工业固废除尘灰基泡沫轻质土耐环境性能研究

doi:10.13722/j.cnki.jrme.2023.0659

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1152 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为实现工业固废除尘灰基泡沫轻质土在交通基建中的资源化利用，提出除尘灰基泡沫轻质土的性能提升技术，研发除尘灰基泡沫轻质土新材料，评价复合改性后不同配合比下的除尘灰基泡沫轻质土力学性能、水稳定性能和耐久性能，并探究改性前后材料微观结构变化及其强度形成机制。研究结果表明：非离子型表面活性剂 (AEO–9)可显著提升泡沫稳定性和除尘灰的浸润性，最优掺量分别为原状发泡液质量的20%和除尘灰质量的0.4%；复合改性后除尘灰掺量最高为50%，除尘灰基泡沫轻质土28 d强度达到2.08 MPa，吸水率和软化系数别为21.4%和0.765，干湿循环和冻融循环强度损失分别为13.8%和17.3%，满足水稳定性及耐久性指标要求；扫描电子显微镜(SEM)结果表明，复合改性后的除尘灰基泡沫轻质土微观孔隙结构显著优化，直径小于200 的气泡比例由32.54%提高至52.2%；XRD分析结果进一步表明，在碱性环境下矿渣微粉有助于提高材料初期强度，除尘灰中的Fe2O3在活性激发后有助于材料生成稳定的水化铁铝酸三钙C3(AF)H6，进一步提高了材料强度。本文提出的除尘灰基泡沫轻质土改性方法及其新材料为工业固废的资源化利用、回填工程的降本增效提供了新途径。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	蒋红光1
	马梦媛1
	解庆贺2
	王超2
	公彦昆1
	马川义3
	姚占勇1

关键词 ：土力学, 泡沫轻质土, 除尘灰, 强度, 水稳定性, 耐久性

Abstract：In order to realize the resource utilization of industrial solid waste dust-based foamed lightweight soil in transportation infrastructure construction，this paper puts forward the performance improvement technology of dust-based foamed lightweight soil and develops a new material of dust-based foamed lightweight soil to evaluate the mechanical properties，water stability and durability of dust-based foamed lightweight soil under different mix ratios after composite modification. The microstructure changes and strength formation mechanism of the material is also explored before and after modification. The results show that the nonionic surfactant(AEO-9) can significantly improve the foam stability and the wettability of the dust，and the optimal dosage is 20 % of the mass of the original foaming liquid and 0.4 % of the mass of the dust，respectively. After composite modification，the content of dust ash is up to 50 %，the 28 d strength of dust ash-based foam lightweight soil reaches 2.08 MPa. The water absorption and softening coefficient are 21.4 % and 0.765 respectively. The strength losses of dry-wet cycle and freeze-thaw cycle are 13.8 % and 17.3 %，respectively，which meets the requirements of water stability and durability index. The results of scanning electron microscopy show that the microscopic pore structure of the composite modified fly ash-based foamed lightweight soil is significantly optimized，and the proportion of bubbles with a diameter of less than 200 μm increases from 32.54 % to 52.2 %.The results of XRD analysis further show that the slag powder is helpful to improve the initial strength of the material in the alkaline environment，and the Fe2O3 in the dust is helpful to form a stable hydrated tricalcium aluminosilicate C3(AF)H6 after the activation of the activity，which further improves the strength of the material. The dust-based foam lightweight soil modification method and its new materials provide a cost-reduction and efficient way for the resource utilization of industrial solid waste in the backfilling engineering.

Key words： soil mechanics foamed lightweight soil sintered dust strength water stability durability

引用本文:

蒋红光1，马梦媛1，解庆贺2，王超2，公彦昆1，马川义3，姚占勇1. 工业固废除尘灰基泡沫轻质土耐环境性能研究[J]. 岩石力学与工程学报, 2024, 43(S2): 4032-4043.
JIANG Hongguang1，MA Mengyuan1，XIE Qinghe2，WANG Chao2，GONG Yankun1，MA Chuanyi3，YAO Zhanyong1. Study on the environmental resistance of foamed lightweight soil material from sintered dust. , 2024, 43(S2): 4032-4043.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2023.0659 或 https://rockmech.whrsm.ac.cn/CN/Y2024/V43/IS2/4032

[1]	DAMTOFT J S，LUKASIK J J，HERFORT D，et al. Sustainable development and climate change initiatives[J]. Cement and Concrete Research，2008，38：115-127.
[2]	OU X，ZENG Y，JIANG J，et al. Experimental research on the properties of foamed mixture lightweight soil with red mud Case Stud. Constr. Mater，17(2022)，Article e01673.
[3]	QUE Y，ZHANG H Y，ZHU T J，et al. Amending foamed lightweight soil with tailings sand for embankment applications：Physical properties，durability，and microstructure[J]. Construction and Building Materials，2022，350：128912.
[4]	PASUPATHY K，RAMAKRISHNAN S，SANJAYAN J G. Formulating eco-friendly geopolymer foam concrete by alkali-activation of ground brick waste[J]. Journal of Cleaner Production，2021，325：129180.
[5]	GENCEL O，OGUZ M，GHOLAMPOUR A，et al. Recycling waste concretes as fine aggregate and fly ash as binder in production of thermal insulating foam concrete[J]. Journal of Building Engineering，2021，38：102232.
[6]	ZHANG H Z，HE Y C，WANG C，et al. Statistical mixture design for carbide residue activated blast furnace slag foamed lightweight concrete[J]. Construction and Building Materials，2022，342(A)：127840.
[7]	CHEN X M，YAN Y，LIU Y Z，et al. Utilization of circulating fluidized bed fly ash for the preparation of foam concrete[J]. Construction and Building Materials，2014，54：137-146.
[8]	侯智坚，王爱涛，公彦昆，等. 泡沫轻质土力学性能与干湿循环试验研究[J]. 西安建筑科技大学学报：自然科学版，2021，53(1)：80-85.(HOU Zhijian，WANG Aitao，GONG Yankun，et al. Study on the mechanical property and wetting-drying cycle durability of cement foamed lightweight soil[J]. Journal of Xi'an University of Architecture and Technology：Natural Science，2021，53(1)：80-85.(in Chinese))
[9]	YU Y W，WANG Z M，WEI H，et al. Separation and recovery of potassium chloride from sinter dust of a steel plant[J]. Ironmaking and Steelmaking，2019，46(2)：193-198.
[10]	LONG H L，LI H Y，MA P C，et al. Effectiveness of thermal treatment on Pb recovery and Cl removal from sintering dust[J]. Journal of Hazardous Materials，2021，403：123595.
[11]	LI C H，ZHANG J L，WANG C，et al. Research on the reason of the different type of chloride forming in the process of blast furnace ironmaking[J]. Springer International Publishing，2017：737-745.
[12]	SHANG H X，LI H M，WEI R F，et al. Present situation and prospect of iron and steel dust and sludge utilization technology[J]. Iron and Steel，2019，54(3)：9-17.
[13]	MASAGUER V，OULEGO P，COLLADO S，et al. Characterization of sinter flue dust to enhance alternative recycling and environmental impact at disposal[J]. Waste Manage(Tucson，Ariz.)，2018，79： 251-259.
[14]	ZHAN G，GUO Z C. Preparation of potassium salt with joint production of spherical calcium carbonate from sintering dust[J]. Transactions of Nonferrous Metals Society of China，2015，25(2)：628-639.
[15]	WANG Q R，MA X，WANG S，et al. A green process for the conversion of hazardous sintering dust into K2SO4 and NH4Cl fertilizers[J]. Journal of Environmental Management，2023，326(A)：116676.
[16]	TANG H H，ZHAO L H，SUN W，et al. Extraction of rubidium from respirable sintering dust [J]. Hydrometallurgy，2018，175： 144-149.
[17]	孙国斌，向晓东，邓爱军，等. 除尘灰基脱磷剂的研发[J]. 钢铁，2019，54(10)：96-102.(SUN Guobin，XIANG Xiaodong，DENG Aijun，et al. Development of dedusting ash-based dephosphorizer[J]. Iron and Steel，2019，54(10)：96-102.(in Chinese))
[18]	CHENG Q，FANG D，WU Z C，et al. Preparation and performance of modified sintering dust catalysts for selective catalytic reduction of NOx with NH3[J]. Materials Research Express，2019，6(7)： 075502.
[19]	MA H Y，PEI Y D，PAN W，et al. Characteristics and recycling progress of dust in sintering machine head[J]. China Metallurgy，2018，28(6)：5-8.
[20]	TANG H H，SUN W，HAN H S. A novel method for comprehensive utilization of sintering dust[J]. Transactions of Nonferrous Metals Society of China，2015，25(12)：4 192-4 200.
[21]	ZHAN G，GUO Z C，Water leaching kinetics and recovery of potassium salt from sintering dust[J]. Transactions of Nonferrous Metals Society of China，2013，23(12)：3 770-3 779.
[22]	TANG H H，ZHAO L H，SUN W，et al. Surface characteristics and wettability enhancement of respirable sintering dust by nonionic surfactant[J]. Journal of Engineering，2016，509：323-333.
[23]	周顺鄂，卢忠远，焦雷，等．泡沫混凝土压缩特性及抗压强度模型[J]. 武汉理工大学学报，2010，32(11)：9-13.(ZHOU Shune，LU Zhongyuan，JIAO Lei，et al. Compression property and compression strength model of foamed concrete[J]. Journal of Wuhan University of Technology，2010，32(11)：9-13.(in Chinese))
[24]	LU B，HUO Z，XU Q Y，et al. Characteristics of CSH under carbonation and its effects on the hydration and microstructure of cement paste[J]. Construction and Building Materials，2023，364：129952.
[25]	张振，饶烽瑞，叶观宝，等. 基于X-CT技术的气泡轻质土孔隙结构研究[J]. 建筑材料学报，2020，23(5)：1 104-1 112.(ZHANG Zhen，RAO Fengrui，YE Guanbao，et al. Investigation on void structure of foamed light-weight soil with X-CT scanning technique[J]. Journal of Building Materials，2020，23(5)：1 104-1 112.(in Chinese))
[26]	李丽华，岳雨薇，肖衡林，等. 稻壳灰-水泥固化镉污染土性能及影响机制[J]. 岩土工程学报，2023，45(2)：252-261.(LI Lihua，YUE Yuwei，XIAO Henglin，et al. Performance and influence mechanism of Cd-contaminated soil solidified by rice husk ash-cement[J]. Chinese Journal of Geotechnical Engineering，2023，45(2)：252-261.(in Chinese))
[27]	李颖，肖学英，文静，等. 原料配比对氯氧镁水泥稳定砾石土强度的影响研究[J]. 岩石力学与工程学报，2017，36(增2)：4 158-4 166.(LI Yin，XIAO Xueying，WEN Jing，et al. Influence of raw material ratio of magnesium oxychloride cement on the compressive strength of solidified gravel soil[J]. Chinese Journal of Rock Mechanics and Engineering，2017，36(Supp.2)：4 158-4 166.(in Chinese))