，但弹性模量没有随应变率的增加而显著增加；在高应变率下，材料的动强度因子与应变率更符合Ханукаев公式；随着应变率的增加，岩石的破坏形态出现完整型→劈裂破坏→粉碎性破坏转化，这是由细观裂纹的激活数目以及裂纹间的相互作用关系所决定的。裂纹密度的变化和扩展路径的选择是材料动断裂机制，其宏观表现为材料的率效应和破碎成形。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李晓锋1
	2
	3
	李海波1
	刘凯2
	张乾兵2
	邹飞4
	黄理兴1
	ZHAO Jian2

关键词 ：岩石力学, 分离式霍布金斯压杆, 率效应, 细观离散元, 动态损伤及破碎

Abstract：Split Hopkinson pressure bar(SHPB) apparatus was used to study the factor of dynamic strength increasing，the density of dissipation energy and the fragment size of limestone，dolomite and sandstone subject to impact loading. SHPB has some difficulties to measure the higher strain rate and dynamic damage process for rock materials. The grain-based model was thus built by using the high resolution scanning and image processing technique combined with the discrete element method. The accuracy of numerical simulation was verified with the experimental SHPB results. The results indicated that the dynamic failure strength of rock material was rate dependent strongly，but the elastic modulus did not increase significantly with the increasing strain rate. The semi-empirical formula for evaluating the factor of dynamic strength increasing is consistent with the Ханукаев equation. The failure pattern of the rock transforms from the intact→splitting damage→pulverized damage with the increasing strain rate. This phenomenon is determined by the number of the micro cracks activated and the interaction between the cracks. The increase of the crack density and the change of the crack propagation path are the mechanism of the dynamic fracture of the rock，and the macrosopic responses are the rate effect and fragmentation of the material.

Key words： rock mechanics split Hopkinson pressure bar(SHPB) rate dependency micro discrete element method dynamic damage and fragment

引用本文:

李晓锋1，2，3，李海波1，刘凯2，张乾兵2，邹飞4，黄理兴1，ZHAO Jian2. 冲击荷载作用下岩石动态力学特性及破裂特征研究[J]. 岩石力学与工程学报, 2017, 36(10): 2393-2405.
LI Xiaofeng1，2，3，LI Haibo1，LIU Kai2，ZHANG Qianbing2，ZOU Fei4，HUANG Lixing1，ZHAO Jian2. Dynamic properties and fracture characteristics of rocks subject to impact loading. , 2017, 36(10): 2393-2405.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2017.0539 或 https://rockmech.whrsm.ac.cn/CN/Y2017/V36/I10/2393

[1] 王礼立. 爆炸与冲击载荷下结构和材料动态响应研究的新进展[J]. 爆炸与冲击，2001，21(2)：81–88.(WANG Lili. Progress in studies on dynamic response of structures and materials under explosive/impact loading[J]. Explosion and Shock Waves，2001，21(2)：81–88.(in Chinese))
[2] 黄理兴. 岩石动力学研究成就与趋势[J]. 岩土力学，2011，32(10)： 2 889–2 900.(HUANG Lixing. Development and new achievements of rock dynamics in China[J]. Rock and Soil Mechanics，2011，32(10)：2 889–2 900.(in Chinese))
[3] LINDHOLM U S. High strain rate tests[J]. Measurement of Mechanical Properties，1971，5(Part 1)：199–271.
[4] NEMAT-NASSER S. Introduction to high strain rate testing[J]. Mechanical testing and evaluation，2000：427–428.
[5] ZHANG Q B，ZHAO J. A review of dynamic experimental techniques and mechanical behaviour of rock materials[J]. Rock Mechanics and Rock Engineering，2014，47(4)：1 411–1 478.
[6] FIELD J E，WALLEY S M，PROUD W G，et al. Review of experimental techniques for high rate deformation and shock studies[J]. International Journal of Impact Engineering，2004，30(7)：725–775.
[7] LOGAN J M，HANDIN J. Triaxial compression testing at intermediate strain rates[C]// The 12th US Symposium on Rock Mechanics (USRMS). [S.l.]：American Rock Mechanics Association，1970：167–194.
[8] ZHANG Q. Mechanical behaviour of rock materials under dynamic loading[Ph. D. Thesis][D]. [S.l.]：École Polytechnique Fédérale de Lausanne EPFL，2014.
[9] ZHOU Y X，XIA K，LI X B，et al. Suggested methods for determining the dynamic strength parameters and mode-I fracture toughness of rock materials[C]// The ISRM Suggested Methods for Rock Characterization，Testing and Monitoring：2007–2014. [S.l.]：Springer International Publishing，2011：35–44.
[10] ATTEWELL P B. Response of rocks to high velocity impact[J]. Transactions of the Institution of Mining and Metallurgy，1962，71：705–24.
[11] KUMAR A. The effect of stress rate and temperature on the strength of basalt and granite[J]. Geophysics，1968，33(3)：501–510.
[12] HAKALEHTO K O. Brittle fracture of rocks under impulse loads[J]. International Journal of Fracture，1970，6(3)：249–256.
[13] OLSSON W A. The compressive strength of tuff as a function of strain rate from 10−6 to 103/sec[C]// International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts. Pergamon：[s.n.]，1991，28(1)：115–118.
[14] CHOCRON S，DANNEMANN K A，NICHOLLS A，et al. Apache Leap tuff rock：High strain rate characterization and support simulations[C]// EURODYMAT 2006–8th International Conference on Mechanical and Physical Behaviour of Materials under Dynamic Loading. [S.l.]：Journal de Physique IV France，2006，134：565–570.
[15] GOLDSMITH W，SACKMAN J L，EWERTS C. Static and dynamic fracture strength of Barre granite[C]// International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts. Pergamon：[s.n.]，1976，13(11)：303–309.
[16] ZHAO J，ZHOU Y X，HEFNY A M，et al. Rock dynamics research related to cavern development for ammunition storage[J]. Tunnelling and Underground Space Technology，1999，14(4)：513–526.
[17] FREW D J，FORRESTAL M J，CHEN W. A split Hopkinson pressure bar technique to determine compressive stress-strain data for rock materials[J]. Experimental Mechanics，2001，41(1)：40–46.
[18] SHAN R，JIANG Y，LI B. Obtaining dynamic complete stress–strain curves for rock using the split Hopkinson pressure bar technique[J]. International Journal of Rock Mechanics and Mining Sciences，2000，37(6)：983–992.
[19] GOMEZ J T，SHUKLA A. Static and dynamic behavior of damaged concrete and granite in compression[J]. Journal of Testing and Evaluation，2001，29(6)：563–569.
[20] KIM D S，MCCARTER M K. Quantitative assessment of extrinsic damage in rock materials[J]. Rock Mechanics and Rock Engineering，1998，31(1)：43–62.
[21] LIU X，LI X，HONG L，et al. Acoustic emission characteristics of rock under impact loading[J]. Journal of Central South University，2015，22(9)：3 571–3 577.
[22] 王其胜，万国香，李夕兵. 动静组合加载下岩石破坏的声发射实验[J]. 爆炸与冲击，2010，30(3)：247–253.(WANG Qisheng，WAN Guoxiang，LI Xibin. Acoustic emission experiment of rock failure under coupled static-dynamic load[J]. Explosion and Shock Waves，2010，30(3)：247–253.(in Chinese))
[23] 万国香，王其胜，李夕兵. 应力波作用下岩石声发射能量特征[J]. 实验力学，2012，(6)：727–733.(WAN Guoxiang，WANG Qisheng，LI Xibin. On the acoustic emission(AE) energy characteristics of rock subjected to stress waves[J]. Journal of Experimental Mechanics，2012，(6)：727–733.(in Chinese))
[24] HUANG S，XIA K，ZHENG H. Observation of microscopic damage accumulation in brittle solids subjected to dynamic compressive loading[J]. Review of Scientific Instruments，2013，84(9)：093903.
[25] HAO Y，HAO H. Numerical investigation of the dynamic compressive behaviour of rock materials at high strain rate[J]. Rock Mechanics and Rock Engineering，2013，46(2)：373–388.
[26] ZHU W C，BAI Y，LI X B，et al. Numerical simulation on rock failure under combined static and dynamic loading during SHPB tests[J]. International Journal of Impact Engineering，2012，49：142–157.
[27] LIAO Z Y，ZHU J B，XIA K W，et al. Determination of dynamic compressive and tensile behavior of rocks from numerical tests of split Hopkinson pressure and tension bars[J]. Rock Mechanics and Rock Engineering，2016，49(10)：3 917–3 934.
[28] ZHU J B，LIAO Z Y，TANG C A. Numerical SHPB tests of rocks under combined static and dynamic loading conditions with application to dynamic behavior of rocks under in situ stresses[J]. Rock Mechanics and Rock Engineering，2016，49(10)：3 935–3 946.
[29] WANG Y，TONON F. Dynamic validation of a discrete element code in modeling rock fragmentation[J]. International Journal of Rock Mechanics and Mining Sciences，2011，48(4)：535–545.
[30] LI X，ZOU Y，ZHOU Z. Numerical simulation of the rock SHPB test with a special shape striker based on the discrete element method[J]. Rock Mechanics and Rock Engineering，2014，47(5)：1 693–1 709.
[31] XU Y，DAI F，XU N W，et al. Numerical investigation of dynamic rock fracture toughness determination using a semi-circular bend specimen in split Hopkinson pressure bar testing[J]. Rock Mechanics and Rock Engineering，2016，49(3)：731–745.
[32] CHO N，MARTIN C D，SEGO D C. A clumped particle model for rock[J]. International Journal of Rock Mechanics and Mining Sciences，2007，44(7)：997–1 010.
[33] POTYONDY D O，CUNDALL P A. A bonded-particle model for rock[J]. International Journal of Rock Mechanics and Mining Sciences，2004，41(8)：1 329–1 364.
[34] LANKFORD J. The role of tensile microfracture in the strain rate dependence of compressive strength of fine-grained limestone—analogy with strong ceramics[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1981，18(2)：173–175.
[35] GRADY D E，LIPKIN J. Criteria for impulsive rock fracture[J]. Geophysical Research Letters，1980，7(4)：255–258.
[36] LIU D Z. Ore-bearing rock blasting physical process[M]. Beijing：Metallurgical Industry Press，1980：428–433.
[37] GARY G，BAILLY P. Behaviour of quasi-brittle material at high strain rate. Experiment and modelling[J]. European Journal of Mechanics- A/Solids，1998，17(3)：403–420.
[38] MASUDA K，MIZUTANI H，YAMADA I. Experimental study of strain-rate dependence and pressure dependence of failure properties of granite[J]. Journal of Physics of the Earth，1987，35(1)：37–66.
[39] ZHAO J，LI H B，WU M B，et al. Dynamic uniaxial compression tests on a granite[J]. International Journal of Rock Mechanics and Mining Sciences，1999，36(2)：273–277.
[40] GRADY D E，KIPP M E. Continuum modelling of explosive fracture in oil shale[C]// International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts. Pergamon：[s.n.]，1980，17(3)：147–157.
[41] GRADY D E. Local inertial effects in dynamic fragmentation[J]. Journal of Applied Physics，1982，53(1)：322–325.
[42] LI X F，LI H B，LIU Y Q，et al. Numerical simulation of rock fragmentation mechanisms subject to wedge penetration for TBMs[J]. Tunnelling and Underground Space Technology，2016，53(3)：96–108.