不同加载刚度下煤体冲击倾向性测试及评价指数分析

doi:10.13722/j.cnki.jrme.2023.0046

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2439 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要煤矿冲击地压是顶板–巷帮系统动力失稳破坏的工程灾变问题，顶板作用下的巷帮冲击破坏研究更符合井下原位地质与工程条件。利用研制的多级可调刚度加载装置，研究不同试验机加载刚度下煤体冲击倾向性指数测试结果，并根据建立的巷道围岩供能冲击表征模型，提出评价巷帮冲击危险性的冲击供能指数。研究表明：随着试验机–试件刚度比的减小，煤体峰后破坏速度加快，破坏形式由块体开裂和剥离转化为碎块崩裂和弹射，碎块分形维数增大，试件破碎程度增强；煤体单轴抗压强度、弹性能量指数的测试值与刚度比相关性很小，动态破坏时间与刚度比呈幂函数正相关的关系，冲击能量指数与刚度比呈幂函数负相关的关系；顶板供能与巷帮煤体释放弹性能叠加是造成巷帮冲击破坏的重要原因，随着顶板–巷帮刚度比的减小，顶板对巷帮供能增加，冲击危险性增强。提出的考虑顶板刚度与供能的巷帮冲击供能指数，可作为评价不同顶板与巷帮组合刚度条件下巷帮冲击危险性的重要指标。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	尹延春1
	赵同彬1
	李海涛2
	汤兴学1
	3
	朱元慧1

关键词 ：采矿工程, 冲击地压, 刚度理论, 冲击倾向性, 冲击危险性, 顶板刚度, 巷帮煤体

Abstract：Coal burst is an engineering dynamic failure of roof and sidewall system. The research of sidewall bursting failure under the action of roof is more suitable for in-situ geological and engineering conditions in coal mining. By using the developed multi-level changeable stiffness loading test device，the test results of coal bursting liability index under different loading stiffness of the test device were studied. According to the energy supply burst characterization model of the roadway surrounding rock，the bursting energy supply index for bursting risk evaluation was proposed. The results show that with the decrease of the device-specimen stiffness ratio，the post-peak failure velocity of coal is accelerated，and the failure mode of coal is transformed from block cracking and peeling to fragment ejection. The fragment fractal dimension and fracture degree of specimens increase. Testing value of the uniaxial compressive strength and elastic strain energy index have little correlation with the stiffness ratio. The duration of dynamic fracture is positively correlated with the stiffness ratio in a power function，while the bursting energy index is negatively correlated with the stiffness ratio in a power function. The roof supply energy，together with the coal released elastic energy，is an important cause of coal burst. With the decrease of roof-sidewall stiffness ratio，the roof supply energy increases，and the coal bursts more easily. The proposed bursting energy supply index can be used as an important indicator to evaluate coal burst risk under different roof and sidewall stiffness conditions.

Key words： mining engineering coal burst stiffness theory bursting liability burst risk roof stiffness coal sidewall

引用本文:

尹延春1，赵同彬1，李海涛2，汤兴学1，3，朱元慧1. 不同加载刚度下煤体冲击倾向性测试及评价指数分析[J]. 岩石力学与工程学报, 2023, 42(12): 2982-2992.
YIN Yanchun1，ZHAO Tongbin1，LI Haitao2，TANG Xingxue1，3，ZHU Yuanhui1. Bursting liability test and evaluation index analysis of coal under different loading stiffnesses. , 2023, 42(12): 2982-2992.

链接本文:

http://rockmech.whrsm.ac.cn/CN/10.13722/j.cnki.jrme.2023.0046 或 http://rockmech.whrsm.ac.cn/CN/Y2023/V42/I12/2982

[8]	潘一山. 煤矿冲击地压扰动响应失稳理论及应用[J]. 煤炭学报，2018，43(8)：2 091-2 098.(PAN Yishan. Disturbance response instability theory of rockburst in coal mine[J]. Journal of China Coal Society，2018，43(8)：2 091-2 098.(in Chinese))
[4]	COOK N G W. The failure of rock[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1965，2(04)：389-403.
[10]	LI Z L，DOU L M，WANG G F，et al. Risk evaluation of rock burst through theory of static and dynamic stresses superposition[J]. Journal of Central South University，2015，22(2)：676-683.
[12]	LI CHARLIE CHUNLIN，ZHAO T B，ZHANG Y B，et al. A study on the energy sources and the role of the surrounding rock mass in strain burst[J]. International Journal of Rock Mechanics and Mining Sciences，2022，154：105114.
[5]	KIDYBINSKI A. Bursting liability indices of coal[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1981，18(4)：295-304.
[7]	齐庆新，潘一山，李海涛，等. 煤矿深部开采煤岩动力灾害防控理论基础与关键技术[J]. 煤炭学报，2020，45(5)：1 567-1 584.(QI Qingxin，PAN Yishan，LI Haitao，et al. Theoretical basis and key technology of prevention and control of coal-rock dynamic disasters in deep coal mining[J]. Journal of China Coal Society，2020，45(5)： 1 567-1 584.(in Chinese))
[15]	陶在朴，章梦涛，朱之芳. 岩石的全程破坏试验与FM型刚性试验机[J]. 阜新矿业学院学报，1979，(3)：17-23.(TAO Zaipu，ZHANG Mengtao，ZHU Zhifang. Rock failure test and FM type rigidity testing machine[J]. Journal of Liaoning Technical University，1979，(3)：17-23. (in Chinese))
[6]	李玉生. 冲击地压机制及其初步应用[J]. 中国矿业学院学报，1985，14(3)：42-48. (LI Yusheng. Rockburst mechanism and its preliminary application[J]. Journal of China University of Mining and Technology，1985，14(3)：42-48.(in Chinese))
[1]	窦林名，田鑫元，曹安业，等. 我国煤矿冲击地压防治现状与难题[J]. 煤炭学报，2022，47(1)：152-171.(DOU Linming，TIAN Xinyuan，CAO Anye，et al. Present situation and problems of coal mine rock bust prevention and control in China[J]. Journal of China Coal Society，2022，47(1)：152-171.(in Chinese))
[2]	谭云亮，郭伟耀，辛恒奇，等. 煤矿深部开采冲击地压监测解危关键技术研究[J]. 煤炭学报，2019，44(1)：160-172.(TAN Yunliang，GUO Weiyao，XIN Hengqi，et al. Key technology of rock burst monitoring and control in deep coal mining[J]. Journal of China Coal Society，2019，44(1)：160-172.(in Chinese))
[22]	SIMON R. Analysis of fault-slip mechanisms in hard rock mining[Ph. D. Thesis][D]. Montreal：McGill University，1999.
[32]	刘刚，李明. 煤岩单轴与三轴压缩试验研究[J]. 煤矿安全，2013，44(7)：4-6.(LIU Gang，LI Ming. Experimental study of coal rock uniaxial and triaxial compression[J]. Safety in Coal Mines，2013，44(7)：4-6.(in Chinese))
[3]	齐庆新，李一哲，赵善坤，等. 我国煤矿冲击地压发展70年：理论与技术体系的建立与思考[J]. 煤炭学报，2019，47(9)：1-40.(QI Qingxin，LI Yizhe，ZHAO Shankun，et al. Seventy years development of coal mine rockburst in China：establishment and consideration of theory and technology system[J]. Journal of China Coal Society，2019，47(9)：1-40.(in Chinese))
[9]	潘俊锋，丁宇，毛德兵，等. 煤矿开采冲击地压启动理论[J]. 岩石力学与工程学报，2012，31(3)：586-596.(PAN Junfeng，DING Yu，MAO Debing，et al. Theory of rockburst start-up during coal mining[J]. Chinese Journal of Rock Mechanics and Engineering，2012，31(3)：586-596.(in Chinese))
[11]	钱七虎. 岩爆、冲击地压的定义、机制、分类及其定量预测模型[J]. 岩土力学，2014，35(1)：1-6.(QIAN Qihu. Definition，mechanism，classification and quantitative forecast model for rockburst and pressure bump[J]. Rock and Soil Mechanics，2014，35(1)：1-6.(in Chinese))
[13]	BIENIAWSKI Z T，DENKHAUS H G，VOGLER U W. Failure of fractured rock[J]. International Journal of Rock Mechanics and Mining Sciences and Geomechanics Abstracts，1969，6(3)：323-330.
[19]	CAI M，HOU P Y，ZHANG X W，et al. Post-peak stress-strain curves of brittle hard rocks under axial-strain-controlled loading[J]. International Journal of Rock Mechanics and Mining Sciences，2021，147(2021)：104921.
[21]	赵同彬，尹延春，谭云亮，等. 变刚度加载试验系统的研制及其在煤岩破坏力学行为测试中的应用[J]. 岩石力学与工程学报，2022，41(9)：1 846-1 857.(ZHAO Tongbin，YIN Yanchun，TAN Yunliang，et al. Development of a rock testing system with changeable stiffness and its application in the study on the rock failure mechanical behavior[J]. Chinese Journal of Rock Mechanics and Engineering，2022，41(9)：1 846-1 857.(in Chinese))
[29]	赵同彬，尹延春，谭云亮，等. 基于颗粒流理论的煤岩冲击倾向性细观模拟试验研究[J]. 煤炭学报，2014，39(2)：280-285.(ZHAO Tongbin，YIN Yanchun，TAN Yunliang，et al. Bursting liability of coal research of heterogeneous coal based on particle flow microscopic test[J]. Journal of China Coal Society，2014，39(2)：280-285.(in Chinese))
[39]	冯国瑞，文晓泽，郭军，等. 含水率对煤样声发射特征和碎块分布特征影响的试验研究[J]. 中南大学学报：自然科学版，2021，52(8)：2 910-2 918.(FENG Guorui，WEN Xiaoze，GUO Jun，et al. Study on influence of moisture content on coal sample AE properties and fragment distribution characteristics[J]. Journal of Central South University：Science and Technology，2021，52(8)：2 910-2 918.(in Chinese))
[14]	HUDSON JA，CROUCH SL，FAIRHURST C. Soft，stiff and servo-controlled testing machines：a review with reference to rock failure[J]. Engineering Geology，1972，6(3)：155-189.
[38]	李杨杨，张士川，文志杰，等. 循环荷载下煤样能量转化与碎块分布特征[J]. 煤炭学报，2019，44(5)：1 411-1 420.(LI Yangyang，ZHANG Shichuan，WEN Zhijie，et al. Energy conversion and fragment distribution characteristics of coal sample under uniaxial cyclic loading[J]. Journal of China Coal Society，2019，44(5)： 1 411-1 420.(in Chinese))
[40]	何满潮，杨国兴，苗金丽，等. 岩爆实验碎屑分类及其研究方法[J]. 岩石力学与工程学报，2009，28(8)：1 521-1 529.(HE Manchao，YANG Guoxing，MIAO Jinli，et al. Classification and research methods of rockburst experimental fragments[J]. Chinese Journal of Rock Mechanics and Engineering，2009，28(8)：1 521-1 529.(in Chinese))
[43]	谭云亮，郭伟耀，赵同彬，等. 深部煤巷帮部失稳诱冲机制及“卸-固”协同控制研究[J]. 煤炭学报，2020，45(1)：66-81.(TAN Yunliang，GUO Weiyao，ZHAO Tongbin，et al. Coal rib burst mechanism in deep roadway and“stress relief-support reinforcement”synergetic control and prevention[J]. Journal of China Coal Society，2020，45(1)：66-81.(in Chinese))
[45]	TAN Y L，LIU X S，SHEN B T，et al. New approaches to testing and evaluating the impact capability of coal seam with hard roof and/or floor in coal mines[J]. Geomechanics and Engineering，2018，14(4)：367-376.
[47]	付玉凯. 基于剩余能量释放率指标的组合煤岩体冲击倾向性研究[J]. 煤矿安全，2018，49(9)：63-67.(FU Yukai. Study on impact tendency of combined coal and rock mass based on residual energy release rate index[J]. Safety in Coal Mines，2018，49(9)：63-67.(in Chinese))
[48]	中华人民共和国国家标准编. GB/T 25217.3—2019冲击地压测定、监测与防治方法第3部分：煤岩组合试件冲击倾向性分类及指数的测定方法[S]. 北京：中国标准出版社，2019.(The National Standards Compilation Group of People?s Republic of China. GB/T 25217.3—2019，Methods for test，monitoring and prevention of rock burst—Part3：Classification and laboratory test method on bursting liability of coal-rock combinations sample[S]. Beijing：Standards Press of China，2019.(in Chinese))
[16]	唐春安. 试验机刚性与测量系统频率响应对测试岩石荷载-位移关系的影响[J]. 岩石力学与工程学报，1987，6(3)：265-276. (TANG Chun?an. Effect of testing machine stiffness and frequency characteristic of recording system on measurements of complete load displacement relations for rock specimens[J]. Chinese Journal of Rock Mechanics and Engineering，1987，6(3)：265-276.(in Chinese))
[17]	顾金才，范俊奇，孔福利，等. 抛掷型岩爆机制与模拟试验技术[J]. 岩石力学与工程学报，2014，33(6)：1 081-1 089.(GU Jincai，FAN Junqi，KONG Fuli，et al. Mechanism of ejective rockburst and model testing technology[J]. Chinese Journal of Rock Mechanics and Engineering，2014，33(6)：1 081-1 089.(in Chinese))
[18]	程骋. 应变岩爆的岩体刚度效应研究[博士学位论文][D]. 北京：中国矿业大学，2013.(CHENG Cheng. Effect of rock mass stiffness on strain rockburst[Ph. D. Thesis][D]. Beijing：China University of Mining and Technology，2013.(in Chinese))
[20]	HOU P Y，CAI M，ZHANG X W，et al. Post-peak stress-strain curves of brittle rocks under axial- and lateral-strain-controlled loadings[J]. Rock Mechanics and Rock Engineering，2022，55(2)：855-884.
[23]	HOMAND F，PIGUET JP，REVALOR R. Dynamic phenomena in mines and characteristics of rocks[C]// Proceedings of the 2nd International Symposium on Rock Bursts and Seismicity in Mines. Minneapolis：[s. n.]，1988：195-209.
[25]	刘景儒，张永双，吴树仁，等. 滇藏铁路丽江玉峰寺隧道围岩岩爆刚度判据[J]. 地质通报，2007，26(6)：748-755.(LIU Jingru，ZHANG Yongshuang，WU Shuren，et al. Rigidity criterion for rockburst in the Yufengsi tunnel in Lijiang City of the Yunnan—Tibet Railway[J]. Geological Bulletin of China，2007，26(6)：748-755.(in Chinese))
[27]	鞠文君，卢志国，高富强，等. 煤岩冲击倾向性研究进展及综合定量评价指标探讨[J]. 岩石力学与工程学报，2021，40(9)：1 839- 1 856.(JU Wenjun，LU Zhiguo，GAO Fuqiang，et al. Research progress and comprehensive quantitative evaluation index of coal rock bursting liability[J]. Chinese Journal of Rock Mechanics and Engineering，2021，40(9)：1 839-1 856.(in Chinese))
[28]	齐庆新，彭永伟，李宏艳，等. 煤岩冲击倾向性研究[J]. 岩石力学与工程学报，2011，39(增1)：2 736-2 742.(QI Qingxin，PENG Yongwei，LI Hongyan，et al. Study of bursting liability of coal and rock[J]. Chinese Journal of Rock Mechanics and Engineering，2011，39(Supp.1)：2 736-2 742.(in Chinese))
[30]	金立平，鲜学福. 煤层冲击倾向性试验研究及模糊综合评判[J]. 重庆大学学报：自然科学版，1993，(6)：114-119.(JIN Liping，XIAN Xuefu. The study of outburst-proneness of coal seam via experiments and fuzzy comprehensive judgement[J]. Journal of Chongqing University，1993，(6)：114-119.(in Chinese))
[33]	刘恺德，刘泉声，朱元广，等. 考虑层理方向效应煤岩巴西破裂及单轴压缩试验研究[J]. 岩石力学与工程学报，2013，32(2)：308- 316.(LIU Kaide，LIU Quansheng，ZHU Yuanguang，et al. Experimental study of coal considering directivity effect of bedding plane under Brazilian splitting and uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering，2013，32(2)：308-316.(in Chinese))
[35]	雷顺，高富强. 实验室煤体变形特征分析及弹性模量关联模型[J]. 采矿与岩层控制工程学报，2021，3(4)：049922.(LEI Shun，GAO Fuqiang. Laboratory study on deformation characteristics of coal mass and correlation model of elastic modulus[J]. Journal of Mining and Strata Control Engineering，2021，3(4)：049922.(in Chinese))
[37]	中华人民共和国国家标准编写. GB/T 25217.2—2010冲击地压测定、监测与防治方法第2部分：煤的冲击倾向性分类及指数的测定方法[S]. 北京：中国标准出版社，2010.(The National Standards Compilation Group of People?s Republic of China. GB/T 25217.2—2010 Methods for test，monitoring and prevention of rock burst-Part 2：Classification and laboratory test method on bursting liability of coal[S]. Beijing：Standards Press of China，2010.(in Chinese))
[24]	KHOSRAVI A，SIMON R. Verification of the CSDS model in estimating the postpeak behavior of hard rocks[J]. International Journal of Geomechanics，2018，18(3)：04017166.1-04017166.15.
[31]	潘一山，耿琳，李忠华. 煤层冲击倾向性与危险性评价指标研究[J]. 煤炭学报，2010，35(12)：1 975-1 978.(PAN Yishan，GENG Lin，LI Zhonghua. Research on evaluation indices for impact tendency and danger of coal seam[J]. Journal of China Coal Society，2010，35(12)：1 975-1 978.(in Chinese))
[41]	张绪言，冯国瑞，康立勋，等. 用剩余能量释放速度判定煤岩冲击倾向性[J]. 煤炭学报，2009，34(9)：1 165-1 168.(ZHANG Xuyan，FENG Guorui，KANG Lixun，et al. Method to determine burst tendency of coal rock by residual energy emission speed[J]. Journal of China Coal Society，2009，34(9)：1 165-1 168.(in Chinese))
[26]	潘岳，王志强，李爱武. 岩石失稳破裂的综合刚度和综合能量准则[J]. 岩土力学，2009，30(12)：3 671-3 676.(PAN Yue，WANG Zhiqiang，LI Aiwu. Comprehensive rigidity and comprehensive energy criterion of the rock burst[J]. Rock and Soil Mechanics，2009，30(12)：3 671-3 676.(in Chinese))
[36]	戴福隆，沈观林，谢惠民. 实验力学[M]. 北京：清华大学出版社，2010：190-191.(DAI Fulong，SHEN Guanlin，XIE Huimin. Experimental mechanics[M]. Beijing：Tsinghua University Press，2010：190-191.(in Chinese))
[46]	肖晓春，樊玉峰，吴迪，等. 组合煤岩破坏过程能量耗散特征及冲击危险评价[J]. 岩土力学，2019，40(11)：4 203-4 212.(XIAO Xiaochun，FAN Yufeng，WU Di，et al. Energy dissipation feature and rock burst risk assessment in coal-rock combinations[J]. Rock and Soil Mechanics，2019，40(11)：4 203-4 212.(in Chinese))
[34]	李顺才，李大权，张农，等. 煤样抗压强度与弹性模量的多元回归模型[J]. 湖南科技大学学报：自然科学版，2020，35(1)：1-9.(LI Shuncai，LI Daquan，ZHANG Nong，et al. Multiple regression models for compressive strength and elastic modulus of coal samples[J]. Journal of Hunan University of Science and Technology：Natural Science，2020，35(1)：1-9.(in Chinese))
[44]	谭彦，郭伟耀，谭云亮，等. 巷道近场围岩能量释放规律及诱冲机制[J]. 煤炭学报，2021，46(增2)：609-620.(TAN Yan，GUO Weiyao，TAN Yunliang，et al. Energy release law of roadway surrounding rock and energy-driven rock burst mechanism[J]. Journal of China Coal Society，2021，46(Supp.2)：609-620.(in Chinese))
[42]	宫凤强，赵英杰，王云亮，等. 煤的冲击倾向性研究进展及冲击地压“人-煤-环”三要素机制[J]. 煤炭学报，2022，47(5)：1 974- 2 010.(GONG Fengqiang，ZHAO Yingjie，WANG Yunliang，et al. Research progress of coal bursting liability indices and coal burst “human-coal-environment”three elements mechanism[J]. Journal of China Coal Society，2022，47(5)：1 974-2 010.(in Chinese))