甲烷气通过页岩粗糙裂隙特性的试验研究

doi:10.13722/j.cnki.jrme.2015.1488

摘要
图/表
参考文献(23)
相关文章 (15)

全文: PDF (2266 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要水力压裂法是页岩气开采的主要方法，研究甲烷气通过页岩粗糙裂隙对页岩气的开采具有重大的实际意义。在不同气体压力梯度和围压1～10 MPa条件下，研究CH4通过页岩粗糙裂隙的渗透特性，研究表明：(1) 在应力–渗流耦合条件下，页岩粗糙裂隙的导流能力相比其他类型的岩石更差。(2) 气体流量与压力梯度并非严格的线性增长关系，其增长速率随着围压的增大而降低，气体通过页岩粗糙裂隙的渗流属于非线性流。(3) 围压增大，气体流量和渗透率降低，当围压超过4.0 MPa时，裂隙趋于最大闭合量，流量趋于平稳；(4) 压力梯度和流量遵循Forchheimer方程，围压增大，导致孔隙结构和流体性质发生变化，渗流更偏向于线性流；(5) 根据工程实际，以10%的非线性流效应为临界，得到本试验条件下的临界雷诺数。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	彭辉华1
	周雷1
	2
	卢义玉1
	2

关键词 ：岩石力学, 页岩, 粗糙裂隙, 非线性流, Forchheimer方程

Abstract：Hydrofracturing method is the main technique of shale gas exploitation. Researching the methane through rough shale fractures is of great practical significance in this field. In this work，experiment of CH4 through rough shale fractures was investigated under different gas pressure gradients and confining pressures from 1 to 10 MPa. The main results are shown as follows. The fracture conductivity of shale is lower than that of other rocks. The values of flow rate do not strictly follow a linear trend with pressure changes，and the growth rate decreases with the increase of confining stress， indicating that gas through rough shale fractures is non-linear flow. The effective stress increases with the increase of confining stress. While the hydraulic aperture，flow rate and permeability follow the opposite trend. When the confining pressure exceeds 4.0 MPa，the fracture closure reaches the maximum，and the flow rate keeps stable. Forchheimer equation provides a good description for the non-linear fracture flow process. When confining pressure increases，the pore structure and fluid property changed，and the seepage prefers to the linear flow. According to the engineering practice，critical Reynolds number was determined when 10% of nonlinear effect was considered.

Key words： rock mechanics shale rough fracture non-linear flow Forchheimer equation

引用本文:

彭辉华1，周雷1，2，卢义玉1，2. 甲烷气通过页岩粗糙裂隙特性的试验研究[J]. 岩石力学与工程学报, 2016, 35(S2): 3644-3652.
PENG Huihua1，ZHOU Lei1，2，LU Yiyu1，2. Experimental study on conductivity of rough shale fractures using methane. , 2016, 35(S2): 3644-3652.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2015.1488 或 https://rockmech.whrsm.ac.cn/CN/Y2016/V35/IS2/3644

[1] 汪吉林，刘桂建，王维忠，等. 川东南龙马溪组页岩孔裂隙及渗透性特征[J]. 煤炭学报，2013，38(5)：772–777.(WANG Jilin，LIU Guijian，WANG Weizhong，et al. Characteristics of pore-fissure and permeability of shales in the Longmaxi Formation in southeastern Sichuan Basin[J]. Journal of China Coal Society，2013，38(5)：772–777.(in Chinese))

[2] BEST M E，徐焱东. 页岩渗透率及其在油气勘探中的意义[J]. 石油物探译丛，1995，(4)：34–40.(BEST M E，XU Yandong. Shales permeability and its' application in oil exploration[J]. Oil geophysical exploration translations，1995，(4)：34–40.(in Chinese))

[3] Soeder. Porosity and permeability of eastern Devonian gas shale[J]. Spe Formation Evaluation，2013，3(1)：116–124.

[4] GANGI A F. Variation of whole and fractured porous rock permeability with confining pressure[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1978，15(5)：249–257.

[5] WITHERSPOON P A，WANG J，IWAI K，et al. Validity of cubic law for fluid-flow in a deformable rock fracture[J]. Water Resources Research，1980，16(6)：1 016–1 024.

[6] BARTON N，BANDIS S，BAKHTAR K. Strength，deformation and conductivity coupling of rock joints[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1985，22(3)：121–140.

[7] LI B，JIANG Y，KOYAMA T，et al. Experimental study of the hydro-mechanical behavior of rock joints using a parallel-plate model containing contact areas and artificial fractures[J]. International Journal of Rock Mechanics and Mining Sciences，2008，45(3)：362–375.

[8] CAMMARATA G，FIDELIBUS C，CRAVERO M，et al. The hydro-mechanically coupled response of rock fractures[J]. Rock Mechanics and Rock Engineering，2007，40(1)：41–61.

[9] ZHANG Z，NEMCIK J. Friction factor of water flow through rough rock fractures[J]. Rock Mechanics and Rock Engineering，2013，46(5)：1 125–1 134.

[10] ZHANG Z，NEMCIK J. Fluid flow regimes and nonlinear flow characteristics in deformable rock fractures[J]. Journal of Hydrology，2013，477(1)：139–151.

[11] ZHANG Z，NEMCIK J，MA S. Micro- and macro-behaviour of fluid flow through rock fractures：an experimental study[J]. Hydrogeology Journal，2013，21(8)：1 717–1 729.

[12] TAYLOR J B，CARRANO A L，KANDLIKAR S G. Characterization of the effect of surface roughness and texture on fluid flow-past，present and future[J]. International Journal of Thermal Sciences，2006，45(10)：962–968.

[13] 许光祥，张永兴，哈秋舲. 粗糙裂隙渗流的超立方和次立方定律及其试验研究[J]. 水利学报，2003，(3)：74–79.(XU Guangxiang，ZHANG Yongxing，HA Qiuling. Super-cubic and sub-cubic law of rough fracture seepage and its experiments study[J]. Journal of Hydraulic Engineering，2003，(3)：74–79.(in Chinese))

[14] 蔡金龙，周志芳. 粗糙裂隙渗流研究综述[J]. 勘察科学技术，2009，(4)：18–23.(CAI Jinlong，ZHOU Zhifang. Review of seepage research in rough fractures[J]. Site Investigation Science and Technology，2009，(4)：18–23.(in Chinese))

[15] 蒋宇静，李博，王刚，等. 岩石裂隙渗流特性试验研究的新进展[J]. 岩石力学与工程学报，2008，27(12)：2 377–2 386.(JIANG Yujing，LI Bo，WANG Gang，et al. New advances in experimental study on seepage characteristics of rock fractures[J]. Chinese Journal of Rock Mechanics and Engineering，2008，27(12)：2 377–2 386.(in Chinese))

[16] 熊祥斌，张楚汉，王恩志. 岩石单裂隙稳态渗流研究进展[J]. 岩石力学与工程学报，2009，28(9)：1 839–1 847.(XIONG Xiangbin，ZHANG Chuhan，WANG Enzhi. A review of steady state seepage in a single fracture of rock[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(9)：1 839–1 847.(in Chinese))

[17] 涂乙，邹海燕，孟海平，等. 页岩气评价标准与储层分类[J]. 石油与天然气地质，2013，35 (1)：153–158.(TU Yi，ZOU Haiyan，MENG Haiping，et al. Evaluation criteria and classification of shale gas reservoirs[J]. Oil and Gas Geology，2013，35 (1)：153–158.(in Chinese))

[18] FORCHHEIMER P. Water movement through the ground[J]. Zeitschrift Des Vereines Deutscher Ingenieure，1901，45(1)：1 782– 1 788.

[19] RANJITH P G，DARLINGTON W. Nonlinear single-phase flow in real rock joints[J]. Water Resources Research，2007，43(9)：146–156.

[20] BARTON N，QUADROS E F D. Joint aperture and roughness in the prediction of flow and groutability of rock masses[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1997，34(3)：251–252.

[21] ZENG Z W，GRIGG R. A criterion for non-Darcy flow in porous media[J]. Transport in Porous Media，2006，63(1)：57–69.

[22] 张文娟，王媛，倪小东. Forchheimer型非达西渗流参数特征分析[J]. 水电能源科学，2014，(1)：52–54.(ZHANG Wenjuan，WANG Yuan，NI Xiaodong. Analysis of Parameters characteristics of Forchheimer¢s non-Darcy seepage[J]. 2014，(1)：52–54.(in Chinese))

[23] ZHANG Z，NEMCIK J，QIAO Q，et al. A model for water flow through rock fractures based on friction factor[J]. Rock Mechanics and Rock Engineering，2015，48(2)：559–571.

[24]