声发射定位精度尺寸效应的试验研究

doi:10.13722/j.cnki.jrme.2015.0921

摘要
图/表
参考文献(23)
相关文章 (15)

全文: PDF (5121 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要利用PCI–2型声发射试验装置，通过不同试件尺寸条件下的声发射断铅定位试验，对声发射定位精度尺寸效应进行研究。研究结果表明：当利用数据参数绝对值分析法进行处理时，对于同一平面，试件尺寸越大，该面的平均位置偏差越大，定位精度越不准；而在利用数据参数归一化处理时，相同平面试件尺寸为100 mm的试件相对误差却为最小。同时结合相对误差与较优点进行分析，得出在进行岩石声发射定位试验时，采用100 mm试件定位效果更好。在进行断铅定位时，断铅点位置不同对声发射定位精度也会产生较大影响，即断铅点距试件边界越近，位置偏差越大，其定位精度就越差，并且将各点坐标投射至三维方向，发现各定位点位于垂直于其所在平面方向坐标矢量大小不定，方向均指向靠近指向试件内部，而平行方向矢量值大小不定，方向不定，比较两方向得出，垂直方向矢量值均大于平行方向矢量值。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	许江1
	2
	李伊1
	2
	田傲雪1
	2
	瞿佳美1
	2

关键词 ：岩石力学, 声发射, 定位精度, 尺寸效应, 声发射定位

Abstract：Using PCI–2 type acoustic emission(AE) testing system to experiment the pencil lead break test under different sizes specimens in order to study on the size effect of acoustic emission location accuracy. The results suggested that：When using absolute value analysis method for analyzing processing data，as for the same plane， the bigger size，the greater average position deviation but the less location accuracy. When using the data normalization analysis method，as for the same plane，the relative error of 100 mm specimens is minimal. At the same time，combining with the relative error and the better points analysis results，it showed that it is better to use 100 mm specimen when someone need to carry out the rock acoustic emission location experiment. While it also showed that different point location also can make great influences on emission location accuracy. The closer distance to the boundary，the greater average position deviation is. After projected the coordinates of each point into three-dimension and analyzed，it can be seen that the value of perpendicular direction vector is variable， but the direction is fixed which means all of them point to the specimen internal. As for the parallel vectors，the value and the directions are variable. When compared the value of perpendicular direction vectors with parallel vectors，perpendicular direction vectors must be larger than parallel vectors.

Key words： rock mechanids acoustic emission location accuracy size effect acoustic emission location

引用本文:

许江1，2，李伊1，2，田傲雪1，2，瞿佳美1，2. 声发射定位精度尺寸效应的试验研究[J]. 岩石力学与工程学报, 2016, 35(S1): 2826-2835.
XU Jiang1，2，LI Yi1，2，TIAN Aoxue1，2，QU Jiamei1，2. Experimental research on size effect of acoustic emission location accuracy. , 2016, 35(S1): 2826-2835.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2015.0921 或 https://rockmech.whrsm.ac.cn/CN/Y2016/V35/IS1/2826

[1]	王文星. 岩石力学[M]. 长沙：中南大学出版社，2004：5-12. (WANG Wenxing．Rock mechanics[M]. Changsha：Central South University Press，2004：5-12.(in Chinese))
[2]	WEIBULL W. The phenomenon of rupture of solids[C]// Generalstabens Litografiska Anstalts Förlag. Stockholm：Handlingar，1939：26-43.
[3]	潘一山，魏建明.岩石材料应变软化尺寸效应的实验和理论研究[J].岩石力学与工程学报，2002，21(2)：215-218.(PAN Yishan，WEI Jianming. Experimental and theoretical study on size effect on strain softening of rock materials[J].Chinese Journal of Rock Mechanics and Engineering，2002，21(2)：215-218.(in Chinese))
[4]	洪亮，李夕兵，马春德，等. 岩石动态强度及其应变率灵敏性的尺寸效应研究[J]. 岩石力学与工程学报，2008，27(3)：526-533.(HONG Liang，LI Xibing，MA Chunde，et al.Study on size effect of rock dynamic strength and strain rate sensitivity[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(3)：526-533.(in Chinese))
[5]	TANG C A. Numerical studies of the influence of microstructure on rock failure in uniaxialcompression-part 1：effect of heterogeneity[J]. International Journal of Rock Mechanics and Mining Sciences，2000，37(4)：555-569.
[6]	王祖荫. 声发射技术基础[M].北京：科学出版社，1990：62-80. (WANG Zuyin.Acoustic emission technology[M].Beijing：Science Press，1990：62-80.(in Chinese))
[7]	袁振明，马羽宽，何泽云. 声发射技术及其应用[M]. 北京：机械工业出版社，1995：21-35.(YUAN Zhenming，MA Yukuan，HE Zeyun.Acoustic emission technique and application[M].Beijing：China Machine Press，1995：21-35.(in Chinese))
[8]	金钟山，刘时风，耿荣生，等. 曲面和三维结构的声发射源定位方法[J]. 无损检测，2002，24(5)：205-211.(JIN Zhongshan，LIU Shifeng，GENG Rongsheng，et al.Location of acoustic emission source on curved surfaces and three-dimension structures[J].Nondestructive Testing，2002，24(5)：205-211.(in Chinese))
[9]	王述红，张亚兵，张楠，等.各向异性岩体破坏过程声发射测量及其定位实验研究[J]. 东北大学学报：自然科学版，2007，28(7)：1033-1036.(WANG Shuhong，ZHANG Yabing，ZHANG Nan，et al.Experimental study on acoustic emission measurement and source location for anisotropic rock failure process[J]. Journal of NortheasternUniversity：Natural Science，2007，28(7)：1033-1036.(in Chinese))
[10]	姚力，赖德明.声发射源定位不确定度的计算[J].无损检测，2002，24(11)：461-463.(YAO Li，LAI Deiming.Calculation of the uncertainty of acoustic emission source location[J].Nondestructive Testing，2002，24(11)：461-463.(in Chinese))
[11]	徐彦廷，孙茂成，李伟，等.声源定位问题研究及误差分析[J].无损检测，1999，21(5)：199-202.(XU Yanting，SUN Maocheng，LI Wei，et al.A study on source location in acoustic emission inspection and its error analysis[J]. Nondestructive Testing，1999，21(5)：199-202.(in Chinese))
[12]	LABUZ J F，BRIDELL J M. Reducing frictional constrain in compression testing through lubrication[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1993，30(4)：451-455.
[13]	欧阳利军，陈洲导，赵艳林，等.混凝土结构声发射检测参数设置研究[J]. 重庆建筑大学学报，2008，30(5)：37-41.(OUYANG Lijun，CHEN Zhoudao，ZHAO Yanlin，et al. The setting of acoustic emission detecting parameters in concrete structure[J].Journal of Chongqing Jianzhu University，2008，30(5)：37-41.(in Chinese))
[14]	张维刚，黄永福，叶荣耀，等.声发射检测中背景噪声对线定位精度影响研究[J].中国计量学院学报，2012，23(4)：326-331.(ZHANG Weigang，HUANG Yongfu，YE Rongyao，et al. Study on the impact of background noise on the accuracy of line localization for acoustic emission detection[J].Journal of China Jiliang University，2012，23(4)：326-331.(in Chinese))
[15]	孙立瑛，李一博，王伟魁，等.突发性声发射信号的传播特性及定位研究[J].压电与声光，2009，31(5)：37-41.(SUN Liying，LI Yibo，WANG Weikui，et al. Research on propagation characteristics and location of burst acoustic emission signal traveling along pipeline[J]. Piezoelectrics andAcoustooptics，2009，31(5)：37-41.(in Chinese))
[16]	胡新亮，马胜利，高景春，等.相对定位方法在非完整岩体声发射定位中的应用[J].岩石力学与工程学报，2004，23(2)：277-283.(HU Xinliang，MAShengli，GAO Jinchun，et al. Location of acoustic emissions in non-integral rock using relative location method[J]. Chinese Journal of Rock Mechanics and Engineering，2004，23(2)：277-283.(in Chinese))
[17]	李光海，刘时风.基于小波分析的声发射源定位技术[J].机械工程学报，2004，40(7)：136-140.(LI Guanghai，LIU Shifeng. Technique of acoustic emission source locating based on wavelet analysis[J].Chinese Journalof Mechanical Engineering，2004，40(7)：136-140.(in Chinese))
[18]	刘建坡，王洪勇，杨宇江，等. 不同岩石声发射定位算法及其实验研究[J]. 东北大学学报：自然科学版，2009，30(8)：1193-1196.(LIU Jianpo，WANG Hongyong，YANG Yujiang，et al. Experimental study on different rock locating algorithms with acoustic emission[J]. Journal of Northeastern University：Natural Science，2009，30(8)：1193-1196.(in Chinese))
[19]	刘建坡，徐世达，李元辉，等.预制孔岩石破坏过程中的声发射时空演化特征研究[J].岩石力学与工程学报，2012，31(12)：2538- 2547.(LIU Jianpo，XU Shida，LI Yuanhui，et al.Studies of AE time-space evolution charateristics during failure process of rock specimens with prefabricated holes[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(12)：2538-2547.(in Chinese))
[20]	赵兴东，陈长华，刘建坡，等. 不同岩石声发射活动特性的实验研究[J]. 东北大学学报：自然科学版，2008，29(11)：1633-1636.(ZHAO Xingdong，CHEN Changhua，LIU Jianpo，et al.Experimental study on ae activity characteristics of different rock samples[J].Journal of Northeastern University：Natural Science，2008，29(11)：1633-1636.(in Chinese))
[21]	赵兴东，刘建坡，李元辉，等. 岩石声发射定位技术及其实验验证[J]. 岩土工程学报，2008，30(10)：1472-1476.(ZHAO Xingdong，LIU Jianpo，LI Yuanhui，et al.Experimental verification of rock locating technique with acoustic emission[J]. Chinese Journal of GeotechnicalEngineering，2008，30(10)：1472-1476.(in Chinese))
[22]	许江，李树春，唐晓军，等. 单轴压缩下岩石声发射定位实验的影响因素分析[J]. 岩石力学与工程学报，2008，27(4)：765-772.(XU Jiang，LI Shuchun，TANG Xiaojun，et al. Experimental study of acoustic emission characteristic during shearing process of sandstone under different water contents[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(4)：765-772.(in Chinese))
[23]	LI Q Y，DONG L J，Li X B，et al.Effects of sonic speed on location accuracy of acoustic emission source in rocks[J]. Transactions of Nonferrous Metals Society of China，2011，(12)：2719-2726.