深孔定向聚能爆破增透机制模拟试验研究及现场应用

doi:10.13722/j.cnki.jrme.2014.12.014

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (10491 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究深孔定向聚能爆破的裂缝特征及应力演化特征，搭建定向聚能爆破试验系统，开展定向聚能爆破试验，分析聚能方向和非聚能方向的裂缝特征、应力演化规律。试验结果表明，定向聚能爆破的爆炸能量主要集中在聚能方向，能够在聚能方向侵彻煤体形成较大的裂缝，产生的裂缝长度远大于非聚能方向；定向爆破的聚能效应导致试样的应力状态在聚能方向发生显著变化，聚能方向的力学变化大于非聚能方向。同时，进行深孔定向聚能爆破的现场试验，煤层采用定向聚能爆破增透技术后，瓦斯抽采量增大10～40倍，有效抽采半径达到7 m，并且定向聚能爆破对煤层顶底板的破坏较小，较好地保护巷道围岩的完整性。研究成果对井下煤层实施定向聚能爆破治理瓦斯灾害有重要的科学意义和应用价值。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章

关键词 ：爆破力学, 深孔爆破, 瓦斯灾害, 增透, 定向聚能爆破

Abstract：In order to study the crack and stress evolutions caused by the directional focused energy blasting in deep borehole，an experiment system was constructed，and a series of laboratory and field experiments together with the field experiments of directional focused energy blasting were carried out. The results show that the energy of directional blasting mainly concentrated in focusing direction and then penetrated the coal sample with the cracks in focusing direction much longer than those in other directions. Because of the effect of directional focused energy blasting，the mechanical properties of the samples in focusing direction were changed much more significantly than in other directions. The permeability after directional focused energy blasting in coal seam was found increased. The maximum gas drainage volume was 10–40 times of the original one，with the effective radius of gas drainage reaching 7 meters. Besides，the directional focused energy blasting made little damage to the roof and floor of coal seam and the surround rock of roadway.

Key words： blasting mechanics deep borehole blasting gas disaster increasing permeability directional focused energy blasting

收稿日期: 2014-05-05

引用本文:

刘健1，2，刘泽功1，2，高魁1，2，马衍坤1，2，李重情1，2，郭林杰1，2. 深孔定向聚能爆破增透机制模拟试验研究及现场应用[J]. 岩石力学与工程学报, 2014, 33(12): 2490-2496.
LIU Jian1，2，LIU Zegong1，2，GAO Kui1，2，MA Yankun1，2，LI Zhongqing1，2，Guo Linjie1，2. EXPERIMENTAL STUDY AND APPLICATION OF DIRECTIONAL FOCUSED ENERGY BLASTING IN DEEP BOREHOLES. , 2014, 33(12): 2490-2496.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2014.12.014 或 https://rockmech.whrsm.ac.cn/CN/Y2014/V33/I12/2490

[1]	刘健，刘泽功，石必明. 低透气性突出煤层巷道快速掘进的试验研究[J]. 煤炭学报，2007，32(8)：827-831.(LIU Jian，LIU Zegong，SHI Biming. Study on the roadway excavation rapidly in the low permeability outburst coal seam[J]. Journal of China Coal Society，2007，32(8)：827-831.(in Chinese))
[2]	高魁，刘泽功，刘健，等. 深孔爆破在深井坚硬复合顶板沿空留巷强制放顶中的应用[J]. 岩石力学与工程学报，2013，32(8)： 1 588-1 594.(GAO Kui，LIU Zegong，LIU Jian，et al. Study on application of deep borehole blasting to gob-side entry retaining forced roof caving in hard and compound roof deep well[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(8)：1 588-1 594.(in Chinese))
[3]	刘健，刘泽功. 深孔预裂爆破技术在井筒揭煤中的应用研究[J].煤炭科学技术，2012，40(2)：19-24.(LIU Jian，LIU Zegong. Study on application of deep borehole pre-fracturing blasting technology to seam opening in mine shaft[J]. Coal Science and Technology，2012，40(2)：19-24.(in Chinese))
[4]	龚敏，张凤舞，文斌，等. 煤巷底板岩石爆破提高瓦斯抽放率的应用与数值模拟[J]. 煤炭学报，2012，37(6)：972-977.(GONG Min，ZHANG Fengwu，WEN Bin，et al. Numerical simulation and application on blasting to improve gas drainage rate in floor rock of coal roadway[J]. Journal of China Coal Society，2012，37(6)：972-977.(in Chinese))
[5]	高魁，刘泽功，刘健，等. 石门揭构造软煤消突与快速成巷技术研究[J]. 煤炭科学技术，2012，40(11)：66-68.(GAO Kui，LIU Zegong，LIU Jian，et al. Study on outburst elimination and rapid mine roadway construction technology during cross-cut opened structure soft coal[J]. Coal Science and Technology，2012，40(11)：66-68.(in Chinese))
[6]	龚敏，刘万波，王德胜，等. 提高煤矿瓦斯抽放效果的控制爆破技术[J]. 北京科技大学学报，2006，28(3)：223-226.(GONG Min，LIU Wanbo，WANG Desheng，et al. Control blasting technique to improve gas predrainage effect in a coal mine[J]. Journal of University of Science and Technology Beijing，2006，28(3)：223-226.(in Chinese))
[7]	黄文尧，颜事龙，刘泽功，等. 煤矿瓦斯抽采水胶药柱在煤层深孔爆破中的研究与应用[J]. 煤炭学报，2012，37(3)：472-476. (HUANG Wenyao，YAN Shilong，LIU Zegong，et al. Research and application of water gel explosive grain on coal mine gas extraction in
	coal seam deep hole blasting[J]. Journal of China Coal Society，2012，37(3)：472-476.(in Chinese)) " target="_blank">
[8]	余永强，杨小林，梁为民，等. 控制爆破致裂提高矿井瓦斯抽放率试验研究[J]. 煤炭学报，2007，32(4)：377-381.(YU Yongqiang，YANG Xiaolin，LIANG Weimin，et al. Testing research of improving mine gas drainage under suction by controlling blasting to cause crack[J]. Journal of China Coal Society，2007，32(4)：377-381.(in Chinese))
[9]	穆朝民，王海露，黄文尧，等. 高瓦斯低透气性煤体定向聚能爆破增透机制[J]. 岩土力学，2013，34(9)：2 496-2 500.(MU Chaomin，WANG Hailu，HUANG Wenyao，et al. Increasing permeability mechanism using directional cumulative blasting in coal seams with high concentration of gas and low permeability[J]. Rock and Soil Mechanics，2013，34(9)：2 496-2 500.(in Chinese))
[10]	郭德勇，裴海波，宋建成，等. 煤层深孔聚能爆破致裂增透机制研究[J]. 煤炭学报，2008，33(12)：1 381-1 385.(GUO Deyong，PEI Haibo，SONG Jiancheng，et al. Study on splitting mechanism of coal bed deep-hole cumulative blasting to improve permeability[J]. Journal of China Coal Society，2008，33(12)：1 381-1 385.(in Chinese)) " target="_blank">
[11]	郭德勇，吕鹏飞，裴海波，等. 煤层深孔聚能爆破裂隙扩展数值模拟[J]. 煤炭学报，2012，37(2)：274-278.(GUO Deyong，LU Pengfei，PEI Haibo，et al. Numerical simulation on crack propagation of coal bed deep-hole cumulative blasting[J]. Journal of China Coal Society，2012，37(2)：274-278.(in Chinese))
[12]	郭德勇，商登莹，吕鹏飞，等. 深孔聚能爆破坚硬顶板弱化试验研究[J]. 煤炭学报，2013，38(7)：1 149-1 153.(GUO Deyong，SHANG Dengying，LU Pengfei，et al. Experimental research of deep-hole cumulative blasting in hard roof weakening[J]. Journal of China Coal Society，2013，38(7)：1 149-1 153.(in Chinese))
[13]	商登莹，吕鹏飞，于学洋，等. 低透气性煤层深孔聚能爆破增透技术及实践[J]. 煤炭科学技术，2012，40(12)：48-51.(SHANG Dengying，LU Pengfei，YU Xueyang，et al. Permeability improved technology and practices with deep borehol energy accumulation blasting in low permeability seam[J]. Coal Science and Technology，2012，40(12)：48-51.(in Chinese))
[14]	戴俊. 柱状装药爆破的岩石压碎圈与裂隙圈计算[J]. 辽宁工程技术大学学报：自然科学版，2001，20(2)：144-147.(DAI Jun. Calculation of radii of the broken and cracked areas in rock by a long charge explosion[J]. Journal of Liaoning Technical University：Natural Science，2001，20(2)：144-147.(in Chinese))
[15]	龚敏，熊本良，王楚翰，等. 穿层爆破各煤层动态应力分布与抽放效果探讨[J]. 岩石力学与工程学报，2012，31(增1)：2 899-2 996. (GONG Min，XIONG Benliang，WANG Chuhan，et al. Discussion on distribution of dynamic stress and gas draining efficiency in coal seams by blasting through layers of coal-rock[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(Supp.1)：2 899-2 996.(in Chinese))
[16]	郭德勇，宋文健，李中州，等. 煤层深孔聚能爆破致裂增透工艺研究[J]. 煤炭学报，2009，34(8)：1 086-1 089.(GUO Deyong，SONG Wenjian，LI Zhongzhou，et al. Research on splitting technical of coal bed deep-hole cumulative blasting to improve permeability[J]. Journal of China Coal Society，2009，34(8)：1 086-1 089.(in Chinese))