基于总安全系数法的喷锚组合支护承载能力试验研究

doi:10.13722/j.cnki.jrme.2023.1014

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (5050 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为验证总安全系数法中喷锚组合支护的计算模型与安全系数计算方法，从结构试验角度研制大型隧道结构模型试验系统，开展毛洞、不同间距系统锚杆下喷锚组合支护结构的加载试验。采用围岩、细砂材料的三轴试验、锚杆材料的拉伸、拉拔试验，明确模型试验中各材料的物理与力学参数，模拟毛洞与不同锚杆间距下喷锚组合支护的加载破坏全过程，试验中监测获取了围岩应力–应变、锚杆应变、喷层内外侧应变、喷层位移随外荷载的演变规律，分析毛洞、不同锚杆间距下喷锚组合支护的设计承载能力、极限承载能力以及变形受力特征，并与总安全系数法理论计算结果进行对比分析。研究结果表明：喷射混凝土与锚杆能有效地与围岩协同承载，提高围岩的侧限力，发挥锚岩承载拱的支护作用，提高围岩的变形与承载能力；试验得到的喷锚组合支护的承载能力、破坏特征均与理论计算结果较为吻合，表明总安全系数法的喷锚组合支护计算方法是合理的，且该方法偏安全。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	肖明清1
	2
	徐晨1
	2
	崔岚3
	4
	盛谦3
	4
	陈健3
	4
	谢壁婷1
	2
	吴鹏3
	4

关键词 ：隧道工程, 喷锚支护, 隧道模型试验, 锚岩承载拱, 支护结构承载能力, 总安全系数法

Abstract：In order to validate the calculation model and safety factor calculation method for the combined spray-anchor support in the total safety factor method，this paper developed a large-scale tunnel structure model test system from the perspective of structural test，and carried out the loading test of the spray-anchor combined support structure under the unsupported tunnels and the different anchor spacing. The triaxial test of surrounding rock and fine sand material，and the tensile and pull-out test of anchor material were used to clarify the physical and mechanical parameters of each material in the model test，simulate the whole process of loading and damage of the spray-anchor combination support under different anchor spacing and unsupported tunnels，and monitor the stress and strain of the surrounding rock，anchor strain，inner and outer strain of the spray layer，and the displacement of the spray layer with the external load. Based on this，the design bearing capacity，ultimate bearing capacity，and deformation force characteristics of the unsupported tunnels and the combined spray-anchor support with different anchor spacing were analyzed and compared with the theoretical calculation results of the total safety factor method. The results show that：sprayed concrete and anchor can effectively carry the surrounding rock，improve the lateral limiting force of the surrounding rock，play the supporting role of the anchor rock bearing arch，and improve the deformation and bearing capacity of the surrounding rock；the bearing capacity and damage characteristics of the spray-anchor combination support obtained from the test are more in line with the results of theoretical calculations，which shows that the total safety factor method of spray-anchor combination support calculation method is reasonable and the method is on the safe side.

Key words： tunnel engineering spray-anchor combination support tunnel model test anchor rock bearing arch support structure bearing capacity the total safety factor method

引用本文:

肖明清1，2，徐晨1，2，崔岚3，4，盛谦3，4，陈健3，4，谢壁婷1，2，吴鹏3，4. 基于总安全系数法的喷锚组合支护承载能力试验研究[J]. 岩石力学与工程学报, 2024, 43(10): 2381-2395.
XIAO Mingqing1，2，XU Chen1，2，CUI Lan3，4，SHENG Qian3，4，CHEN Jian3，4，XIE Biting1，2，WU Peng3，4. Experimental study on bearing capacity of spray anchor combination support based on total safety factor method. , 2024, 43(10): 2381-2395.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2023.1014 或 https://rockmech.whrsm.ac.cn/CN/Y2024/V43/I10/2381

[1]	肖明清. 隧道支护结构设计总安全系数法[M]. 北京：人民交通出版社，2020：100-101.(XIAO Mingqing. Design of railway tunnel support structure based on overall safety factor method[M]. Beijing：China Communication Press，2020：100-101.(in Chinese))
[2]	SUN Z Y，ZHANG D L，FANG Q，et al. Analysis of the interaction between tunnel support and surrounding rock considering pre-reinforcement[J]. Tunnelling and Underground Space Technology，2023，141：105314.
[3]	CUI L，SHEN Q，DONG Y K，et al. Two-stage analysis of interaction between strain-softening rock mass and liner for circular tunnels considering delayed installation of liner[J]. European Journal of Environmental and Civil Engineering，2022，26(4)：1 492-1 517.
[4]	SHEN Q，ZHENG J J，CUI L，et al. A procedure for interaction between rock mass and liner for deep circular tunnel based on new solution of longitudinal displacement profile[J]. European Journal of Environmental and Civil Engineering，2022，26(1)：280-298.
[5]	CUI L，SHENG Q，DONG Y K，et al. Semianalytical analysis of over excavation and critical support pressure for support design in TBM tunneling through squeezing rock condition[J]. International Journal of Geomechanics，2021，21(7)：04021097.
[6]	孙明社，吴旭，宋克志，等. 基于位移反分析方法的隧道衬砌最早施作时机研究[J]. 隧道建设：中英文，2023，43(12)：2 046- 2 055.(SUN Mingshe，WU Xu，SONG Kezhi，et al. Earliest lining construction time based on the displacement back analysis method[J]. Tunnel Construction，2023，43(12)：2 046-2 055.(in Chinese))
[7]	刘英棨，张谢东，陈卫东，等. 多位移反分析浅埋偏压隧道初期支护荷载分布研究[J]. 隧道建设，2016，36(7)：832-836.(LIU Yingqi，ZHANG Xiedong，CHEN Weidong，et al. Study of load distribution rules of primary support of shallow-covered unsymmetrically pressured tunnel by using multi-displacement back analysis method[J]. Tunnel Construction，2016，36(7)：832-836.(in Chinese))
[8]	时亚昕，王明年，李强. 单洞双层地铁隧道施工力学行为[J]. 岩石力学与工程学报，2006，25(增1)：2 985-2 990.(SHI Yaxin，WANG Mingnian，LI Qiang. Construction mechanical behavior of metro tunnel with single cavern and double-layer[J]. Chinese Journal of Rock Mechanics and Engineering，2006，25(Supp.1)：2 985-2 990.(in Chinese))
[9]	ZHANG S M，ZHU Y Q，ZHAO Y C，et al. Comparative analysis of limit displacements for tunnels at the unlined and primary support stages[J]. International Journal of Rock Mechanics and Mining Sciences，2004，41(Supp.1)：774-779.
[10]	崔岚，郑俊杰，章荣军，等. 软弱破碎带隧道围岩变形及初期支护受力分析[J]. 华中科技大学学报：自然科学版，2012，40(11)：53-57.(CUI Lan，ZHENG Junjie，ZHANG Rongjun，et al. Analysis of deformation of the surrounding rock and preliminary support stress in tunnels through weak and cracked strata[J]. Journal of Huazhong University of Science and Technology：Natural Science，2012，40(11)：53-57.(in Chinese))
[11]	崔岚，张威，申俊敏，等. 深埋软岩隧道不同施工工法力学效应分析[J]. 土木工程与管理学报，2012，29(4)：36-40.(CUI Lan，ZHANG Wei，SHEN Junmin，et al. Mechanical response of deep-buried tunnels through soft and cracked rock mass under different excavation methods[J]. Journal of Civil Engineering and Management，2012，29(4)：36-40.(in Chinese))
[12]	杨林霖，杨文波，田浩晟，等. 考虑围岩短期蠕变效应的隧道双层初期支护变形控制研究[J]. 岩石力学与工程学报，2023，42(7)：1 731-1 742.(YANG Linlin，YANG Wenbo，TIAN Haosheng，et al. Study on deformation control of double-layered initial support in tunnels considering short-term creep effects of surrounding rock[J]. Chinese Journal of Rock Mechanics and Engineering，2023，42(7)：1 731-1 742.(in Chinese))
[13]	谢金池，寇昊，何川，等. 高地应力软岩大变形隧道洞型及双层初期支护支护时机研究[J]. 隧道建设(中英文)，2022，42(9)： 1 578-1 588.(XIE Jinchi，KOU Hao，HE Chuan，et al. Hole type and supporting time of double-layer primary support for large deformation soft rock tunnel with high insitu stress[J]. Tunnel Construction，2022，42(9)：1 578-1 588.(in Chinese))
[14]	FANG Y，XU C，CUI G，et al. Scale model test of highway tunnel construction underlying mined-out thin coal seam[J]. Tunnelling and Underground Space Technology，2016，56(June)：105-116.
[15]	李荣锦，邹鑫，李荣建，等. 半嵌泥岩半覆黄土隧道模型试验及承载特性评价[J]. 岩土工程学报，2022，44(增1)：98-103.(LI Rongjin，ZOU Xin，LI Rongjian，et al. Model tests and bearing characteristics of tunnels under semi-inlaid mudstone and semi-loess[J]. Chinese Journal of Geotechnical Engineering，2022，44(Supp.1)：98-103.(in Chinese))
[16]	周阳，来弘鹏，王兴广，等. 长锚杆/锚索改善深埋大跨度隧道初支结构受力试验研究[J]. 岩土工程学报，2024，46(4)：853-863.(ZHOU Yang，LAI Hongpeng，WANG Xingguang，et al. Experimental study on improving the mechanical characteristics of initial supporting structure of deep buried large-span tunnel with long bolts or cables[J]. Chinese Journal of Geotechnical Engineering，2024，46(4)：853-863.(in Chinese))
[17]	王万平，李建斐，晏鹏博，等. 基于主动支护的木寨岭隧道高地应力软岩大变形预应力锚索支护设计实践[J]. 隧道建设(中英文)，2023，43(增1)：313-322.(WANG Wanping，LI Jianfei，YAN Pengbo，et al. Design practice of prestressed anchor cable support technology for soft rock with extremely high geostress and large deformation in Muzhailing tunnel[J]. Tunnel Construction，2023，43(Supp.1)：313-322.(in Chinese))
[18]	谢生荣，谢国强，何尚森，等. 深部软岩巷道锚喷注强化承压拱支护机制及其应用[J]. 煤炭学报，2014，39(3)：404-409.(LAI Hongpeng，LIU Miao，XIE Yongli，et al. Study of surrounding rock pressure characteristics of shallow excavation three-arch metro tunnel in loess region[J]. Journal of China Coal Society，2014，39(3)：404-409.(in Chinese))
[19]	肖明清，陈立保，徐晨，等. 高速铁路隧道支护参数的计算研究[J]. 隧道建设(中英文)，2018，38(3)：406-413.(XIAO Mingqing，CHEN Libao，XU Chen，et al. Calculation study of support parameters of high-speed railway tunnel[J]. Tunnel Construction，2018，38(3)：406-413.(in Chinese))
[20]	徐晨，肖明清，谢壁婷，等. 不同埋深条件下隧道围岩压力设计值通用算法[J]. 铁道工程学报，2023，40(6)：62-68.(XU Chen，XIAO Mingqing，XIE Biting. Universal calculation method for design values of tunnel surrounding rock pressure under different burial depth conditions[J]. Journal of Railway Engineering Society，2023，40(6)：62-68.(in Chinese))
[21]	肖明清，徐晨. 基于总安全系数法的隧道围岩压力代表值研究[J]. 铁道工程学报，2019，36(2)：64-69.(XIAO Mingqing，XU Chen. Research on the representative value of deep buried tunnel surrounding rock pressure based on total safety factor method[J]. Journal of Railway Engineering Society，2019，36(2)：64-69.(in Chinese))
[22]	肖明清，王少锋，陈立保，等. 基于荷载结构法的隧道初期支护设计方法研究[J]. 铁道工程学报，2018，35(4)：60-64.(XIAO Mingqing，WANG Shaofeng，CHEN Libao，et al. Research on the design method of primary support of tunnel based on the load-structure method[J]. Journal of Railway Engineering Society，2018，35(4)：60-64.(in Chinese))
[23]	肖明清. 复合式衬砌隧道的总安全系数设计方法探讨[J]. 铁道工程学报，2018，35(1)：84-88.(XIAO Mingqing. Discussion on design method of general safety factor of composite lining tunnel[J]. Journal of Railway Engineering Society，2018，35(1)：84-88.(in Chinese))
[24]	肖明清. 采用总安全系数法对几个隧道设计问题的探讨[J]. 铁道工程学报，2019，36(1)：65-69.(XIAO Mingqing. Exploration on the several problems of tunnel design with the total safety factor method[J]. Journal of Railway Engineering Society，2019，36(1)：65-69.(in Chinese))
[25]	肖明清. 采用总安全系数法对几个隧道设计问题的探讨[J]. 铁道工程学报，2019，36(1)：65-69.(XIAO Mingqing. Exploration on the several problems of tunnel design with the total safety factor method[J]. Journal of Railway Engineering Society，2019，36(1)：65-69.(in Chinese))
[26]	肖明清. 基于总安全系数法的铁路隧道支护结构设计[J]. 中国铁路，2020，(12)：82-88.(XIAO Mingqing. Design of railway tunnel support structure based on overall safety factor method[J]. China Railway，2020，(12)：82-88.(in Chinese))
[27]	中华人民共和国行业标准编写组. TB 10003—2016 铁路隧道设计规范[S]. 北京：中国铁道出版社，2017.(The Professional Standards Compilation Group of People?s Republic of China. TB 10003—2016 Code for design of railway tunnel[S]. Beijing：China Railway Publishing House，2017.(in Chinese))