三合土表面微生物诱导碳酸钙沉淀耐水性试验研究

doi:10.13722/j.cnki.jrme.2018.0734

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (739 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要水害是引起土遗址表面侵蚀的最主要因素之一，利用微生物诱导碳酸钙沉淀(MICP)技术在三合土材料表面形成耐水保护层，以达到提高三合土材料耐水性的目的。通过静态接触角试验、毛细吸水试验、Karsten管试验、耐久性试验、耐酸性试验、水蒸气渗透性试验和表面颜色变化试验评估碳酸钙保护层对三合土材料的保护效果，并分析细菌和胶结液浓度对保护效果的影响。试验结果表明，微生物诱导的碳酸钙沉淀通过改变土样表面的微观结构，可大幅度提高其耐水性；较高的细菌和胶结液浓度可以使沉淀层起到较佳的保护作用，但其影响并不是线性的，细菌溶液存在一个适宜浓度，小于该浓度时，细菌浓度的改变对处理试样的耐水性影响较大，当超过该浓度时，细菌浓度的改变对处理试样的耐水性影响并不明显，细菌适宜浓度的发现可以在保证MICP技术工程实际应用效果的同时，提高其经济性；微生物诱导的碳酸钙沉淀保护层不仅耐久性良好，而且对样品本身的透气性和颜色影响较小。MICP技术可作为缓解土遗址表层风化的有效方法。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	刘士雨1
	2
	俞缙1
	2
	韩亮1
	2
	蔡燕燕1
	2
	涂兵雄1
	2
	周建烽1
	2

关键词 ：土力学, 土遗址, 表面侵蚀, 微生物, 碳酸钙保护层, 耐水性

Abstract：Water is one of the most important factors causing surface erosion of earthen sites. In this study，microbially induced carbonate precipitation(MICP) technique was used to form a water-resistant layer on the surface of tabia，and the applicability of MICP for tabia surface erosion control was examined by the static contact angle test，capillary water absorption test，Karsten tube test，durability test，acid resistance test，water vapor permeability test and surface color change test in the laboratory. The effect of the concentration of bacteria and cementation solution on the surface erosion control was analyzed. The test results show that MICP can significantly improve the water resistance of soil samples by changing the microstructure of the surface. A higher concentration of bacteria and cementation solution can make the sediment layer play a better protection in a non-linear form. There is a suitable concentration value of the bacterial solution. When the bacterial concentration is less than the value，the change of the concentration has a great influence on the water resistance of the treated samples. However，the change of the bacterial concentration greater than the value has no obvious effect. The discovery of suitable concentration value can improve the economics of MICP technology on the premise of successful application of MICP in practice. The MICP protection layer not only has good durability，but also has little negative impact on the air permeability and color of the samples. MICP can be used as an effective method to relieve surface erosion of earthen sites.

Key words： soil mechanics earthen sites surface erosion microorganism calcium carbonate protective layer water resistance

引用本文:

刘士雨1，2，俞缙1，2，韩亮1，2，蔡燕燕1，2，涂兵雄1，2，周建烽1，2. 三合土表面微生物诱导碳酸钙沉淀耐水性试验研究[J]. 岩石力学与工程学报, 2019, 38(8): 1718-1728.
LIU Shiyu1，2，YU Jin1，2，HAN Liang1，2，CAI Yanyan1，2，TU Bingxiong1，2，ZHOU Jianfeng1，2. Experimental study on water resistance of tabia surface with microbially induced carbonate precipitation. , 2019, 38(8): 1718-1728.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2018.0734 或 http://www.rockmech.org/CN/Y2019/V38/I8/1718

[8]	BELIE D N. Microorganisms versus stony materials：a love-hate relationship[J]. Materials and Structures，2010，43(9)：1 191-1 202.
[7]	SIDDIQUE R，CHAHAL N K. Effect of ureolytic bacteria on concrete properties[J]. Construction and Building Materials，2011，25(10)：3 791- 3 801.
[17]	黄明，张瑾璇，靳贵晓，等. 残积土MICP 灌浆结石体冻融损伤的核磁共振特性试验研究[J]. 岩石力学与工程学报，2018，37(12)：2 846-2 855.(HUANG Ming，ZHANG Jinxuan，JIN Guixiao，et al. Magnetic resonance image experiments on the damage feature of microbial induced calcite precipitated residual soil during freezing-thawing cycles[J]. Chinese Journal of Rock Mechanics and Engineering，2018，37(12)：2 846-2 855.(in Chinese))
[19]	QIAN C，WANG J，WANG R，et al. Corrosion protection of cement-based building materials by surface deposition of CaCO3 by Bacillus pasteurii[J]. Materials Science and Engineering C，2009，29：1 273-1 280.
[22]	YANG Z，CHENG X H. A performance study of high-strength microbial mortar produced by low pressure grouting for the reinforcement of deteriorated masonry structures[J]. Construction and Building Materials，2013，41：505-515.
[24]	MUYNCK D W，LEURIDAN S，VAN L D，et al. Influence of pore structure on the effectiveness of a biogenic carbonate surface treatment for limestone conservation[J]. Applied and Environmental Microbiology，2011，77：6 808-6 820.
[27]	宋应星，潘吉星. 天工开物[M]. 上海：上海古籍出版社，2008：208-209.(SONG Yingxing，PANG Jixing. Tian gong kai wu[M]. Shanghai：Shanghai Classics Publishing House，2008：208-209.(in Chinese))
[29]	American Society for Testing Materials. ASTM D1557. Standard test methods for laboratory compaction characteristics of soil using modified effort[S]. West Conshohocken(PA)：ASTM International，2009.
[37]	ALLINSON D，HALL M. Hygrothermal analysis of a stabilised rammed earth test building in the UK[J]. Energy Build，2010，42(6)：845-852.
[39]	SOUDANI L，FABBRI A，MOREL J C，et al. Assessment of the validity of some common assumptions in hygrothermal modeling of earth based materials[J]. Energy Build，2016，116：498-511.
[2]	UNESCO. Fujian Tulou，in：World Heritage Convention(WHC) Advisory Body Evaluation Report[R]. Paris：UNESCO World Heritage Centre，2008.
[12]	何稼，楚剑，刘汉龙，等. 微生物岩土技术的研究进展[J]. 岩土工程学报，2016，38(4)：643-653.(HE Jia，CHU Jian，LIU Hanlong，et al. Research advances in biogeotechnologies[J]. Chinese Journal of Geotechnical Engineering，2016，38(4)：643-653.(in Chinese))
[5]	STAZI F，NACCI A，TITTARELLI F，et al. An experimental study on earth plasters for earthen building protection：The effects of different admixtures and surface treatments[J]. Journal of Cultural Heritage，2016，17：27-41.
[15]	刘汉龙，肖鹏，肖杨，等. MICP胶结钙质砂动力特性试验研究[J]. 岩土工程学报，2018，40(1)：38-45.(LIU Hanlong，XIAO Peng，XIAO Yang，et al. Dynamic behaviors of MICP-treated calcareous sand in cyclic tests[J]. Chinese Journal of Geotechnical Engineering，2018，40(1)：38-45.(in Chinese))
[25]	STANISLAWSKI D. Structural responses and finite element modeling of Hakka Tulou rammed earth structures[M. S. Thesis][D]. Virginia，USA：West Virginia University，2011.
[35]	American Society for Testing Materials. ASTM E96M—2005. Standard test methods for water vapor transmission of materials[S]. West Conshohocken(PA)：ASTM International，2005.
[1]	YANG R W，ZHANG Z L，XIE M J，et al. Microstructural insights into the lime mortars mixed with sticky rice sol-gel or water：A comparative study[J]. Construction and Building Materials，2016，125：974-980.
[11]	ACHAL V，MUKHERJEE A. A review of microbial precipitation for sustainable construction[J]. Construction and Building Materials，2015，93：1 224-1 235.
[21]	SOURADEEP G，DAI P S，WEI K H. Autonomous healing in concrete by bio-based healing agents-A review[J]. Construction and Building Materials，2017，146：419-428.
[31]	Reunion Internationale des Laboratoires D?Essais et de Recherches sur les Materiaux et les Constructions(RILEM). Recommandations provisoires de lacommission 25-PEM Protection et erosion des monuments Essais recom-mandés pour mesurer l’altération des pierres et évaluer l’efficacité desméthodes de traitement[C]// Matériaux de Constructions，Paris：RILEM，1980：255-264.
[41]	KAPRIDAKI C，MARAVELAKI P. TiO2-SiO2-PDMS nano- composite hydrophobic coating with self-cleaning properties for marble protection[J]. Progress in Organic Coatings，2013，76：400-410.
[3]	YAND R W，LI K，WANG L，et al. A micro-experimental insight into the mechanical behavior of sticky rice slurry-lime mortar subject to wetting-drying cycles[J]. Journal of Materials Science，2016，51(18)：8 422-8 433.
[13]	程晓辉，麻强，杨钻，等. 微生物灌浆加固液化砂土地基的动力反应研究[J]. 岩土工程学报，2013，35(8)：1 486-1 495.(CHENG Xiaohui，MA Qiang，YANG Zuan，et al. Dynamic response of liquefiable sand foundation improved by bio-grouting[J]. Chinese Journal of Geotechnical Engineering，2013，35(8)：1 486-1 495.(in Chinese))
[23]	MUYNCK D W，VERBEKEN K，BELIE D N，et al. Influence of urea and calcium dosage on the effectiveness of bacterially induced carbonate precipitation on limestone[J]. Ecological Engineering，2009，36：99-111.
[33]	MOREL J C，BUI Q B，HAMARD E. Weathering and durability of earthen materials and structures[C]// HALL M，LINDSAY R，KRAYENHOFF M，ed. Modern Earth Buildings，Materials，Engineering，Construction and Applications. UK，Sawston：Woodhead Publishing Limited，2012：282-303.
[10]	钱春香，任立夫，罗勉. 基于微生物诱导矿化的混凝土表面缺陷及裂缝修复技术研究进展[J]. 硅酸盐学报，2015，43(5)：619-631.(QIAN Chunxiang，REN Lifu，LUO Mian. Development of concrete surface defects and cracks repair technology based on microbial-induced mineralization[J]. Journal of the Chinese Ceramic Society，2015，43(5)：619-631.(in Chinese))
[20]	荣辉，钱春香，张磊，等. 微生物水泥的胶结过程[J]. 硅酸盐学报，2015，43(8)：1 067-1 075.(RONG Hui，QIAN Chunxiang，ZHANG Lei. Cementation process of microbe cement[J]. Journal of the Chinese Ceramic Society，2015，43(8)：1 067-1 075.(in Chinese))
[30]	中华人民共和国国家标准编写组. GB/T50082—2009普通混凝土长期性能和耐久性能试验方法标准[S]. 北京：中国建筑工业出版社，2009.(The National Standards Compilation Group of People?s Republic of China. GB/T50082—2009 Standard for test methods of long-term performance and durability of ordinary concrete[S]. Beijing：China Architecture and Building Press，2009.(in Chinese))
[40]	SOUDANI L，WOLOSZYN M，FABBRI A，et al. Energy evaluation of rammed earth walls using long term in-situ measurements[J]. Solar Energy，2017，141：70-80.
[4]	YAND R W，LEMARCHAND E，CHONG T F，et al. A micromechanics model for partial freezing in porous media[J]. International Journal of Solids and Structures，2015，75：109-121.
[6]	YANG F，ZHANG B，MA Q. Study of sticky rice-lime mortar technology for the restoration of historical masonry construction[J]. Accounts of Chemical Research，2010，43(6)：936-944.
[9]	MUYNCK D W，BELIE D N，VERSTRAETE W. Microbial carbonate precipitation in construction materials：a review[J]. Ecological Engineering，2010，36(2)：118-136.
[14]	方祥位，申春妮，楚剑，等. 微生物沉积碳酸钙固化珊瑚砂的试验研究[J]. 岩土力学，2015，36(10)：2 773-2 779.(FANG Xiangwei，SHEN Chunni，CHU Jian，et al. An experimental study of coral sand enhanced through microbially-induced precipitation of calcium carbonate[J]. Rock and Soil Mechanics，2015，36(10)：2 773-2 779. (in Chinese))
[16]	孙潇昊，缪林昌，童天志，等. 砂土微生物固化过程中尿素的影响研究[J]. 岩土工程学报，2018，40(5)：939-944.(SUN Xiaohao，MIAO Linchang，TONG Tianzhi，et al. Effect of methods of adding urea in culture media on sand solidification tests[J]. Chinese Journal of Geotechnical Engineering，2018，40(5)：939-944.(in Chinese))
[18]	李驰，王硕，王燕星，等. 沙漠微生物矿化覆膜及其稳定性的现场试验研究[J]. 岩土力学，2019，40(4)：1-8.(LI Chi，WANG Shuo，WANG Yanxing，et al. Field experimental study on stability of bio-mineralization crust in ulanbuh desert，Inner Mongolia of China[J]. Rock and Soil Mechanics，2019，40(4)：1-8.(in Chinese))
[28]	American Society for Testing Materials. ASTM D3551. Standard practice for laboratory preparation of soil-lime mixtures using mechanical mixer[S]. West Conshohocken(PA)：ASTM International，2008.
[38]	PACHECO F，JALALI S. Earth construction：Lessons from the past for future eco-efficient construction[J]. Construction and Building Materials，2012，29：512-519.
[26]	中华人民共和国行业标准编写组. SL237—1999土工试验规程[S]. 北京：中国水利水电出版社，1999.(The Professional Standards Compilation Group of People?s Republic of China. SL237—1999 Specification of soil test[S]. Beijing：China Water Power Press，1999.(in Chinese))
[32]	American Society for Testing Materials. ASTM D559/D559M-15 Standard test methods for wetting and drying compacted soil-cement mixtures[S]. West Conshohocken(PA)：ASTM International，2015.
[34]	刘强，张秉坚. 石质文物表面生物矿化保护材料的仿生制备[J]. 化学学报，2006，64(15)：1 601-1 605.(LIU Qiang，ZHANG Bingjian. Bioinspired preparation of a protective biomineralized material on the surfaces of historic stones[J]. Acta Chimica Sinica，2006，64(15)：1 601-1 605.(in Chinese))
[36]	KOCH K，BHUSHAN B，BARTHLOTT W. Diversity of structure，morphology and wetting of plant surfaces[J]. Soft Matter，2008， 4(10)：1 943-1 963.
[42]	PINHO L，MOSQUERA M J. Titania-Silica nanocomposite photocatylysts withapplication in stone self-cleaning[J]. The Journal of Physical Chemistry C，2011，115：22 851-22 862.