水平排水板真空预压–碱激发矿渣固化联合法处理高含水率淤泥的试验研究

doi:10.13722/j.cnki.jrme.2023.0040

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1436 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要疏浚淤泥具有含水率高、强度低、渗透性低等特点，快速高效的加固处理这些淤泥并实现其资源化利用具有重要意义。通过模型试验开展水平排水板真空预压–化学固化(PHDVPS)联合方法快速处理高含水率淤泥的研究。模型试验采用的固化剂包括不同配比的活性氧化镁激发粒化矿渣粉和硅酸盐水泥，并将联合方法的处理效果和效率与单一真空预压方法进行对比。在模型试验中，监测真空预压排水量和淤泥体积的变化；在模型试验结束后，测试不同养护龄期固化土样的无侧限抗压强度(UCS)，并对固化土样的微观结构进行分析。试验结果表明：与单一真空预压法相比，PHDVPS法具有更优越的减量效率和加固效果。固化剂会产生絮凝效应，有助于提高真空脱水效率和效果，使后续的固化反应在更密实的土体骨架中进行，从而进一步大幅提升土体强度。此外，对于PHDVPS方法，以活性氧化镁激发粒化矿渣粉作固化剂比以水泥为固化剂具有更好的减量效果和加固效果。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	宋丁豹1
	蒲诃夫1
	胡海蓝2
	李展毅3
	张纯雪4

关键词 ：土力学, 高含水率淤泥, 水平排水板, 真空预压, 固化, 碱激发矿渣, 模型试验

Abstract：Dredged mud slurry has the characteristics of high water content，low or negligible strength and low hydraulic conductivity. Rapid and efficient treatment and utilization of these slurry are of great significance. This paper conducted a series of experimental to study the rapid treatment of high water content slurry using the combined method of prefabricated horizontal drain vacuum preloading and chemical solidification(abbreviated as PHDVPS). The solidifying agents used in the experiment included magnesium oxide(MgO)-activated ground granulated blast furnace slag(GGBS) and Portland cement. The treatment effect and efficiency of the combined method were compared with those of pure vacuum preloading method. Variation of discharged water mass and slurry volume were monitored during the vacuum preloading stage of the model tests，after which the unconfined compressive strength (UCS) of soil samples at different curing ages was tested，and the microstructures of the treated soils were analyzed. The experiment results indicates that PHDVPS method has a significantly better volume reduction efficiency and a significantly better reinforcement effect than the pure vacuum preloading method. The solidifying agent produces flocculation effects，which improve the vacuum dewatering efficiency，leaving the subsequent solidification process occurring in a denser state of soil matrix and thus achieving much higher strength. Moreover，using GGBS-MgO as the solidifying agent in PHDVPS method has better volume reduction and strength improvement effects than using cement.

Key words： soil mechanics high-water-content mud slurry prefabricated horizontal drain vacuum preloading solidification alkali-activated blast furnace slag model test

引用本文:

宋丁豹1，蒲诃夫1，胡海蓝2，李展毅3，张纯雪4. 水平排水板真空预压–碱激发矿渣固化联合法处理高含水率淤泥的试验研究[J]. 岩石力学与工程学报, 2023, 42(12): 3109-3119.
SONG Dingbao1，PU Hefu1，HU Hailan2，LI Zhanyi3，ZHANG Chunxue4. Experimental investigation on prefabricated horizontal drain-based vacuum preloading-alkali-activated GGBS solidification combined method for #br# treatment of high-water-content mud slurry. , 2023, 42(12): 3109-3119.

链接本文:

https://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2023.0040 或 https://rockmech.whrsm.ac.cn/CN/Y2023/V42/I12/3109

[1]	朱伟，闵凡路，吕一彦，等. “泥科学与应用技术”的提出及研究进展[J]. 岩土力学，2013，34(11)：3 041-3 054.(ZHU Wei，MIN Fanlu，LV Yiyan，et al. Subject of“mud science and application technology”and its research progress[J]. Rock and Soil Mechanics，2013，34(11)：3 041-3 054.(in Chinese))
[2]	TANG C S，CHENG Q，WANG P，et al. Hydro-mechanical behavior of fiber reinforced dredged sludge[J]. Engineering Geology，2020，276：105779.
[3]	王军，王逸杰，刘飞禹. 间歇式真空预压联合电渗加固吹填软土试验[J]. 中国公路学报，2016，29(10)：37-45.(WANG Jun，WANG Yijie，LIU Feiyu. Test of reinforcement by intermittent vacuum preloading- electroosmosis in dredger soft clay[J]. China Journal of Highway and Transport，2016，29(10)：37-45.(in Chinese))
[4]	ZHANG R，DONG C，LU Z，et al. Strength characteristics of hydraulically dredged mud slurry treated by flocculation-solidification combined method[J]. Construction and Building Materials，2019，228：116742.
[5]	XU G，GAO Y，HONG Z，et al. Sedimentation behavior of four dredged slurries in China[J]. Marine Georesources and Geotechnology，2012，30(2)：432-156.
[6]	朱伟，张春雷，刘汉龙，等. 疏浚泥处理再生资源技术的现状[J]. 环境科学与技术，2002，25(4)：39-41.(ZHU Wei，ZHANG Chunlei，LIU Hanlong，et al. The status quo dredged spoils utilization[J]. Environmental Science and Technology，2002，25(4)：39-41.(in Chinese))
[7]	CAI Y，QIAO H，WANG J，et al. Experimental tests on effect of deformed prefabricated vertical drains in dredged soil on consolidation via vacuum preloading[J]. Engineering Geology，2017，222：10-19.
[8]	CHU J，YAN S，LAM K P. Methods for improvement of clay slurry or sewage sludge[J]. Proceedings of the Institution of Civil Engineers-Ground Improvement，2012，165(4)：187-199.
[9]	姜彦彬，何宁，许滨华，等. 真空预压负压分部规律模型试验研究[J]. 岩土工程学报，2017，39(10)：1 874-1 883.(JIANG Yanbin，HE Ning，XU Binhua，et al. Model tests on negative pressure distribution in vacuum preloading[J]. Chinese Journal of Geotechnical Engineering，2017，39(10)：1 874-1 883.(in Chinese))
[10]	QIU Q，MO H，DONG Z. Vacuum pressure distribution and pore pressure variation in ground improved by vacuum preloading[J]. Canadian Geotechnical Journal，2007，44(12)：1 433-1 445.
[11]	SHINSHA H，WATARI Y，KURIMADA Y. Improvement of very soft ground by vacuum consolidation using horizontal drains[C]// Proceedings of the International Conference on Geotechnical Engineering for Coastal Development(GEO-COAST91). Yokohama，Japan：Coastal Development Institute of Technology，1991：387-392.
[12]	CHIBA T，SHINSHA H，TANI Y. Development of a vacuum consolidation method employing horizontal drains[R]. [S. l.]：Japan Dredging and Reclamation Engineering Association Tokyo，1992.
[13]	NAGAHARA H，FUJIYAMA T，ISHIGURO T，et al. FEM analysis of high airport embankment with horizontal drains[J]. Geotextiles and Geomembranes，2004，22(1/2)：49-62.
[14]	罗玉龙，彭华，何金平. 水平塑料排水带固结流态吹填土可行性研究[J]. 武汉理工大学学报，2008，30(6)：74-78.(LUO Yulong，PENG Hua，HE Jinping. Research on the feasibility of consolidating flowed dredger fill by horizontal plastic drainage strip method[J]. Journal of Wuhan University of technology，2008，30(6)：74-78.(in Chinese))
[15]	韦剑锋. 天津市滨海新区吹填土工程处理现状及技术改进试验研究[J]. 工程勘察，2008，6：20-22.(WEI Jianfeng. The present treatment state and existing problems analysis for dredger fill in Tianjin Binhai New Area and research of technology improvement[J]. Geotechnical Investigation and Surveying，2008，6：20-22.(in Chinese))
[16]	王海燕，张文彬，刘凌云，等. 水平排水板真空预压法处理吹填土现场试验研究[J]. 中国港湾建设，2016，36(12)：57-62.(WANG Haiyan，ZHANG Wenbin，LIU Lingyun，et al. Field experimental study on dredger fill flow mud improved by vacuum preloading method employing horizontal drains[J]. China Harbour Engineering，2016，36(12)：57-62.(in Chinese))
[17]	TANG Y X，MIYAZAKI Y，TSUCHIDA T. Practices of resued dredgings by cement treatment[J]. Soils and Foundations，2001，41(5)：129-143.
[18]	丁建文，洪振舜，刘松玉. 疏浚淤泥流动固化土的压汞试验研究[J]. 岩土力学，2011，32(12)：3 591-3 596.(DING Jianwen，HONG Zhenshun，LIU Songyu. Microstructure study of flow-solidified soil of dredged clays by mercury intrusion porosimetry[J]. Rock and Soil Mechanics，2011，32(12)：3 591-3 596.(in Chinese))
[19]	张春雷，王春才，朱伟，等. 初始含水率对水泥固化淤泥效果的影响[J]. 岩土力学，2008，29(增1)：567-570.(ZHANG Chunlei，WANG Chuncai，ZHU Wei，et al. Influence of initial water content on cement solidification effect of dredged material[J]. Rock and Soil Mechanics，2008，29(Supp.1)：567-570.(in Chinese))
[20]	NARENDRA B S，SIVAPULLAIAH P V，SURESH S，et al. Prediction of unconfined compressive strength of soft grounds using computational intelligence techniques：A comparative study[J]. Computers and Geotechnices，2006，33(3)：196-208.
[21]	ZHANG R，ZHENG Y，ZHENG J，et al. Flocculation-solidification combined method for treatment of hydraulically dredged mud at extra high water content[J]. Acta Geotechnica，2020，15(6)：1 685-1 698.
[22]	SCRIVENER K L，KIRKPATRICK R J. Innovation in use and research on cementitious material[J]. Cement and Concrete Research，2008，38(2)：128-136.
[23]	ANAND S，VRAT P，DAHIYA R P. Application of a system dynamics approach for assessment and mitigation of CO2 emissions from the cement industry[J]. Journal of Environmental Management，2006，79(4)：383-398.
[24]	NIDZAM R M，KINUTHIA J M. Sustainable soil stabilization with blastfurnace slag-a review[J]. Proceedings of the Institution of Civil Engineers-Construction Materials，2010，163(3)：157-165.
[25]	SARGENT P，HUGHES P N，ROUAINIA M，et al. The use of alkali activated waste binders in enhancing the mechanical properties and durability of soft alluvial soils[J]. Engineering Geology，2013，152(1)：96-108.
[26]	YI Y，LI C，LIU S. Alkali-activated ground-granulated blast furnace slag for stabilization of marine soft clay[J]. Journal of Materials in Civil Engineering，2015，27(4)：04014146.
[27]	JEGANDAN S，AL-TABBAA A，LISKA M，et al. Sustainable binders for soil stabilization[J]. Proceedings of the ICE-Ground Improvement，2010，163(1)：53-61.
[28]	YI Y，LISKA M，AL-TABBAA A. Initial investigation into the use of GGBS-MgO in soil stabilization[C]// Proceedings of the fourth International Conference on Grouting and Deep Mixing. New Orleans，Louisiana，United States：American Society of Civil Engineers Press，2012：444-453.
[29]	YI Y，ZHENG X，LIU S，et al. Comparison of reactive magnesia-and carbide slag-activated ground granulated blastfurnace slag and Portland cement for stabilization of a natural soil[J]. Applied Clay Science，2015，111：21-26.
[30]	YI Y，LISKA M，AL-TABBAA A. Properties of two model soils stabilized with different blends and contents of GGBS，MgO，Lime，and PC[J]. Journal of Materials in Civil Engineering，2014，26(2)：267-274.
[31]	YI Y，LI C，LIU S，et al. Resistance of MgO-GGBS and CS-GGBS stabilized marine soft clays to sodium sulfate attach[J]. Géotechnique，2014，64(8)：673-679.
[32]	HORPIBULSUK S，MIURA N，NAGARAJ T S. Clay-water/ cement ratio identity for cement admixed soft clays[J]. Journal of Geotechnical and Geoenvironmental Engineering，2005，131(2)：187-192.
[33]	LOCAT J，HÉLÈNE T，LEROUEIL S. Mechanical and hydraulic behaviour of a soft inorganic clay treated with lime[J]. Canadian Geotechnical Journal，1996，33(4)：654-669.
[34]	樊恒辉，高建恩，吴普特，等. 水泥基土壤固化剂固化土的物理化学作用[J]. 岩土力学，2010，31(12)：3 741-3 745.(FAN Henghui，GAO Jianen，WU Pute，et al. Physicochemical actions of stabilized soil with cement- based soil stabilizer[J]. Rock and Soil Mechanics，2010，31(12)：3 741-3 745.(in Chinese))
[35]	OUHADI V R，YONG R N，AMIRI M，et al. Pozzolanic consolidation of stabilized soft clays[J]. Applied Clay Science，2014，95：111-118.
[36]	HORPIBULSUK S，RACHAN R，CHINKULKIJNIWAT A，et al. Analysis of strength development in cement-stabilized silty clay from microstructural considerations[J]. Construction and Building Materials，2010，24(10)：2 011-2 021.
[37]	侯永峰，龚晓南. 水泥土的渗透特性[J]. 浙江大学学报：工学版，2000，34(2)：189-193.(HOU Yongfeng，GONG Xiaonan. The permeability of cement-treated soil[J]. Journal of Zhejiang University：Engineering Science，2000，34(2)：189-193.(in Chinese))
[38]	QUANG N D，CHAI J. Permeability of lime- and cement-treated clayey soil[J]. Canadian Geotechnical Journal，2015，52(9)：1 221-1 227.
[39]	ESKISAR T. Influence of cement treatment on unconfined compressive strength and compressibility of lean clay with medium plasticity[J]. Arabian Journal for Science and Engineering，2015，40：763-772.
[40]	JIN F，GU K，AL-TABBAA A. Strength and hydration properties of reactive MgO-activated ground granulated blastfurnace slag paste[J]. Cement and Concrete Composites，2015，57：8-16.
[41]	JIN F，GU K，ABDOLLAHZADEH A，et al. Effects of different reactive MgOs on the hydration of MgO-activated GGBS paste[J]. Journal of Materials in Civil Engineering，2015，27(7)：B4014001.