水平井射孔压裂完井下控制近井筒裂缝复杂度的参数优化

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (3967 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要水平井射孔压裂完井是开发非常规油气储层的关键手段，但水力裂缝在射孔孔眼的竞争起裂与近井筒的非平面扩展行为仍不明确。为此，以某页岩油储层HX井为例，结合离散格子方法建立三维全耦合螺旋射孔压裂数值模型，精细描述多孔眼裂缝竞争扩展中的相互干扰行为以及空间演化，系统研究水平主应力差、射孔密度和射孔相位角等关键因素影响下的水平井近井筒裂缝起裂与扩展行为，提出控制近井筒裂缝复杂度的工程措施建议。结果表明，在压裂初期，各射孔孔眼根部存在径向和横向的“十”型裂缝；随后在地应力的控制下，各孔眼的横向裂缝发生优势扩展而纵向裂缝扩展受到抑制；最后在相邻孔眼裂缝发生不同程度的沟通与连接下，在远井端形成了垂直于最小水平主应力方位的横向主裂缝。当水平井筒沿着最小水平主应力方位时，低水平主应力差、高射孔密度和低相位角有利于在近井筒形成简单连续的横向主裂缝，而高水平主应力差、低射孔密度和高相位角下由于各孔眼裂缝之间沟通困难，导致形成含多条分支缝的复杂裂缝。提出的三维全耦合射孔压裂数值模型有效地描述了多孔眼裂缝起裂与扩展行为，同时研究成果为通过优化射孔完井参数以降低近井筒裂缝复杂度提供了理论指导。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王小华1
	2
	罗浩然1
	2
	3
	张丰收1
	2

关键词 ：岩石力学, 页岩储层, 流固耦合, 水力压裂, 裂缝, 离散格子方法, 射孔

Abstract：Perforated fracturing of horizontal wells is a key measure to exploit unconventional oil and gas reservoirs，but the competitive initiation of hydraulic fractures from perforation tunnels and the non-planar propagation near the wellbore are still unclear. Therefore，taking the well HX of shale oil reservoir as an example，a three-dimensional fully-coupled fracturing model with helical perforation is established by using the discrete lattice method. The interaction behavior and propagation evolution of multi-tunnel fractures for helical perforation are described in detail. The impacts of controlling factors such as horizontal stress difference，perforation density and phase angle on the propagation of near-wellbore fractures are systematically studied，and several engineering measures to control the complexity of near-wellbore fractures are put forward. The results show that there are longitudinal fractures and transverse fractures at the bottom of perforation tunnels in the initial stage of fracturing，then，transverse fractures propagate predominantly while longitudinal fractures are restrained due to the influence of in-situ stresses，and finally，a dominant transverse-fracture perpendicular to the direction of the minimum horizontal principal stress is formed at the far end after different communication between fractures initiated from adjacent tunnels. When the horizontal wellbore is oriented along the direction of the minimum horizontal stress，the low horizontal stress difference，high perforation density and low phase angle are beneficial to the creation of simple and continuous transverse-fractures near the wellbore. However，under the conditions of high horizontal stress difference，low perforation density and high phase angle，complex fractures with multiple branches are generated due to the difficulty in communication between fractures initiated from adjacent tunnels. The proposed three-dimensional fully-coupled model of perforated fracturing effectively describes the initiation and propagation of multiple-tunnel fractures，and the research results provide theoretical guidance for controlling the complexity of near-wellbore fractures by optimizing perforation completion.

Key words： rock mechanics shale reservoir fluid-solid coupling hydraulic fracturing fracture discrete lattice method perforation

引用本文:

王小华1，2，罗浩然1，2，3，张丰收1，2. 水平井射孔压裂完井下控制近井筒裂缝复杂度的参数优化[J]. 岩石力学与工程学报, 2022, 41(6): 1223-1234.
WANG Xiaohua1，2，LUO Haoran1，2，3，ZHANG Fengshou1，2. Parameter optimization for controlling the complexity of near-wellbore fractures for perforated fracturing of horizontal wells#br#. , 2022, 41(6): 1223-1234.

链接本文:

http://rockmech.whrsm.ac.cn/CN/Y2022/V41/I6/1223

[24]	BEHRMANN L A，ELBEL J L. Effect of perforations on fracture initiation[J]. Journal of Petroleum Technology，1991，43：608-615.
[22]	DANESHY A. Experimental investigation of hydraulic fracturing through perforations[J]. Journal of Petroleum Technology，1973，25：1 201-1 206.
[30]	DONG Z，TANG S. Numerical study of near-wellbore hydraulic fracture propagation[J]. Theoretical and Applied Fracture Mechanics，2019，103：102274.
[6]	VISHKAI M，GATES I. On multistage hydraulic fracturing in tight gas reservoirs：Montney Formation，Alberta，Canada[J]. Journal of Petroleum Science and Engineering，2019，174：1 127-1 141.
[16]	HOSSAIN M，RAHMAN M，RAHMAN S. Hydraulic fracture initiation and propagation：roles of wellbore trajectory，perforation and stress regimes[J]. Journal of Petroleum Science and Engineering，2000，27：129-149.
[19]	SHAN Q，ZHANG R，JIANG Y. Complexity and tortuosity hydraulic fracture morphology due to near-wellbore nonplanar propagation from perforated horizontal wells[J]. Journal of Natural Gas Science and Engineering，2021，89：103884.
[21]	DOU F，WANG J，LEUNG C，et al. The alterations of critical pore water pressure and micro-cracking morphology with near-wellbore fractures in hydraulic fracturing of shale reservoirs[J]. Engineering Fracture Mechanics，2021，242：107481.
[26]	LIU Z，JIN Y，CHEN M，et al. Analysis of non-planar multi-fracture propagation from layered-formation inclined-well hydraulic fracturing[J]. Rock Mechanics and Rock Engineering，2016，49：1 747-1 758.
[29]	张丰收，吴建发，黄浩勇，等. 提高深层页岩裂缝扩展复杂程度的工艺参数优化[J]. 天然气工业，2021，41(1)：125-135.(ZHANG Fengshou，WU Jianfa，HUANG Haoyong，et al. Technological parameter optimization for improving the complexity of hydraulic fractures in deep shale reservoirs[J]. Natural Gas Industry，2021，41(1)：125-135.(in Chinese))
[46]	DETOURNAY E. Mechanics of hydraulic fractures[J]. Annual Review of Fluid Mechanics，2016，48：311-339.
[1]	邹才能，翟光明，张光亚，等. 全球常规-非常规油气形成分布、资源潜力及趋势预测[J]. 石油勘探与开发，2015，42(1)：13-25.(ZOU Caineng，ZHAI Guangming，ZHANG Guangya，et al. Formation，distribution，potential and prediction of global conventional and unconventional hydrocarbon resources[J]. Petroleum Exploration and Development，2015，42(1)：13-25.(in Chinese))
[3]	贾承造，郑民，张永峰. 中国非常规油气资源与勘探开发前景[J]. 石油勘探与开发，2012，39(2)：129-136.(JIA Chengzao，ZHENG Min，ZHANG Yongfeng. Unconventional hydrocarbon resources in China and the prospect of exploration and development[J]. Petroleum Exploration and Development，2012，39(2)：129-136.(in Chinese))
[9]	ZENG Y，WANG Z，ZANG Y，et al. Pore pressure disturbance induced by multistage hydraulic fracturing in shale gas：Modelling and field application[J]. Geofluids，2019，2019：1315451.
[11]	CAI C，WANG X，YUAN X，et al. Experimental investigation on perforation of shale with ultra-high pressure abrasive water jet：Shape，mechanism and sensitivity[J]. Journal of Natural Gas Science and Engineering，2019，67：196-213.
[13]	郭天魁，张士诚，潘林华. 页岩储层射孔水平井水力裂缝起裂数值模拟研究[J]. 岩石力学与工程学报，2015，34(增1)：2 721-2 731. (GUO Tiankui，ZHANG Shicheng，PAN Linhua. Numerical simulation study of hydraulic fracture initiation for perforated horizontal well in shale play[J]. Chinese Journal of Rock Mechanics and Engineering，2015，34(Supp.1)：2 721-2 731.(in Chinese))
[15]	姜浒，陈勉，张广清，等. 定向射孔对水力裂缝起裂与延伸的影响[J]. 岩石力学与工程学报，2009，28(7)：1 321-1 326.(JIANG Hu，CHEN Mian，ZHANG Guangqing，et al. Impact of oriented perforation on hydraulic fracture initiation and propagation[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(7)：1 321-1 326. (in Chinese))
[18]	张丰收，李猛利，张重远，等. 高地应力下深部岩芯饼化裂缝发展规律及机制研究[J]. 岩石力学与工程学报，2022，41(3)：533-542. (ZHANG Fengshou，LI Mengli，ZHANG Chongyuan，et al. Study on fracture propagation and formation mechanism of core discing at depth under high in-situ stresses[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(3)：533-542.(in Chinese))
[7]	TAGHICHIAN A，HASHEMALHOSEINI H，ZAMAN M，et al. Propagation and aperture of staged hydraulic fractures in unconventional resources in toughness-dominated regimes[J]. Journal of Rock Mechanics and Geotechnical Engineering，2018，10：249-258.
[17]	蔡武强，梁文灏，朱合华. 深埋岩体隧道开挖面三维非线性挤出效应分析[J]. 岩石力学与工程学报，2021，40(9)：1 868-1 883.(CAI Wuqiang，LIANG Wenhao，ZHU Hehua. Three-dimensional and nonlinear face extrusion effects of deep-buried rock tunnels under excavation unloading[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(9)：1 868-1 883.(in Chinese))
[27]	ZHANG R，HOU B，SHAN Q，et al. Hydraulic fracturing initiation and near-wellbore nonplanar propagation from horizontal perforated boreholes in tight formation[J]. Journal of Natural Gas Science and Engineering，2018，55：337-349.
[31]	BAI Q，LIU Z，ZHANG C，et al. Geometry nature of hydraulic fracture propagation from oriented perforations and implications for directional hydraulic fracturing[J]. Computers and Geotechnics，2020，125：103682.
[36]	POULSEN B，ADHIKARY D，ELMOUTTIE M，et al. Convergence of synthetic rock mass modelling and the Hoek-Brown strength criterion[J]. International Journal of Rock Mechanics and Mining Sciences，2015，80：171-180.
[37]	BAKHSHI E，GOLSANAMI N，CHEN L. Numerical modeling and lattice method for characterizing hydraulic fracture propagation：A review of the numerical，experimental，and field studies[J]. Archives of Computational Methods in Engineering，2020，28：3 329-3 360.
[39]	BAKHSHI E，RASOULI V，GHORBANI A，et al. Lattice numerical simulations of lab-scale hydraulic fracture and natural interface interaction[J]. Rock Mechanics and Rock Engineering，2019，52：1 315-1 337.
[41]	DAMJANAC B，CUNDALL P. Application of distinct element methods to simulation of hydraulic fracturing in naturally fractured reservoirs[J]. Computers and Geotechnics，2016，71：283-294.
[47]	DONTSOV E V. An approximate solution for a plane strain hydraulic fracture that accounts for fracture toughness，fluid viscosity，and leak-off[J]. International Journal of Fracture，2017，205：221-237.
[49]	BOIS A，GARNIER A，RODOT F，et al. How to prevent loss of zonal isolation through a comprehensive analysis of microannulus formation[J]. SPE Drilling and Completion，2011，26：13-31.
[2]	童晓光，郭建宇，王兆明. 非常规油气地质理论与技术进展[J]. 地学前缘，2014，21(1)：9-20.(TONG Xiaoguang，GUO Jianyu，WANG Zhaoming. The progress of geological theory and technology for unconventional oil and gas[J]. Earth Science Frontiers，2014，21(1)：9-20.(in Chinese))
[4]	胡文瑞，翟光明，李景明. 中国非常规油气的潜力和发展[J]. 中国工程科学，2010，12(5)：25-29.(HU Wenrui，ZHAI Guangming，LI Jingming. Potential and development of unconventional hydrocarbon resources in China[J]. Engineering Sciences，2010，12(5)：25-29.(in Chinese))
[5]	翟光明，何文渊. 煤层气是天然气的现实接替资源[J]. 天然气工业，2004，24(5)：1-3.(ZHAI Guangming，HE Wenyuan. Conventional natural gas actual succeeding resources—coalbed methane[J]. Natural Gas Industry，2004，24(5)：1-3.(in Chinese))
[8]	LOPEZ MANRÍQUEZ A. Stress behavior in the near fracture region between adjacent horizontal wells during multistage fracturing using a coupled stress-displacement to hydraulic diffusivity model[J]. Journal of Petroleum Science and Engineering，2018，162：822-834.
[10]	CHENG W，JIANG G，TIAN H，et al. Numerical investigations of the fracture geometry and fluid distribution of multistage consecutive and alternative fracturing in a horizontal well[J]. Computers and Geotechnics，2017，92：41-56.
[12]	MICHAEL A，GUPTA I. Analytical orientation criteria for drilling and completion-induced fracture initiation considering fluid infiltration from the wellbore[J]. Journal of Petroleum Science and Engineering，2020，190：107033.
[14]	李根生，宋剑，熊伟，等. 高压水射流射孔渗流场模型及计算[J]. 石油勘探与开发，2005，32(6)：97-100.(LI Gensheng，SONG Jian，XIONG Wei，et al. Simulation model and calculation of seepage flow field for high pressure waterjet perforated wells[J]. Petroleum Exploration and Development，2005，32(6)：97-100.(in Chinese))
[20]	ZHU H，DENG J，JIN X，et al. Hydraulic fracture initiation and propagation from wellbore with oriented perforation[J]. Rock Mechanics and Rock Engineering，2015，48：585-601.
[23]	RABAA W. Experimental study of hydraulic fracture geometry initiated from horizontal wells[C]// SPE Annual Technical Conference and Exhibition. [S. l.]：Society of Petroleum Engineers，1989：SPE-19720-MS.
[25]	FALLAHZADEH S H，RASOULI V，SARMADIVALEH M. An investigation of hydraulic fracturing initiation and near-wellbore propagation from perforated boreholes in tight formations[J]. Rock Mechanics and Rock Engineering，2015，48：573-584.
[28]	刘乃震，张兆鹏，邹雨时，等. 致密砂岩水平井多段压裂裂缝扩展规律[J]. 石油勘探与开发，2018，45(6)：1 059-1 068.(LIU Naizhen，ZHANG Zhaopeng，ZOU Yushi，et al. Propagation law of hydraulic fractures during multi-staged horizontal well fracturing in a tight reservoir[J]. Petroleum Exploration and Development，2018，45(6)：1 059-1 068.(in Chinese))
[32]	ZHANG F，DAMJANAC B，MAXWELL S. Investigating hydraulic fracturing complexity in naturally fractured rock masses using fully coupled multiscale numerical modeling[J]. Rock Mechanics and Rock Engineering，2019，52：5 137-5 160.
[33]	HUANG L，LIU J，ZHANG F，et al. 3D lattice modeling of hydraulic fracture initiation and near-wellbore propagation for different perforation models[J]. Journal of Petroleum Science and Engineering，2020，191：107169.
[35]	VALLEJOS J，SUZUKI K，BRZOVIC A，et al. Application of synthetic rock mass modeling to veined core-size samples[J]. International Journal of Rock Mechanics and Mining Sciences，2016，81：47-61.
[38]	ZHANG F，WANG X，TANG M，et al. Numerical investigation on hydraulic fracturing of extreme limited entry perforating in plug-and- perforation completion of shale oil reservoir in Changqing oilfield，China[J]. Rock Mechanics and Rock Engineering，2021，54：2 925-2 941.
[40]	WU J，HUANG H，XU E，et al. Numerical investigation on propagation behaviors of a three-dimensional fracture network coupled with microseismicity in fractured shale reservoirs[J]. Energies，2021，14：8 297.
[42]	DAMJANAC B，DETOURNAY C，CUNDALL P A. Application of particle and lattice codes to simulation of hydraulic fracturing[J]. Computational Particle Mechanics，2016，3：249-261.
[43]	SUN Y，LIU Z，TANG X. A hybrid FEMM-Phase field method for fluid-driven fracture propagation in three dimension[J]. Engineering Analysis with Boundary Elements，2020，113：40-54.
[45]	ZOLFAGHARI N，BUNGER A. Numerical model for a penny-shaped hydraulic fracture driven by laminar/turbulent fluid in an impermeable rock[J]. International Journal of Solids and Structures，2019，158：128-140.
[48]	LI J，XI Y，TAO Q，et al. Experimental investigation and numerical simulation of the emergence and development of micro-annulus in shale gas wells subjected to multistage fracturing[J]. Journal of Natural Gas Science and Engineering，2020，78：103314.
[50]	XI Y，LI J，TAO Q，et al. Experimental and numerical investigations of accumulated plastic deformation in cement sheath during multistage fracturing in shale gas wells[J]. Journal of Petroleum Science and Engineering，2020，187：106790.
[34]	MAS IVARS D，PIERCE M，DARCEL C，et al. The synthetic rock mass approach for jointed rock mass modelling[J]. International Journal of Rock Mechanics and Mining Sciences，2011，48：219-244.
[44]	TOO J，CHENG A，KHOO B，et al. Hydraulic fracturing in a penny-shaped crack. Part I：Methodology and testing of frozen sand[J]. Journal of Natural Gas Science and Engineering，2018，52：609-618.
[51]	KIM C，ABASS H. Hydraulic fracture initiation from horizontal wellbores：laboratory experiments[C]// The 32nd U.S. Symposium on Rock Mechanics. [S. l.]：American Rock Mechanics Association，1991：ARMA-91-231.