负煤柱长壁工作面底板应力分布及破坏特征

doi:10.13722/j.cnki.jrme.2022.0189

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (92442 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究负煤柱长壁工作面底板应力分布及破坏特征，采用有限元–离散元耦合数值模拟方法构建FLAC-PFC数值模型，研究自开切眼、到采空区压实、再到岩层移动稳定全过程底板应力分布时空演化规律、底板破坏特征及矸石堆积对底板受力和破坏的影响，并基于弹性力学理论构建负煤柱工作面底板受力模型，对破坏深度进行理论推导。结果表明：(1) 覆岩在采空区两侧形成非对称顶板垮落结构，矸石沿工作面倾向堆积于采空区下部，堆积形态亦非对称，二者共同作用造成底板非对称受力及破坏。(2) 底板非对称破坏与顶板关键块回转下沉形成“瓶颈”结构，矸石继续向下堆积受阻。(3) 矸石非对称堆积造成底板应力空间上“下大上小”，采空区两侧应力集中随先增强后减弱，底板应力经历压应力–拉应力–压应力演化过程。(4) 数值模拟、理论计算及现场实测结果均验证了矸石非对称堆积造成的底板非对称受力及破坏特征。研究可为接续负煤柱长壁工作面巷顶沿空掘巷合理位置选择及围岩控制提供科学依据。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王朋飞
	刘佳男
	冯国瑞

关键词 ：岩石力学, 负煤柱, 底板, 应力分布, 破坏特征, 矸石滑移, FLAC-PFC耦合

Abstract：To study stress distribution and failure characteristics of a longwall panel floor with a negative gate pillar，coupled finite and discrete element numerical modelling method was adopted to construct a FLAC-PFC coupling numerical model. Spatiotemporal evolution of floor stress distribution，failure characteristics and effect of caved rock accumulation on floor stress and failure were analyzed throughout the process from setup room excavation to compaction of caved rock in gob to roof strata settlement. Based on elastic mechanics，a mechanical floor model was established to derive failure depth. The results show that：(1) Asymmetric accumulation of caved rocks in gob and asymmetric collapse of roof result in asymmetry of stress and failure of floor. (2) A “bottleneck” structure is formed by asymmetric failure of the floor and rotary cave-in of key blocks of roof，which hinders the further asymmetric slip of gob rocks. (3) The floor stress distribution under the influence of asymmetric accumulation of gob rocks presents a spacial distribution of “large top and small bottom”. And the stress concentration on both sides of the gob increases first and then decreases over time，and the floor stress experiences a transition of “compressive-tensile-compressive”. (4) Numerical simulation，theoretical calculation and field measurement results verify the asymmetric characteristics of stress and failure of floor caused by asymmetric accumulation of gob rocks. The study serves to provide theoretical support and scientific basis for determining location of gob side entry and its surrounding rock control of future adjacent panel with a negative gate pillar.

Key words： rock mechanics negative pillar floor stress distribution failure characteristics gangue slip FLAC-PFC coupling

引用本文:

王朋飞，刘佳男，冯国瑞. 负煤柱长壁工作面底板应力分布及破坏特征[J]. 岩石力学与工程学报, 2023, 42(1): 194-211.
WANG Pengfei，LIU Jianan，FENG Guorui. Stress distribution and failure characteristics of a longwall panel floor with a negative gate pillar. , 2023, 42(1): 194-211.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2022.0189 或 http://rockmech.whrsm.ac.cn/CN/Y2023/V42/I1/194

[25]	POULSEN B A，ADHIKARY D P. A numerical study of the scale effect in coal strength[J]. International Journal of Rock Mechanics and Mining Sciences，2013，63：62–71.
[3]	姜福兴，王建超，孙广京，等. 深部开采沿空巷道冲击危险性的工程判据[J]. 煤炭学报，2015，40(8)：1 729–1 736.(JIANG Fuxing，WANG Jianchao，SUN Guangjing，et al. Engineering criterion of gob-side entry rock burst hazard in deep mining[J]. Journal of China Coal Society，2015，40(8)：1 729–1 736.(in Chinese))
[5]	LI Z，DOU L，CAI W，et al. Roadway stagger layout for effective control of gob-side rock bursts in the longwall mining of a thick coal seam[J]. Rock Mechanics and Rock Engineering，2016，49(2)：621–629.
[7]	王朋飞，赵景礼，王志强，等. 非充分采动采空区与煤岩柱(体)耦合作用机制及应用[J]. 岩石力学与工程学报，2017，36(5)：1 185–1 200.(WANG Pengfei，ZHAO Jingli，WANG Zhiqiang，et al. Mechanism of gob-pillar interaction for subcritical panels and its application[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(5)：1 185–1 200.(in Chinese))
[2]	谢和平，李存宝，高明忠，等. 深部原位岩石力学构想与初步探索[J]. 岩石力学与工程学报，2021，40(2)：217–232.(XIE Heping，LI Cunbao，GAO Mingzhong，et al. Conceptualization and preliminary research on deep in situ rock mechanics[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(2)：217–232.(in Chinese))
[1]	杜计平，孟宪锐. 采矿学[M]. 徐州：中国矿业大学出版社，2009：92–104.(DU Jiping，MENG Xianrui. Mining[M]. Xuzhou：China University of Mining and Technology Press，2009：92–104.(in Chinese))
[6]	张俊文，刘畅，李玉琳，等. 错层位沿空巷道围岩结构及其卸让压原理[J]. 煤炭学报，2018，43(8)：2 133–2 143.(ZHANG Junwen，LIU Chang，LI Yulin，et al. Study on the surrounding rock structure of stagger layout roadway and its pressure release as well as deformation yielding mechanism[J]. Journal of China Coal Society，2018，43(8)：2 133–2 143.(in Chinese))
[4]	翟明华，姜福兴，朱斯陶，等. 巨厚坚硬岩层下基于防冲的开采设计研究与应用[J]. 煤炭学报，2019，44(6)：1 707–1 715.(ZHAI Minghua，JIANG Fuxing，ZHU Sitao，et al. Research and application of mining design based on prevention of rock burst under giant thickness hard strata[J]. Journal of China Coal Society，2019，44(6)：1 707–1 715.(in Chinese))
[9]	王志强，郭磊，苏泽华，等. 倾斜中厚煤层错层位外错式巷道布置及相邻巷道联合支护技术[J]. 煤炭学报，2020，45(2)：542–555. (WANG Zhiqiang，GUO Lei，SU Zehua，et al. Layout and combined support technology of alternate exterior stagger arrangement roadway and adjacent roadways in inclined and medium-thick coal seam[J]. Journal of China Coal Society，2020，45(2)：542–555.(in Chinese))
[11]	LI X，WANG Z，ZHANG J. Stability of roof structure and its control in steeply inclined coal seams[J]. International Journal of Mining Science and Technology，2017，27(2)：359–364.
[12]	WANG J，JIAO J. Criteria of support stability in mining of steeply inclined thick coal seam[J]. International Journal of Rock Mechanics and Mining Sciences，2016，82：22–35.
[14]	刘伟韬，穆殿瑞，杨利，等. 倾斜煤层底板破坏深度计算方法及主控因素敏感性分析[J]. 煤炭学报，2017，42(4)：849–859.(LIU Weitao，MU Dianrui，YANG Li，et al. Calculation method and main factor sensitivity analysis of inclined coal floor damage depth[J]. Journal of China Coal Society，2017，42(4)：849–859.(in Chinese))
[23]	康红普，伊丙鼎，高富强，等. 中国煤矿井下地应力数据库及地应力分布规律[J]. 煤炭学报，2019，44(1)：23–33.(KANG Hongpu，YI Bingding，GAO Fuqiang，et al. Database and characteristics of underground in-situ stress distribution in Chinese coal mines[J]. Journal of China Coal Society，2019，44(1)：23–33.(in Chinese))
[8]	FENG G，WANG P，CHUGH Y P. Stability of gate roads next to an irregular yield pillar：a case study[J]. Rock Mechanics and Rock Engineering，2019，52(8)：2 741–2 760.
[10]	王家臣，赵兵文，赵鹏飞，等. 急倾斜极软厚煤层走向长壁综放开采技术研究[J]. 煤炭学报，2017，42(2)：286–292.(WANG Jiachen，ZHAO Bingwen，ZHAO Pengfei，et al. Research on the longwall top-coal caving mining technique in extremely inclined and soft thick coal seam[J]. Journal of China Coal Society，2017，42(2)：286–292.(in Chinese))
[15]	MENG X，LIU W，ZHAO J，et al. In situ investigation and numerical simulation of the failure depth of an inclined coal seam floor：a case study[J]. Mine Water and the Environment，2019，38(3)：686–694.
[17]	LIANG Z，SONG W，LIU W. Theoretical models for simulating the failure range and stability of inclined floor strata induced by mining and hydraulic pressure[J]. International Journal of Rock Mechanics and Mining Sciences，2020，132：104–382.
[19]	POTYONDY D O，CUNDALL P A. A bonded-particle model for rock[J]. International Journal of Rock Mechanics and Mining Sciences，2004，41(8)：1 329–1 364.
[21]	蒋明镜，白闰平，刘静德，等. 岩石微观颗粒接触特性的试验研究[J]. 岩石力学与工程学报，2013，32(6)：1 121–1 128.(JIANG Mingjing，BAI Runping，LIU Jingde，et al. Experimental study of inter-granular particles bonding behaviors for rock microstructure[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(6)：1 121–1 128.(in Chinese))
[26]	石崇，张强，王盛年. 颗粒流(PFC 5.0)数值模拟技术及应用[M]. 1版. 北京：中国建筑工业出版社，2018：263–268.(SHI Chong，ZHANG Qiang，WANG Shengnian. Numerical simulation technology and application of particle flow (PFC5.0)[M]. 1st ed. Beijing：China Architecture Publishing and Media Co. Ltd.，2018：263–268.(in Chinese))
[28]	沈明荣，陈建峰. 岩体力学[M]. 2版. 上海：同济大学出版社， 2006：41–42.(SHEN Mingrong，CHEN Jianfeng. Rock mass mechanics[M]. 2nd ed. Shanghai：Tongji University Press，2006：41–42.(in Chinese))
[30]	宋文成，梁正召，刘伟韬，等. 采场底板破坏特征及稳定性理论分析与试验研究[J]. 岩石力学与工程学报，2019，38(11)：2 208–2 218. (SONG Wencheng，LIANG Zhengzhao，LIU Weitao，et al. Theoretical analysis and experimental investigation on failure characteristics and stability of stope floors[J]. Chinese Journal of Rock Mechanics and Engineering，2019，38(11)：2 208–2 218.(in Chinese))
[13]	王金安，焦军灵，程文东，等. 论大倾角长壁综放工作面圆弧段对支架稳定性的控制作用[J]. 煤炭学报，2015，40(10)：2 361–2 369. (WANG Jinan，JIAO Junling，CHENG Wendong，et al. Roles of arc segment in controlling the support stability in longwall fully mechanized topcoal caving mining face of steeply inclined coal seam[J]. Journal of China Coal Society，2015，40(10)：2 361–2 369.(in Chinese))
[16]	陈继刚，熊祖强，李卉，等. 倾斜特厚煤层综放带压开采底板破坏特征研究[J]. 岩石力学与工程学报，2016，35(增1)：3 018–3 023. (CHEN Jigang，XIONG Zuqiang，LI Hui，et al. Failure characteristics of floor under pressure inclined and extra thick coal seam in full-mechanized top coal caving faces[J]. Chinese Journal of Rock Mechanics and Engineering，2016，35(Supp.1)：3 018–3 023.(in Chinese))
[18]	POTYONDY D O. The bonded-particle model as a tool for rock mechanics research and application：current trends and future directions[J]. Geosystem Engineering，2015，18(1)：1–28.
[20]	宿辉，党承华，李彦军. 考虑不均质度的岩石声发射数值模拟研究[J]. 岩土力学，2011，32(6)：1 886–1 890.(SU Hui，DANG Chenghua，LI Yanjun. Study of numerical simulation of acoustic emission in rock of inhomogeneity[J]. Rock and Soil Mechanics，2011，32(6)：1 886–1 890.(in Chinese))
[22]	周喻，王莉，丁剑锋，等. 多尺度节理岩体力学特性的颗粒流分析[J]. 岩土力学，2016，37(7)：2 085–2 095.(ZHOU Yu，WANG Li，DING Jianfeng，et al. Particle flow code analysis of multi-scale jointed rock mass based upon equivalent rock mass technique[J]. Rock and Soil Mechanics，2016，37(7)：2 085–2 095.(in Chinese))
[24]	POTYONDY D O. A flat-jointed bonded-particle material for hard rock[C]// Proceedings of the 46textsuperscriptth U.S. Rock Mechanics，Geomechanics Symposium. Chicago：[s. n. ]，2012：24–27.
[27]	徐芝纶. 弹性力学简明教程[M]. 1版. 北京：高等教育出版社， 2002：72–77.(YU Zhilun. Brief tutorial on elasticity[M]. 1st ed. Beijing：Higher Education Press，2002：72–77.(in Chinese))
[29]	孟祥瑞，徐铖辉，高召宁，等. 采场底板应力分布及破坏机制[J]. 煤炭学报，2010，35(11)：1 832–1 836.(MENG Xiangrui，XU Chenghui，GAO Zhaoning，et al. Stress distribution and damage mechanism of mining floor[J]. Journal of China Coal Society，2010，35(11)：1 832–1 836.(in Chinese))
[31]	罗生虎，田程阳，伍永平，等. 大倾角煤层长壁开采覆岩走向受载与破坏特征[J]. 煤炭学报，2021，46(7)：2 227–2 236.(LUO Shenghu，TIAN Chengyang，WU Yongping，et al. Characteristics of loading and failure of overlying rock at working face advancing direction in longwall mining of steeply inclined seam[J]. Journal of China Coal Society，2021，46(7)：2 227–2 236.(in Chinese))