Experimental investigation on dynamic mechanical properties and deformation failure mechanism of anchored coal samples
LI Junchen1，2，3，WU Yongzheng1，2，3，FU Yukai2，3，HE Sifeng2，3，SUN Zhuoyue2，3，ZHOU Penghe2，3
(1. School of Energy and Mining Engineering，China University of Mining and Technology(Beijing)，Beijing 100083，China；
2. Coal Mining and Designing Branch，China Coal Research Institute，Beijing 100013，China；3. CCTEG Coal Mining Research Institute，Beijing 100013，China)
Abstract：The dynamic mechanical properties of anchored bodies，which determine the stability of anchor bearing structures，is the scientific basis for further revealing the deformation and failure mechanism of anchor bearing structures under impact dynamic loads. In this study，the dynamic mechanical properties and deformation failure processes of three types(unanchored，end-anchored，and fully-anchored) of specimens subjected to dynamic impact loads under varying pre-tightening forces were investigated with the aid of the split Hopkinson pressure bar(SHPB) technique. Based on the test results，the dynamic stress-strain curves，dynamic strain field evolution characteristics，and anchor rod axial force characteristics of anchored coal specimens were yielded. Furthermore，the interactions among anchor rods，anchoring agents，and pre-tightening forces during impact failure of anchored coal specimens were analyzed，and the dynamic deformation and failure mechanism of anchored coal specimens was disclosed. The following beneficial results were obtained：(1) Under dynamic impact loads，the stress-strain curves of anchored coal specimens exhibit significant elastic-plastic behaviors，and their dynamic strength and average peak strain values both grow with the rise of pre-tightening force. Among the three types of specimens，the dynamic strength values of end-anchored specimens are 3.7%–7.9% lower than those of fully-anchored specimens. (2) Affected by anchor rods and pre-tightening forces，crack development and propagation in the specimens slows down，and the position of crack initiation shifts towards both sides. An increase in the pre-tightening force and anchorage length brings about a decrease in the fragmentation degree of specimens，and these two factors exert a stronger influence on fully-anchored specimens than end-anchored specimens. (3) The deformation compatibility process between specimens and anchor rods is divided into two stages，i.e.，“advance response” and “delayed response”. For end-anchored specimens，the strain response of anchor rods precedes that of the specimens. In contrast，for fully-anchored specimens，it lags behind that of the specimens. (4) Under dynamic impact loads，a larger anchoring length and pre-tightening force correspond to a higher support stiffness and sensitivity of specimens and a smaller peak axial force of anchor rods. The pre-tightening force should be controlled below a value that neither diminishes the strength of surrounding rock nor exceeds the yield load of the rod body，as an excessively high pre-tightening force is inconducive to the overall impact resistance of the anchored coal body. These findings are expected to offer guidance and reference for grasping the anchoring mechanism of roadway support under dynamic impact loads and the degradation mechanism of anchored bearing structures in surrounding rock.
[1] 潘一山，代连朋. 煤矿冲击地压发生理论公式[J]. 煤炭学报，2021，46(3)：789–799.(PAN Yishan，DAl Lianpeng. Theoretical formula of rock burst in coal mines[J]. Journal of China Coal Society，2021，46(3)：789–799.(in Chinese))
[2] 潘一山，齐庆新，王爱文，等. 煤矿冲击地压巷道三级支护理论与技术[J]. 煤炭学报，2020，45(5)：1 585–1 594.(PAN Yishan，QI Qingxin，WANG Aiwen，et al. Theory and technology of three levels support in bump-prone roadway[J]. Journal of China Coal Society，2020，45(5)：1 585–1 594.(in Chinese))
[3] 姜耀东，赵毅鑫，宋彦琦，等. 放炮震动诱发煤矿巷道动力失稳机制分析[J]. 岩石力学与工程学报，2005，24(17)：3 131– 3 136.(JIANG Yaodong，ZHAO Yixin，SONG Yanqi，et al. Analysis of blasting tremor impact on roadway stability in coalmining[J]. Chinese Journal of Rock Mechanics and Engineering，2005，24(17)：3 131–3 136.(in Chinese))
[4] 吴拥政，何 杰，王 洋. 特大断面冲击地压巷道破坏机制及控制技术研究[J]. 煤炭科学技术，2018，46(1)：61–67.(WU Yongzheng，HE Jie，WANG Yang. Study on failure mechanism and control technology of large cross section rockburst roadway[J]. Coal Science and Technology，2018，46(1)：61–67.(in Chinese))
[5] 王爱文，潘一山，赵宝友. 冲击载荷下锚杆–围岩结构冲击失效机制的数值分析[J]. 地震工程学报，2017，39(3)：417–424.(WANG Aiwen，PAN Yishan，ZHAO Baoyou. Numerical analysis of the failure mechanism of bolted rock structure under impact load[J]. China Earthquake Engineering Journal，2017，39(3)：417–424.(in Chinese))
[6] 陈 璐，谭云亮，臧传伟，等. 加锚岩石力学性质及破坏特征试验研究[J]. 岩土力学，2014，35(2)：413–422.(CHEN Lu，TAN Yunliang，ZANG Chuanwei，et al. Test study of mechanical properties and failure characteristics of anchored rock[J]. Rock and Soil Mechanics，2014，35(2)：413–422.(in Chinese))
[7] 邱鹏奇，宁建国，王 俊，等. 冲击动载作用下加锚岩体抗冲时效试验研究[J]. 煤炭学报，2021，46(11)：3 433–3 444.(QIU Penggi，NING Jianguo，WANG Jun，et al. Experimental study on EPRD (effectiveness for a given period to resistance dynamic load) of bolted rock under dynamic load[J]. Journal of China Coal Society，2021，46(11)：3 433–3 444.(in Chinese))
[8] 吴拥政，付玉凯，郝登云. 加锚岩体侧向冲击载荷下动力响应规律研究[J]. 岩石力学与工程学报，2020，39(10)：2 014–2 024.(WU Yongzheng，FU Yukai，HAO Dengyun. Study on dynamic response law of anchored rock mass under lateral impact loads[J]. Chinese Journal of Rock Mechanics and Engineering，2020，39(10)：2 014–2 024.(in Chinese))
[9] 吴拥政，陈金宇，焦建康，等. 冲击载荷作用下锚固围岩损伤破坏机制[J]. 煤炭学报，2018，43(9)：2 389–2 397.(WU Yongzheng，CHEN Jinyu，JIAO Jiankang，et al. Damage and failure mechanism of anchored surrounding rock with impact loading[J]. Journal of China Coal Society，2018，43(9)：2 389–2 397.(in Chinese))
[10] 焦建康，鞠文君. 动载扰动下巷道锚固承载结构冲击破坏机制[J]. 煤炭学报，2021，46(增1)：94–105.(JIAO Jiankang，JU Wenjun. Burst failure mechanism of roadway anchorage bearing structure under dynamic load disturbance[J]. Journal of China Coal Society，2021，46(Supp.1)：94–105.(in Chinese))
[11] 焦建康，鞠文君，吴拥政，等. 动载冲击地压巷道围岩稳定性多层次控制技术[J]. 煤炭科学技术，2019，47(12)：10–17.(JIAO Jiankang，JU Wenjun，WU Yongzheng，et al. Multi-layer control technologies for surrounding rock stability of dynamic-loading rock burst roadway[J]. Coal Science and Technology，2019，47(12)：10–17.(in Chinese))
[12] 张 农，王 朋，阚甲广，等. 高频低能冲击扰动下锚固结构渐进失效试验研究[J]. 煤炭学报，2024，49(1)：309–319.(ZHANG Nong，WANG Peng，KAN Jiaguang，et al. Experimental study on progressive failure of anchoring structure under high-frequency and low-energy impact disturbance[J]. Journal of China Coal Society，2024，49(1)：309–319.(in Chinese))
[13] 刘学生，范德源，谭云亮，等. 深部动载作用下超大断面硐室群锚固围岩破坏失稳机制研究[J]. 岩土力学，2021，42(12)：3 407–3 418. (LIU Xuesheng，FAN Deyuan，TAN Yunliang，et al. Failure and instability mechanism of anchored surrounding rock for deep chamber group with super-large section under dynamic disturbances[J]. Rock and Soil Mechanics，2021，42(12)：3 407–3 418.(in Chinese))
[14] 宁建国，邱鹏奇，杨书浩，等. 深部大断面硐室动静载作用下锚固承载结构稳定机制研究[J]. 采矿与安全工程学报，2020，37(1)：50–61.(NING Jianguo，QIU Pengqi，YANG Shuhao，et al. Damage mechanism and support of surrounding rock anchorage structure of deep large section chamber under static-dynamic coupling loading[J]. Journal of Mining and Safety Engineering，2020，37(1)：50–61.(in Chinese))
[15] 王 琦，吴文瑞，何满潮，等. 恒阻吸能锚固岩体动力特性及控制机制[J]. 煤炭学报，2023，48(8)：3 009–3 019.(WANG Qi，WU Wenrui，HE Manchao，et al. Dynamic characteristics and control mechanism of anchored rock with constant resistance and energy absorption material[J]. Journal of China Coal Society，2023，48(8)：3 009–3 019.(in Chinese))
[16] 赵增辉，孙 伟，刘 浩，等. 冲击载荷下节理岩体锚固系统剪切动响应分析[J]. 采矿与岩层控制工程学报，2022，4(5)：72–80. (ZHAO Zenghui，SUN Wei，LIU Hao，et al. Shear dynamic response of jointed rock mass anchorage system under impact load[J]. Journal of Mining and Strata Control Engineering，2022，4(5)：72–80.(in Chinese))
[17] 李 壮，王 俊，宁建国，等. 预紧力对锚固体抗动载冲击能力影响的试验研究[J]. 中国矿业大学学报，2021，50(3)：459–468.(LI Zhuang，WANG Jun，NING Jianguo，et al. Experimental research on influence of pre-tension on dynamic load impact resistance of anchorage body[J]. Journal of China University of Mining and Technology，2021，50(3)：459–468.(in Chinese))
[18] 王 斌，宁 勇，冯 涛，等. 低应变率加载速度影响脆性岩体锚固效果的试验研究[J]. 煤炭学报，2019，44(9)：2 691–2 699.(WANG Bin，NING Yong，FENG Tao，et al. Experimental study on anchoring effect of brittle rock mass influenced by loading rates at low strain rate[J]. Journal of China Coal Society，2019，44(9)：2 691–2 699.(in Chinese))
[19] ZHOU Y，XIA K， LI X，et al. Suggested methods for determining the dynamic strength parameters and mode–I fracture toughness of rock materials[J]. International Journal of Rock Mechanics and Mining Sciences，2011，49(1)：105–112.
[20] 王 斌，宁 勇，冯 涛，等. 单轴压缩条件下锚杆影响脆性岩体破裂的细观机制[J]. 岩土工程学报，2018，40(9)：1 593–1 600. (WANG Bin，NING Yong，FENG Tao，et al. Meso-mechanism of rock failure influenced by bolt anchorage under uniaxial compression loading[J]. Chinese Journal of Geotechnical Engineering，2018，40(9)：1 593–1 600.(in Chinese))
[21] 王 斌，宁 勇，冯 涛，等. 加锚砂岩单轴力学特性及屈曲型岩爆控制机制[J]. 中南大学学报：自然科学版，2019，50(9)：2 285–2 294.(WANG Bin，NING Yong，FENG Tao，et al. Uniaxial mechanical characteristics of anchored sandstone and its mechanism of controlling buckling rockburst[J]. Journal of Central South University：Science and Technology，2019，50(9)：2 285–2 294.(in Chinese))
[22] 余伟健，吴根水，刘 泽，等. 煤–岩–锚组合锚固体单轴压缩试验及锚杆力学机制[J]. 岩石力学与工程学报，2020，39(1)：57–68.(YU Weijian，WU Genshui，LIU Ze，et al. Uniaxial compression test of coal-rock-bolt anchorage body and mechanical mechanisms of bolts[J]. Chinese Journal of Rock Mechanics and Engineering，2020，39(1)：57–68.(in Chinese))
[23] LI XB，LI CJ，CAO WZ，et al. Dynamic stress concentration and energy evolution of deep-buried tunnels under blasting loads [J]. International Journal of Rock Mechanics and Mining Sciences，2018，104：131–146.
[24] ZHAGN X P，WONG L N Y. Cracking processes in rock-like material containing a single flaw under uniaxial compression：a numerical study based on parallel bonded-particle model approach[J]. Rock Mechanics and Rock Engineering，2012，45(5)：711–737.
[25] 康红普，王金华. 煤巷锚杆支护理论与成套技术[M]. 北京：煤炭工业出版社，2007：15–17.(KANG Hongpu，et al. Rock bolting theory and complete technology for coal roadways[M]. Beijing：China Coal Industry Publishing House，2007：15–17.(in Chinese))
[26] 林 健，石 垚，孙志勇，等. 端部锚固锚杆预应力场分布特征的大型模型试验研究[J]. 岩石力学与工程学报，2016，35(11)：2 237–2 247.(LIN Jian，SHI Yao，SUN Zhiyong，et al. Large scale model test on the distribution characteristics of the prestressed field of end-anchored bolts[J]. Chinese Journal of Rock Mechanics and Engineering，2016，35(11)：2 237–2 247.(in Chinese))
2025, Vol. 44 
