桥桩钢套管施工引起地铁隧道纵向变形计算研究

doi:10.13722/j.cnki.jrme.2021.0405

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (784 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要依托杭州某桥梁试桩邻近地铁隧道建设工程，建立桥桩钢套管施工简化力学模型，提出考虑套管分节施工特点与挤土效应影响的全套管灌注桩施工附加力的修正计算公式。同时，基于Mindlin应力解和两阶段分析法，求解桥桩施工引起的既有隧道附加应力与纵向竖向变形，并进一步分析桥桩施工全过程的动态影响规律。得出以下结论：(1) 引入土塞高度折减系数和区段修正分别对桩端压力、桩侧径向压力和桩侧垂向摩阻力进行修正，更符合桥桩钢套管施工附加力的分布规律。(2) 桥桩钢套管施工引起地铁隧道纵向变形的理论计算结果与实测数据对比验证较为吻合。(3) 随着桥桩钢套管施工深度的不断增加，既有隧道先小幅隆起而后沉降变大，随后趋于平稳，且纵向沉降区进一步扩大。施工到达隧道埋深附近时引起隧道隆起最大，隆沉交界点位于隧道底部1.5D深度范围。(4) 桩侧垂向摩阻力是引起既有隧道变形的关键性因素，并随施工深度增加而影响扩大；桩端压力在施工远离隧道埋深一定范围后影响减弱；桩侧径向压力对隧道竖向变形的影响甚微。(5) 桥桩施工全过程中不仅要关注隧道最大竖向变形的发展，而且要留意随施工深度改变产生的隧道纵向隆沉变化以及管片纵向错台变形。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	丁智1
	张霄1
	2
	张默爆3
	董毓庆1
	刘坤涛4
	夏能武4

关键词 ：隧道工程, 桥桩, 钢套管, 地铁隧道, 纵向变形, 施工过程

Abstract：Relying on the construction project of a test bridge pile adjacent to a subway tunnel in Hangzhou，a simplified mechanical model of the steel casing construction of bridge piles is established，and a revised calculation formula for the additional force resulted from the construction of the full-pipe cast-in-place piles considering the construction characteristics of casing sections and the effect of soil squeezing is proposed. At the same time，based on the Mindlin stress solution and two-stage analysis method，the additional stress and longitudinal vertical deformation of the existing tunnel caused by the construction of the bridge piles are calculated，and the dynamic influence law of the whole process of construction of the bridge piles is further analyzed. The following conclusions are drawn：(1) The application of the reduction factor of the soil plug height and the section correction to respectively calculate the pile tip pressure，the pile side radial pressure and the pile side vertical friction is more in line with the distribution law of the additional force due to bridge pile steel casing construction. (2) The theoretical calculation results of the longitudinal deformation of the subway tunnel caused by the construction of the bridge pile steel casing are more consistent with the actual measurement data. (3) With continuously increasing the construction depth of the bridge pile steel casing，the existing tunnels first uplift slightly，then subside and finally tend to be stable，accompanied by the longitudinal settlement area further expanding. When the construction reaches near the buried depth of the tunnel，the tunnel reaches the maximum uplift，and the junction of uplift and settlement is located at the depth of 1.5D at the bottom of the tunnel. (4) The pile side vertical friction is a key factor that causes the deformation of the existing tunnel，and the influence will expand with the construction depth. The influence of the pile tip pressure will weaken after the construction is far away from the tunnel buried depth for a certain range, and the pile side radial pressure has little effect on the vertical deformation of the tunnel. (5) During the whole process of construction of bridge piles，attention should be paid not only to the development of the maximum vertical deformation of the tunnel，but also to the longitudinal heave change of the tunnel and the longitudinal dislocated deformation of the segments due to changes in the construction depth.

Key words： tunnelling engineering')" href="#">

tunnelling engineering bridge pile steel casing subway tunnel longitudinal deformation construction process

引用本文:

丁智1，张霄1，2，张默爆3，董毓庆1，刘坤涛4，夏能武4. 桥桩钢套管施工引起地铁隧道纵向变形计算研究[J]. 岩石力学与工程学报, 2022, 41(4): 836-848.
DING Zhi1，ZHANG Xiao1，2，ZHANG Mobao3，DONG Yuqing1，LIU Kuntao4，XIA Nengwu4. Computational research on longitudinal deformation of subway tunnels caused by steel casing construction of bridge piles. , 2022, 41(4): 836-848.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2021.0405 或 http://rockmech.whrsm.ac.cn/CN/Y2022/V41/I4/836

[26]	ATTEWELL P B，YEATES J，SELBY A R. Soil movements induced by tunneling and their effects on pipelines and structures[M]. London：Blackie and Son Ltd.，1986：325.
[10]	杨平，周志良，黄晓东，等. 钻孔灌注桩施工对邻近既有隧道影响数值分析[J]. 沈阳建筑大学学报：自然科学版，2020，36(6)：1 064-1 073.(YANG Ping，ZHOU Zhiliang，HUANG Xiaodong，et al. Numerical analysis on influence of adjacent operated tunnel caused by bored pile construction[J]. Journal of Shenyang Jianzhu University：Natural Science，2020，36(6)：1 064-1 073.(in Chinese))
[20]	POTYONDY J G. Skin friction between various soils and construction materials[J]. Géotechnique，1961，11(4)：339-353.
[2]	闫静雅. 桩基础全寿命期对邻近已有隧道的影响研究[博士学位论文][D]. 上海：同济大学，2007.(YAN Jingya. The influence of pile foundation in life-cycle on adjacent existing tunnel[Ph. D. Thesis][D]. Shanghai：Tongji University，2007.(in Chinese))
[5]	丁智，王永安，虞兴福，等. 近距离桥桩施工对地铁隧道影响监测分析[J]. 现代隧道技术，2016，53(1)：173-179.(DING Zhi，WANG Yong¢an，YU Xingfu，et al. Monitoring and analysis of the impact of adjacent bridge pile construction on subway tunnels[J]. Modern Tunnelling Technology，2016，53(1)：173-179.(in Chinese))
[7]	YOO C. Three-dimensional numerical investigation on the effect of bridge construction on existing tunnel[J]. KSCE Journal of Civil Engineering，2014，18(3)：794-802.
[12]	周志良，仇欢，黄晓东，等. 钻孔灌注桩施工对邻近运营隧道变形影响研究[J]. 岩土工程技术，2021，35(1)：1-6.(ZHOU Zhiliang，QIU Huan，HUANG Xiaodong，et al. Impact of bored pile construction on deformation of adjacent operating tunnel[J]. Geotechnical Engineering Technique，2021，35(1)：1-6.(in Chinese))
[15]	黄大维，周顺华，刘重庆，等. 护壁套管钻孔灌注桩微扰动施工分析[J]. 岩土力学，2013，34(4)：1 103-1 108.(HUANG Dawei，ZHOU Shunhua，LIU Chongqing，et al. Analysis of small disturbing construction of protective jacket tube for cast-in-situ bored pile[J]. Rock and Soil Mechanics，2013，34(4)：1 103-1 108.(in Chinese))
[17]	靳军伟，李咏梅，孟潮，等. 桩基础影响下既有地铁隧道截面内力计算研究[J]. 防灾减灾工程学报，2020，40(2)：152-159.(JIN Junwei，LI Yongmei，MENG Chao，et al. Subway tunnel section inner force induced by pile foundation[J]. Journal of Disaster Prevention and Mitigation Engineering，2020，40(2)：152-159.(in Chinese))
[8]	吕宝伟. 超临界桥桩基施工对既有隧道影响数值与实测分析[J]. 铁道标准设计，2017，61(3)：103-107.(LV Baowei. Monitoring and numerical analysis of the impact of supercritical bridge pile foundation on existing tunnel[J]. Railway Standard Design，2017，61(3)：103-107.(in Chinese))
[18]	贺雷，张洋，马山青. 静压沉桩引起邻近隧道水平位移计算方法研究[J]. 岩土力学，2020，41(11)：3 740-3 747.(HE Lei，ZHANG Yang，MA Shanqing. A study on the calculation method of horizontal displacement of adjacent tunnels caused by static pressure sinking piles[J]. Rock and Soil Mechanics，2020，41(11)：3 740-3 747.(in Chinese))
[28]	志波由纪夫，川島一彦，大日方尚己，等. ツールドトンネルの耐震解析に用いる長手方向覆工剛性の評価法[C]// 土木學會論文集. [S. l.]：[s. n.]，1988：319-327.(in Japanese))
[25]	LIU X，FANG Q，ZHANG D L，et al. Behaviour of existing tunnel due to new tunnel construction bellow[J]. Computers and Geotechnics，2019，110：71-81.
[3]	中华人民共和国行业标准编写组. DB33/T 1139—2017城市轨道交通结构安全保护技术规程[S]. 北京：中国建筑工业出版社，2017.(The Professional Standards Compilation Group of People¢s Republic of China. DB33/T 1139—2017 Technical regulations for safety protection of urban rail transit structure[S]. Beijing：China Architecture and Building Press，2017.(in Chinese))
[6]	张超，杨龙才，黄大维，等. 钢套管施工对地铁隧道影响分析及变形控制研究[J]. 岩石力学与工程学报，2013，32(增2)：3 584-3 591.(ZHANG Chao，YANG Longcai，HUANG Dawei，et al. Effect of steel casing construction on metro tunnel and deformation control[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(Supp.2)：3 584-3 591.(in Chinese))
[13]	徐云福，王立峰. 近邻桩基施工对城市地铁隧道的影响分析[J]. 岩土力学，2015，36(增2)：577-582.(XU Yunfu，WANG Lifeng. Analysis of effects on city metro tunnel due to adjacent pile foundation construction[J]. Rock and Soil Mechanics，2015，36(Supp.2)：577-582.(in Chinese))
[1]	丁智，张霄，周联英，等. 近距离桥桩与地铁隧道相互影响研究及展望[J]. 浙江大学学报：工学版，2018，52(10)：1 943-1 953. (DING Zhi，ZHANG Xiao，ZHOU Lianying，et al. Research and prospect of interaction between close bridge pile and metro tunnel[J]. Journal of Zhejiang University：Engineering Science，2018，52(10)：1 943-1 953.(in Chinese))
[4]	庄妍，牟凡，崔晓艳，等. 全套管灌注桩在临近地铁隧道的暗桥桩基工程中的应用[J]. 岩土工程学报，2015，37(增2)：41-45. (ZHUANG Yan，MU Fan，CUI Xiaoyan，et al. Application of Benoto pile in concealed bridge piled project near subway[J]. Chinese Journal of Geotechnical Engineering，2015，37(Supp.2)：41-45.(in Chinese))
[9]	路平，郑刚. 立交桥桩基础施工及运营期对既有隧道影响的研究[J]. 岩土工程学报，2013，35(增2)：923-927.(LU Ping，ZHENG Gang. Influence of construction and operation of pile foundation of overpass on existing tunnels[J]. Chinese Journal of Geotechnical Engineering，2013，35(Supp.2)：923-927.(in Chinese))
[11]	丁智，何奇威，叶星宇，等. 桥桩施工对邻近既有地铁隧道影响实测研究[J]. 铁道工程学报，2018，(9)：80-87.(DING Zhi，HE Qiwei，YE Xingyu，et al. Research on the influence of bridge pile construction on adjacent existing metro tunnels[J]. Journal of Railway Engineering Society，2018，(9)：80-87.(in Chinese))
[14]	丁智，张霄. 桩基施工对邻近既有地铁隧道影响的数值分析[J]. 中南大学学报：自然科学版，2019，50(2)：390-399.(DING Zhi，ZHANG Xiao. Numerical analysis of influence of pile foundation construction on adjacent metro tunnel[J]. Journal of Central South University：Science and Technology，2019，50(2)：390-399.(in Chinese))
[16]	HEAMA N，JONGPRADIST P，LUEPRASERT P，et al. Investigation on tunnel responses due to adjacent loaded pile by 3D finite element analysis[J]. International Journal of Geomate，2017，12(31)：63-70.
[19]	黄大维，周顺华，宫全美，等. 钢管压入土体施工挤土机制与案例分析[J]. 岩石力学与工程学报，2013，32(1)：176-183.(HUANG Dawei，ZHOU Shunhua，GONG Quanmei，et al. Analysis of squeezing mechanism for jacked-in construction of steel pipe and project case[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(1)：176-183.(in Chinese))
[21]	张明义，静力压入桩的研究与应用[M]. 北京：中国建材工业出版社，2004：20-51.(ZHANG Mingyi. Research and application of statically pressed piles[M]. Beijing：Chinese Building Materials Industry Publication，2004：20-51.(in Chinese))
[22]	宋志彬. 全套管钻进套管柱损坏机理与应用技术研究[硕士学位论文][D]. 北京：中国地质大学，2013.(SONG Zhibin. Damage mechanism of the casing string and applied research of full casing drilling method[M. S. Thesis][D]. Beijing：China University of Geosciences，2013.(in Chinese))
[27]	HUANG M S，ZHOU X C，YU J，et al. Estimating the effects of tunnelling on existing jointed pipelines based on Winkler model[J]. Tunnelling and Underground Space Technology，2019，86：89-99.
[29]	叶飞，何川，朱合华，等. 考虑横向性能的盾构隧道纵向等效刚度分析[J]. 岩土工程学报，2011，33(12)：1 870-1 876.(YE Fei，HE Chuan，ZHU Hehua，et al. Longitudinal equivalent rigidity analysis of shield tunnel considering transverse characteristics[J]. Chinese Journal of Geotechnical Engineering，2011，33(12)：1 870-1 876. (in Chinese))
[30]	VESIC A B. Bending of beams resting on isotropic elastic solid[J]. Journal of the Engineering Mechanics Division，1961，87(2)：35-53.
[32]	YU J，ZHANG C R，HUANG M S. Soil-pipe interaction due to tunnelling：Assessment of Winkler modulus for underground pipelines[J]. Computers and Geotechnics，2013，50：17-28.
[23]	王卫东，李永辉，吴江斌. 上海中心大厦大直径超长灌注桩现场试验研究[J]. 岩土工程学报，2011，33(12)：1 817-1 826.(WANG Weidong，LI Yonghui，WU Jiangbin. Field loading tests on large-diameter and super-long bored piles of Shanghai Center Tower[J]. Chinese Journal of Geotechnical Engineering，2011，33(12)：1 817-1 826.(in Chinese))
[24]	张乾青，李术才，李利平，等. 考虑侧阻软化和端阻硬化的群桩沉降简化算法[J]. 岩石力学与工程学报，2013，32(3)：615-624. (ZHANG Qianqing，LI Shucai，LI Liping，et al. Simplified method for settlement prediction of pile groups considering skin friction softing and end resistance hardening[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(3)：615-624.(in Chinese))
[31]	KLAR A，VOSTER TEB，SOGA K，et al. Soil-pipe interaction due to tunneling：comparison between Winkler and elastic continuum solutions[J]. Géotechnique，2005，55(6)：461-466.