不同含水率煤体单轴压缩力学特性及损伤统计模型研究

doi:10.13722/j.cnki.jrme.2017.1080

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (482 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为了研究水分对煤体力学特性的影响，制备不同含水率的原煤煤样和型煤煤样，进行单轴压缩力学试验。根据试验结果，讨论2种煤样的变形特性随含水率变化的规律，分析煤样的力学参数和含水率的关系，对比不同含水率下2种煤样的破坏方式。研究结果表明，随着含水率增大，2种煤样的应力–应变曲线的压密阶段区间增大，弹性阶段区间缩小，屈服阶段更加显著。2种煤样的含水率和力学参数拟合关系相同，抗压强度与含水率呈负线性关系，峰值应变与含水率呈正线性关系，弹性模量与含水率呈负指数关系。从干燥状态到饱水状态，发生破坏后，原煤煤样依次表现为剪切破坏、拉伸–剪切组合破坏，型煤煤样依次表现为剪切破坏、拉伸破坏、拉伸–剪切组合破坏。在力学试验的基础上，考虑煤体压密阶段的应力–应变关系，建立考虑含水率的煤体分段式损伤本构模型，对试验结果进行了验证。拟合结果显示理论曲线和试验数据具有较高的拟合度，模型适用于分析不同含水率的煤体单轴压缩力学问题。研究结论为受煤体水分影响的煤矿工程的分析和设计提供了参考。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	王凯1
	2
	蒋一峰1
	2
	徐超1
	2

关键词 ：岩石力学, 原煤煤样, 型煤煤样, 含水率, 单轴力学压缩试验, 本构模型

Abstract：In order to study the influence of moisture on the mechanical properties of coal，raw coal and briquette coal samples with different moisture contents were prepared，and the uniaxial compression tests were carried out. Based on the test results，the deformation characteristics of two types of coal samples with various moisture contents were discussed，the relationship between the mechanical parameters and moisture contents of coal samples were analyzed and the failure modes of two coal samples with different moisture contents were compared. The results show that，as the moisture content increases，the width of the compaction phase in the stress-strain curve increases，the width of the elastic phase decreases and the yield phase becomes more visible. The fitting relationships between the moisture content and mechanical parameters of two types of coal samples are the same. The moisture content and the compressive strength have a negative linear relationship，the peak strain and the moisture content have a positive linear relationship，and the elastic modulus and the moisture content have a negative exponential relationship. From the dry state to the saturated water state，the raw coal samples show shear failure and combined tensile-shear failure in turn，while the briquette samples show shear failure，tensile failure and combined tensile-shear failure. The segmented constitutive model of coal mass damage considering moisture content and the stress-strain relationship in the compaction stage of coal was established. The fitting results show that the theoretical curve is consistent with the experimental data.

Key words： rock mechanics raw coal sample briquette coal sample moisture content uniaxial mechanical compression test constitutive model

引用本文:

王凯1，2，蒋一峰1，2，徐超1，2. 不同含水率煤体单轴压缩力学特性及损伤统计模型研究[J]. 岩石力学与工程学报, 2018, 37(5): 1070-1079.
WANG Kai1，2，JIANG Yifeng1，2，XU Chao1，2. Mechanical properties and statistical damage model of coal with different moisture contents under uniaxial compression. , 2018, 37(5): 1070-1079.

链接本文:

http://www.rockmech.org/CN/10.13722/j.cnki.jrme.2017.1080 或 http://www.rockmech.org/CN/Y2018/V37/I5/1070

[23]	LEMAITRE J. How to use damage mechanics[J]. Nuclear Engineering and Design，1984，80(2)：233-245.
[1]	谢和平，高峰，鞠杨，等. 深地煤炭资源流态化开采理论与技术构想[J]. 煤炭学报，2017，42(3)：547-556.(XIE Heping，GAO Feng，JU Yang，et al. Theoretical and technological conception of the fluidization mining for deep coal resources[J]. Journal of China Coal Society，2017，42(3)：547-556.(in Chinese))
[8]	茅献彪，陈占清，徐思朋，等. 煤层冲击倾向性与含水率关系的试验研究[J]. 岩石力学与工程学报，2001，20(1)：49-52.(MAO Xianbiao，CHEN Zhanqing，XU Sipeng，et al. Experiment study on the relationship between the burst tendency and water content in coal seam[J]. Chinese Journal of Rock Mechanics and Engineering，2001，20(1)：49-52.(in Chinese))
[6]	秦虎，黄滚，王维忠. 不同含水率煤岩受压变形破坏全过程声发射特征试验研究[J]. 岩石力学与工程学报，2012，31(6)： 1 115-1 120.(QIN Hu，HUANG Gun，WANG Weizhong. Experiment study of acoustic emission characteristics of coal samples with different moisture content in process of compression deformation and failure[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(6)：1 115-1 120.(in Chinese))
[11]	尹光志，蒋长宝，许江，等. 煤层气储层含水率对煤层气渗流影响的试验研究[J]. 岩石力学与工程学报，2011，30(增2)：3 401-3 406. (YIN Guangzhi，JIANG Zhangbao，XU Jiang，et al. Experiment study of influences for water content in coalbed gas reservoirs on methane seepage[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(Supp.2)：3 401-3 406.(in Chinese))
[16]	齐庆新，彭永伟，李宏艳，等. 煤岩冲击倾向性研究[J]. 岩石力学与工程学报，2011，30(增1)：2 736-2 742.(QI Qingxin，PENG Yongwei，LI Hongyan，et al. Comparative research on permeability characteristics in complete stress-strain process of briquettes and coal samples[J]. Chinese Journal of Rock Mechanics and Engineering，2011，30(Supp.1)：2 736-2 742.(in Chinese))
[2]	顾大钊. 煤矿地下水库理论框架和技术体系[J]. 煤炭学报，2015，40(2)：239-246.(GU Dazhao. Theory framework and technological system of coal mine underground reservoir[J]. Journal of China Coal Society，2015，40(2)：239-246.(in Chinese))
[12]	康红普. 水对岩石的损伤[J]. 水文地质工程地质，1994，(3)：39-41.(KANG Hongpu. The damage of water to rock[J]. Hydrogeology and Engineering Geology，1994，(3)：39-41.(in Chinese))
[5]	PAN Z，CONNELL L D，MICHAEL C，et al. Effects of matrix moisture on gas diffusion and flow in coal[J]. Fuel，2010，89(11)：3 207-3 217.
[15]	中华人民共和国行业标准编写组. GT/T23561.5—2009煤与岩石物理力学性质测定方法[S]. 北京：中国标准出版，2010.(The Professional Standards Compilation Group of Peoples Republic of China. GT/T23561.5—2009. Methods for determining the physical and mechanical properties of coal and rock[S]. Beijing：Standards Press of China，2010.(in Chinese))
[3]	顾大钊，颜永国，张勇，等. 煤矿地下水库煤柱动力响应与稳定性分析[J]. 煤炭学报，2016，41(7)：1 589-1 597.(GU Dazhao，YAN Yongguo，ZHANG Yong，et al. Experimental study and numerical simulation for dynamic response of coal pillars in coal mine underground reservoir[J]. Journal of China Coal Society，2016，41(7)：1 589-1 597.(in Chinese))
[10]	魏建平，位乐，王登科. 含水率对含瓦斯煤的渗流特性影响试验研究[J]. 煤炭学报，2014，39(1)：97-103.(WEI Jianping，WEI Le，WANG Dengke. Experimental study of moisture content influences on permeability of coal containing gas[J]. Journal of China Coal Society，2014，39(1)：97-103.(in Chinese))
[13]	胡昕，洪宝宁，孟云梅. 考虑含水率影响的红砂岩损伤统计模型[J]. 中国矿业大学学报，2007，36(5)：609-613.(HU Xin，HONG Baoning，MENG Yunmei. Statistical damage model of red sandstone with effect of water ratio considered[J]. Journal of China University of Mining and Technology，2007，36(5)：609-613.(in Chinese))
[20]	蔡美峰，何满潮，刘东燕. 岩石力学与工程[M]. 北京：科学出版社，2013：35-37.(CAI Meifeng，HE Manchao，LIU Dongyan. Rock mechanics and engineering[M]. Beijing：Science Press，2013：35-37.(in Chinese))
[4]	PERERA M S A， RANJITH P G， PETER M. Effects of saturation medium and pressure on strength parameters valley brown coal： carbon dioxide，water and nitrogen saturations[J]. Energy，2011，36(12)：6 941-6 947.
[7]	刘忠锋，康天合，鲁伟，等. 煤层注水对煤体力学特性影响的试验[J]. 煤炭科学技术，2010，38(1)：17-19.(LIU Zhongfeng，KANG Tianhe，LU Wei，et al. Experiment on water injection affected to mechanics features of coal body[J]. Coal Science and Technology，2010，38(1)：17-19.(in Chinese))
[9]	魏建平，秦恒洁，王登科. 基于水分影响的加-卸载围压条件下含瓦斯煤渗流特性研究[J]. 采矿与安全工程学报，2014，31(6)：987-994.(WEI Jianping，QIN Hengjie，WANG Dengke. Seepage characteristics of coal mass containing gas considering moisture effect in loading-unloading confining pressure test[J]. Journal of Mining and Safety Engineering，2014，31(6)：987-994.(in Chinese))
[14]	吴勇. 不同含水条件下白云岩力学特性试验研究[硕士学位论文][D]. 昆明：昆明理工大学，2012.(WU Yong. Experimental research on mechanical characteristics of dolomite in different water conditions[M. S. Thesis][D]. Kunming：Kunming University of Science and Technology，2012.(in Chinese))
[17]	曹树刚，李勇，郭平，等. 型煤与原煤全应力-应变过程渗流特性对比研究[J]. 岩石力学与工程学报，2010，29(5)：899-906.(CAO Shugang，LI Yong，GUO Ping，et al. Comparative research on permeability characteristics in complete stress-strain process of briquettes and coal samples[J]. Chinese Journal of Rock Mechanics and Engineering，2010，29(5)：899-906.(in Chinese))
[19]	YAO Q L，LI X H，ZHOU J，et al. Experimental study of strength characteristics of coal specimens after water intrusion[J]. Arabian Journal of Geosciences，2015，8(9)：6 779-6 789.
[22]	鲁祖德. 裂隙岩石水-岩作用力学特性试验研究与理论分析[博士学位论文][D]. 武汉：中国科学院武汉岩土力学研究所，2010.(LU Zude. Experimental and theoretical analysis on mechanical properties of fractured rock under water-rock interaction[Ph. D. Thesis][D]. Wuhan：Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，2010.(in Chinese))
[24]	陈四利. 化学腐蚀下岩石细观损伤破裂机制及其本构模型[博士学位论文][D]. 沈阳：东北大学，2003.(CHEN Sili. Meso- mechanism and its constitutive model of rock damage under chemical erosion[Ph. D. Thesis][D]. Shenyang：Northeastern University，2003.(in Chinese))
[26]	曹文贵，赵明华，刘成学. 基于Weibull分布的岩石损伤软化模型及其修正方法研究[J]. 岩石力学与工程学报，2004，23(19)：3 226- 3 231.(CAO Wengui，ZHAO Minghua，LIU Chengxue. Study on the model and its modifying method for rock softening and damage based on Weibull random distribution[J]. Chinese Journal of Rock Mechanics and Engineering，2004，23(19)：3 226-3 231.(in Chinese))
[27]	徐卫亚，韦立德. 岩石损伤统计本构模型的研究[J]. 岩石力学与工程学报，2002，21(6)：787-791.(XU Weiya，WEI Lide. Study on statistical damage constitutive model of rock[J]. Chinese Journal of Rock Mechanics and Engineering，2002，21(6)：787-791.(in Chinese))
[18]	刘恺德，刘泉声，朱元广，等. 考虑层理方向效应煤岩巴西劈裂及单轴压缩试验研究[J]. 岩石力学与工程学报，2013，32(2)：308-316.(LIU Kaide，LIU Quansheng，ZHU Yuanguang，et al. Experimental study of coal considering directivity effect of bedding plane under Brazilian splitting and uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(2)：308-316.(in Chinese))
[21]	赵红鹤，高富强，杨小林. 基于不同分布的分段式岩石损伤本构模型[J]. 矿业研究与开发，2015，35(4)：64-67.(ZHAO Honghe，GAO Fuqiang，YANG Xiaolin. Study on segmentary damage constitutive model based on different distribution[J]. Minging Research and Development，2015，35(4)：64-67.(in Chinese))
[25]	游强，游猛. 岩石统计损伤本构模型及对比分析[J]. 兰州理工大学学报，2011，37(3)：119-123.(YOU Qiang，YOU Meng. Statistical damage constitutive models of rock and their comparative analysis[J]. Journal of Lanzhou University Technology，2011，37(3)：119-123.(in Chinese))
[28]	刘星光. 含瓦斯煤变形破坏特征及渗透行为研究[博士学位论文][D]. 徐州：中国矿业大学，2013.(LIU Xingguang. Study on the deformation and failure characteristics and the permeation behavior of gas-saturated coal[Ph. D. Thesis][D]. Xuzhou：China University of Mining and Technology，2013.(in Chinese))